This car has less than 37,000 miles on it it has significant oil leaks from the valve cover gasket, it-??s timing cover gasket and now it had been determined it has a cracked cylinder head. This was covered by 3 Service alerts with the cracked cylinder head being SA-031/21. None of the dealers notified us of the issue when serviced Galpin Mazda and New Century Mazda. But Big O Tires did. The two oil leak gasket repairs cost over $1600. The car is 8 months past warranty. The car is burning oil when driven. Due to the leak and the smoke particles and smell enter the cabin. The engine smokes when shut down instill it cold down. The smoke particles in the cabin are dangerous. The engine oil light appeared in late November (my daughter-??s car, she is away at college). We found out the depth of the oil leak issues the second and fourth week of December. The fact that the dealers did not notice us or do preemptive repairs is a major failure by the Mazda organization.

- Pasadena, CA, USA

Brought 2019 Cx-5 to local dealer with complaint of strong smell and smoke coming from hood. Cracked cylinder head at only 21k miles. Known flaw for this particular make and model. Only 6 months out of warranty. Mazda refuses to make it right and only extended warranty for turbo engines. Mazda needs to make this right for ALL engines with this issue.

- Aston, PA, USA

The 2019 has a creaked cylinder with 40000 miles on it. This is a problem with that has been happening. We are 4 months out of the warranty with May 2024.

- Lincoln, NE, USA

My Mazda CX-5 was found to have a cracked cylinder in the engine and was profusely leaking oil. When I spoke to the dealership they denied seeing this regularly, however, upon doing research on reddit, it is found to be more pronounced than indicated. There was no known cause indicated, however, on reddit it appears that the original casting done in Mexico maybe the culprit because it is so thin and causes it to crack between 40-50k miles. There is no other sign or warnings, besides an obscene amount of oil leaking. The failure of this could cause the engine to fail while driving. This is a significant risk.

- Glen Allen, VA, USA

Vehicle has 40k after a oil change noticed oil spots on pavement took it back to the garage that did the task, was told that the leak was near cylinder #2. Called Mazda customer service and was informed that my warranty expired in May of 2024. my mechanic called Mazda parts to get the price of cylinder head and was told that they had a run on cylinder heads due to defective heads coming from the Factory, SHOULD BE A RECALL ON THE MAZDA.

- Clearwater, FL, USA

The head gasket cover is leaking leading to a great deal of smoke. The car should not be driven per my mechanic due to risk of fire

- Seymour, CT, USA

I have 115k miles on my 2019 CX5. Never has any issues. Now all of a sudden I have a cracked cylinder head leaking oil. I was smelling smoke but mot seeing it. I took into dealership they noticed oil dripping thus why smell. Its a $4500-5000 job. I cannot afford this. This should not happen at this kind of mileage. My warranty just expired too. Mazda needs to cover these type of repairs

- York, PA, USA

The vehicle starting stalling, check engine light would come on, and the vehicle would slipped into -??limp mode-?? while traveling on the freeway. I was amount in two auto collisions because of the vehicle slowing down in the middle of the highway. The problem started in August 2023 and was towed to the dealer on one occasions and towed to my home on another occasion. The dealer ran a diagnostic and said it was the brand new battery I had installed and then the catalytic converter. After repairing both; the vehicle proceeded to not drive over 30 miles per hour. The dealer said it was the engine and then said it was something else. I-??ve expressed that the symptoms are those more aligned to the PCM issue recalled on 2019. A actual diagnostic report from Auto Zone supports this. The vehicle has also been inspected by another Mazda dealer and a stand alone mechanic.

- Katy , TX, USA

At 49k miles and 4 months out of warranty, the car began leaking oil and smelling like smoke. The dealer diagnosed with a cracked cylinder head and repaired it.

- Aurora, CO, USA

CX5 Cylinder head cracked at 53,500 miles. Was driving when received engine overheating and pull over immediately warning. The car smelled like maple syrup as it was engine coolant burning. Took it to the dealership and they informed me of the cylinder failure. It is currently awaiting parts and its not under warranty.

- Fairfax, VA, USA

Cracked cylinder head requiring replacement at 62,000 miles.

- Rancho Palos Verdes, CA, USA

While driving, I received a warning that the engine in my car was overheating. Upon arriving home and parking, I noticed pooling under the car. My car was due for an oil change so the next day I dropped off the car for the oil change and mentioned the overheating message and leak to the technician thinking the fix would be routine. To my surprise, I was told my vehicle had a serious coolant leak related to a cracked cylinder. I was advised to take the vehicle to a Mazda dealer. Morrie's Mazda in Minnetonka, MN confirmed the cracked cylinder head which required a full engine replacement despite the car being only ~5 years old and having ~63,000 miles. Mazda had issued a technical service bulletin on this issue but had not issued a recall. As a result, I was left with a large repair bill to replace the engine in a relatively new car. This is a serious issue and I feel Mazda put my life and others in jeopardy by not recalling vehicles and letting customers drive with the risk of the engine overheating.

