Huge win for car owners! All TSBs to be made public. The Center for Auto Safety just made the NHTSA (US Government) make public the full text of all TSBs from now on. They are the same organization that has petitioned the NHTSA & filed lawsuits to protect car owners over exploding gas tanks & other major safety issues. Whenever you drive in your car, you are safer thanks in part to a lot of work over the years by this small but very effective consumer advocacy group.

Please take a moment & say thank you by donating $5 or whatever you can to the Center for Auto Safety.

2.8

hardly worth mentioning
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
51,000 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2004 Honda Pilot fuel system problems

fuel system problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2004 Honda Pilot:

Unsubscribe any time. We don't sell/share your email.

2004 Honda Pilot Owner Comments

problem #3

Oct 072013

Pilot 6-cyl

  • miles

A D V E R T I S E M E N T S

Gas can be empty and when you attempt to fill up tank it shuts off as if tank is full. Spent $400.15 on 10/25/13 for fuel vapor control valve yonder dealer thought this might be causing it. This worked for few weeks then it began again but seemed to let us fill it up if we drove for a few miles before attempting to fill up the gas tank. Now it doesn't matter how far we drive the car the gas will not pump into the tank it can take us up to 30 minutes to pump a few gallons of gas. The Honda dealer is as much of a loss as to what is causing this to take place. The car has not been involved in any accidents and is causing extreme stress as to how and what it will take to get the gas to pump correctly.

- Phoenix, AZ, USA

problem #2

Jun 012012

Pilot

  • 105,000 miles
The contact owns a 2004 Honda Pilot. The contact stated while adding gasoline to the fuel tank it would spill out preventing the contact from adding fuel to its capacity. While inside the vehicle the contact also smelled a strong odor of gasoline. The vehicle was taken to the dealer for diagnostic testing where they stated that the gasoline valve caused the failure and needed to be replaced. The vehicle was repaired; however, the failure recurred immediately. The manufacturer was later contacted and advised the contact to have the dealership diagnose the failure. The failure mileage was approximately 105,000. The current mileage was approximately 120,000. Updated 2/25/13 the rv valve was replaced. However, the problem continued. The consumer stated the problem had been going on for over a year. Honda could not give her a definitive answer as tow hat the problem was. The consumer was unable to completely fill the gas tank. Updated 03/07/13

- Long Wood, FL, USA

problem #1

Jan 032008

Pilot 6-cyl

  • Automatic transmission
  • 48,000 miles
Vtm-4 light and check engine light illuminating. Was told that gas cap being loose may cause this to happen but I have been ensuring that it is properly seated every time I refil the vehicle.

- Merrimack, NH, USA

Not what you are looking for?