1997 Lincoln Town Car
1997 Defect Investigations
There are also 7 Lincoln recalls » 14 defect investigations » 134 TSBs » for the Lincoln Town Car.
SPARK PLUG EJECTION FROM CYLINDER HEAD: Engine And Engine Cooling**
no recall issued
** This defect investigation is filed under 3 related vehicle components.
1997 LINCOLN TOWN CAR -- On September 6, 2005, ODI received a petition requesting that the Agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 Ford vehicles with Triton V-8 and V-10 engines. ODI received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine. As of December 8, 2005, ODI is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles. In addition, ODI is aware of only two incidents where the vehicle stalled without restart. Information contained in the ODI consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on MY 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall. In the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine. In one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire. In another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location. None of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident. As the petitioner noted, and ODI¿S analysis showed, it is possible for a spark plug to detach from the engine cylinder threads in the subject vehicles. However, ODI¿S analysis of 474 complaints describing such incidents found only a very few alleged any safety-related consequences. None of these showed any evidence of a serious safety consequence. Given the large population and relatively long exposure time of the subject vehicles, the complaint analysis indicates that the risk to motor vehicle safety from the alleged defect is very low. In view of the foregoing, it is unlikely that NHTSA would issue an order for the notification and remedy of the alleged defect at the conclusion of the investigation requested in the petition. Therefore, in view of the need to allocate and prioritize NHTSA¿S limited resources to best accomplish the Agency¿S safety mission, the petition is denied.
Investigation was initiated on September 22 2005. Closed on January 04 2006. For detailed information & supporting documents, see the official NHTSA page concerning investigation #DP05005 »
SPEED CONTROL DEACTIVATION SWITCH FIRES: Engine And Engine Cooling
no recall issued
1997 LINCOLN TOWN CAR -- Based on the low rate of fire incidents (2.5 incidents per 100,000 vehicles sold) where failure of the scds is involved and the age of the vehicles ¿ 7 to 11 years ¿ a safety-related defect trend has not been identified and further use of Agency resources does not appear to be warranted. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The Agency reserves the right to take further action if warranted by the circumstances. For additional information, see the attached closing report. Investigation was initiated on September 06 2002. Closed on June 30 2004. For detailed information & supporting documents, see the official NHTSA page concerning investigation #EA02025 »
NHTSA Defect Investigation #SQ01014POST REAR END COLLISION FIRES: Fuel System, Gasoline:Storage
Recall #02I003000
1997 LINCOLN TOWN CAR -- Allege fuel tank can rupture following a high-energy rear collision resulting in severe fires. Investigation was initiated on November 27 2001. Closed on October 03 2002. For detailed information & supporting documents, see the official NHTSA page concerning investigation #SQ01014 »
NHTSA Defect Investigation #EA03012REAR BRAKE LINE FAILURE: Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings**
Recall #05V086000
** This defect investigation is filed under 3 related vehicle components.
1997 LINCOLN TOWN CAR -- In a letter dated February 25, 2005, Ford motor company (Ford) notified ODI that it would be conducting a customer satisfaction program (Ford no. 04B26) to correct a rear brake line chafing concern in approximately 44,000 model year (MY) 1997 Ford Crown Victoria and Grand Marquis non-fleet vehicles equipped with electronic traction control that werebuilt after March 19, 1997. These vehicles have an additional rear brake line and a mastic patch causing reduced clearance from a stiffening rib in the floor pan. ODI¿S analysis showed higher complaint and warranty rates related to rear brake line failures in this population than in other subject vehicles and peer mid-sized passenger cars that were evaluated during the investigation. Vehicles involved in Ford¿S program will have the rear brake lines inspected for contact with the floor pan stiffing rib. If there is contact, but no abrasion or leakage, the brake lines will be repositioned. If there is abrasion or a leak is evident the brake line will be repaired. If necessary, both of the rear brake lines will be replaced. Though Ford does not admit to a safety-defect in the subject components, ODI believes that the facts in this investigation show otherwise because the insufficient clearance in the routing of those brake lines may result in leaks in those lines that may result in increased stopping distances. ODI is designating the campaign a safety recall (NHTSA recall no. 05V-086). Because of the low rates of brake line failures in the remaining subject vehicles, a safety-related defect has not been identified in those populations and further use of Agency resources does not appear to be warranted. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists in those vehicles. The Agency reserves the right to take further action if warranted by the circumstances. For additional information, see the attached closing report.
Investigation was initiated on July 25 2003. Closed on April 11 2005. For detailed information & supporting documents, see the official NHTSA page concerning investigation #EA03012 »
REAR BRAKE LINE FAILURE: Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings**
no recall issued
** This defect investigation is filed under 4 related vehicle components.
1997 LINCOLN TOWN CAR -- ODI has received 40 complaints alleging rear brake line failure in the subject vehicles, including 8 that have been received this year. An additional 192 reports and 478 warranty claims have been received from Ford. A leak in the rear brake line can cause extended stopping distance. A search of ODI's complaint database for peer vehicle complaints, using the same brake line failure criteria as for the subject vehicles and the same model years (1995-97), identified only 1 complaint involving General Motors caprice/implala/88/98/regal vehicles and only 2 complaints involving Chrysler LH-cars. The investigation has been upgraded to an engineering analysis to further evaluate the frequency, scope, and causal factors related to rear brake line failures in the subject vehicle population.
Investigation was initiated on March 11 2003. Closed on July 25 2003. For detailed information & supporting documents, see the official NHTSA page concerning investigation #RQ03004 »
BALL JOINT SEPARATION: Suspension:Front:Control Arm:Lower Ball Joint
no recall issued
1997 LINCOLN TOWN CAR -- See attached report. Investigation was initiated on January 03 2003. Closed on June 03 2003. For detailed information & supporting documents, see the official NHTSA page concerning investigation #RQ03002 »
NHTSA Defect Investigation #DP02007FUEL-FED FIRES: Vehicle Speed Control:Linkages
no recall issued
1997 LINCOLN TOWN CAR -- The fars data shows that the risk of fire from impact in all directions in the subject vehicles is the same as all other sedans. The subject vehicles are not over represented with respect to the risk of fire in real-world high-energy crashes. A further discussion of issues related to post crash fires in the subject vehicles is set out in the closing report for sq 01-014 and that report is in the docket for this petition. After reviewing the petition and its supporting materials, as well as information furnished by Ford and GM, and information within the Agency's possession from previous investigations and other related actions,NHTSA has concluded that futher investigation concerning post-crash fires in the subject vehicles is not likely to lead to a decision that the vehicles contain a safety defect. Investigation was initiated on August 22 2002. Closed on December 04 2002. For detailed information & supporting documents, see the official NHTSA page concerning investigation #DP02007 »