- Saint Louis Park, MN, USA

Coolant leaks at cylinder head on 2019 Mazda CX-5 Grand Touring Reserve. Mazda North American Operations released a technical service bulletin (01-013/21) regarding 2016-2020 Mazda CX-5, CX-9, and Mazda6 with SKYACTIV-G 2.5T engines. This issue can cause the engine to leak coolant, overheat, and stall, potentially leaving the driver and passengers stranded in an unsafe location. Mazda is aware of this manufacturing defect but has not recalled these engines to be repaired or replaced if they are outside of their manufacturers warranty period and placing costly repairs and potentially life-threatening situations as the responsibility to their customers. The diagnosis to repair this issue is a replacement of the cylinder head/sleeve or replacement of the engine block, which has since been modified by Mazda to resolve this issue. This is a costly repair for diagnostics, labor hours, and parts and Mazda is refusing to be held responsible for these defects outside of the power train warranty period. Mazda customer support advised this will only be potentially covered if diagnostics are completed at a Mazda dealership and does not provide any assistance if the customer uses a non-Mazda affiliated repair shop. Messaging on the dash console advised excessive heat and thermostat was nearing 260?F

- Cheektowaga, NY, USA

Started smelling smoke randomly and discovered an apparent oil leak in the engine. Mechanic inspected and noted that it appears to be an issue relating to the cylinder head/head gasket, which is in line with a technical services bulletin put out by Mazda several years ago for this make/model/year for a known design flaw that can result in catastrophic engine failure. I am just outside the five year warranty but well under the 60,000 miles, so expecting them to tell me they won't cover the repair even though this should have been a recall due to the potential outcome. I cannot drive the vehicle until this is repaired because it can cause engine fires (or worse).

- Linthicum, MD, USA

There is a coolant leak at the cylinder head. We have been told that the cylinder is cracked at the back of the cylinder head where the exhaust ports meet. The dealer's technician said there is a "redesign" in the cylinder head. This is a known issue that is a defect apparently due to Mazda's design of securing the turbo on exhaust studs that are not designed to hold the weight. Why has there not been a recall? There is a Mazda TSB - 01-013/21, issued 10/15/2021 Verbal estimate from dealer for repair - over $7,000

- Tallahassee, FL, USA

My vehicle started smoking and I smelled a oil burning smell coming through the vents. I took it to the Mazda dealership and they diagnosed it with a cracked cylinder head. The repair estimate is $4,900. It is a 2019 with less than 60,000 miles, but it is a few months out of the powertrain warranty. However, this is a KNOWN issue to Mazda. As I have been researching online, many Mazda CX-5 owners have reported the same issue and I believe Mazda has traced it back to defective manufacturing in a batch of these parts. My local mechanic has also told us that he has seen this issue with 2019 Mazda CX-5s and recommended we report them. Mazda SHOULD issue a recall, but I understand that is expensive for them. At the very least, they should alerting drivers to this possibility and voluntarily repairing these cylinders without cost to unsuspecting drivers who could end up with an engine fire. I have submitted a complaint to Mazda customer service and I am awaiting a response.

- Allendale, NJ, USA

I am writing to express serious concerns regarding the recent service that occurred on November 14th, 2023. Due to the service's failure and negligence, Luther Brookdale Mazda has jeopardized the safety and well-being of my family members. On [XXX], my 2019 CX-5 was towed from Monticello, Minnesota, to the dealership in Brooklyn Center around 9 pm. While returning from [XXX] dinner in St. Cloud on [XXX], a sudden warning appeared on the dashboard: "Engine Coolant Temperature High. Stop the vehicle immediately in a safe place." Upon receiving this notification, we pulled over to the shoulder and observed smoke emanating from the engine bay. We promptly turned off the vehicle. Concerned for our safety, we contacted our family to pick us up and had the vehicle towed by AAA. As we awaited the tow truck's arrival, we noticed coolant had sprayed all over the engine under the hood, and the engine cover was missing. Furthermore, the coolant reservoir was below the minimum threshold. This particular issue is the reason I brought the vehicle in for service the week prior, regarding insufficient coolant temperature. It was evident from the state of the engine bay that the dealership failed to follow proper protocol. This lack of oversight likely resulted in damage to the engine and other essential vehicle components, leading to the total loss of the car. I am deeply disappointed by the lack of care and attention to detail in the service provided. This negligence also compromised my family's safety. Moreover, what was meant to be a festive holiday was marred due to the disregard for my property. I have been a loyal customer at Luther Mazda Brooklyn Park for several years, and I am shocked by the incident that has transpired. We have approached the dealer with the issue and they are continue to articulate that there is no engine damage, but with the ongoing class action lawsuit, I am extremely skeptical of their claims. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Minneapolis, MN, USA

This report is for a 2019 Mazda CX-5 with the Naturally Aspirated/Non-Turbo engine. This vehicle only has 26,500 miles and has developed a major oil leak from a cracked Cylinder Head. The continued safety of the vehicle has been degraded. The engine could seize while driving making the vehicle inoperable while on roadways. The vehicle has been inspected and confirmed by both an independent service center and by an authorized dealer service center. The only warning lamp that appeared was a low oil light. I immediately pulled over for safety and inspected the oil levels of the engine. I determined the engine oil levels were just below the fill line on the dip stick. I then added approximately half a quart of recommended oil and the oil warning light turned off. I then contacted a local service center for diagnostics of the problem. They determined the cause of the oil leak which was a Cracked Cylinder Head on the Engine. I then drove the vehicle to an authorized Mazda service center at the dealership. They also diagnosed the problem as a Cracked Cylinder Head on the Engine. Both the independent service center and the authorized Mazda service center recommended a full Engine replacement.

- St George, UT, USA

I have a 2019 CX5 Mazda that consistently leaks oil and smokes. After taking it to a mechanic, I learned that this is a known Mazda issue, but because my car is under warranty, they won't help me. The Cylinder head is pours, and my mechanic said even if he replaces it, it will happen again due to the design. After I have checked online, it seems that MANY people have this issue from 2018-2021. Mazda even made TSB #SA-031-21 to cover some of this issue but no recall. As mentioned, my car leaks oil everyday, and I have to constantly put oil in just to keep it from burning up. It smokes really bad, but I cannot afford a new car or afford to pay over $3K to get this fixed, or don't understand why they won't fix it if they know it was poor design"?"

- Morongo Valley, CA, USA

UNKNOWN. Vehicle stalls and jumps when I step on the gas pedal or try to increase speed.

- Charlotte, NC, USA