NHTSA Campaign #08E050000 EXTERIOR LIGHTING:HEADLIGHTS

AUGUST 11
2008

1,921 vehicles recalled

2001 CHEVROLET CAVALIER -- K2 motor is recalling 1,921 aftermarket headlamps of various models sold for use on the above listed vehicles. These headlamps are missing the amber side reflex reflector which fails to conform with the requirements of Federal Motor Vehicle Safety Standard no. 108, "Lamps, Reflective Devices, And Associated Equipment."

Without the amber side reflex reflectors, the lighting visibility may be affected, possibly resulting in a vehicle crash.

K2 motor will notify owners and offer a full refund. The recall is expected to begin during September 2008. Owners may contact K2 motor at 1-909-839-2992. For detailed information & supporting documents, see the official NHTSA page concerning recall #08E050000 »

NHTSA Campaign #07E021000 FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES

MARCH 12
2007

742 vehicles recalled

2001 CHEVROLET CAVALIER -- Certain delphi fuel pressure regulators, P/nos. FP10020-11B1, FP10026-11B1, and FP10027-11B1, sold after January 9, 2007, as aftermarket equipment for various passenger vehicles listed above. The universal pressure regulators (upr) were produced without an O'ring and retainer.

Fuel may leak, possibly resulting in a fire.

Delphi will notify owners and replace the upr free of charge. The recall began on April 23, 2007. Owners can contact delphi at 877-411-8770. For detailed information & supporting documents, see the official NHTSA page concerning recall #07E021000 »

NHTSA Campaign #06E026000 EXTERIOR LIGHTING

MARCH 23
2006

61,944 vehicles recalled

2001 CHEVROLET CAVALIER -- Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.

Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Pro-a motors will notify owners and offer to repurchase the lamps. The recall began on April 3, 2006. Owners may contact pro-a motors at 323-838-2988. For detailed information & supporting documents, see the official NHTSA page concerning recall #06E026000 »

NHTSA Campaign #04V036000 ELECTRICAL SYSTEM:IGNITION:SWITCH

JANUARY 27
2004

1,415,231 vehicles recalled

2001 CHEVROLET CAVALIER -- On certain passenger vehicles. If the engine fails to start and the driver holds the key in the "start" position for an extended period, high current flows through the ignition switch, and sometimes produces enough heat to melt internal switch parts.

If the switch is damaged, a fire could occur in the steering column, even with the engine off and the key removed. The fire could spread to the interior of the car, which could injure occupants or cause damage to adjoining structures.

Dealers will install a relay kit in these vehicles to prevent high current from flowing through the ignition switch, and check that your car will start with a properly charged battery and, if necessary, replace the ignition switch. Owner notification will begin on March 1, 2004. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Chevrolet at 1-800-630-2438, Pontiac at 1-800-620-7668, Buick at 1-866-608-8080, or Oldsmobile at 1-800-630-6537. Customers can also check their vehicle online by going to www.mygmlink.com and entering the vehicle's identification number. For detailed information & supporting documents, see the official NHTSA page concerning recall #04V036000 »