Technical Service Bulletins (TSBs) for the 2006 Kodiak are official communications between Chevrolet & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
GMC/CHEVROLET: FLUID LEAK AT STEERING GEAR INPUT SHAFT. ALL C SERIES MODELS. WHEN REPAIRING A POWER STEERING FLUID LEAK AT THE STEERING GEAR INPUT SHAFT STUB SEAL BEWARE THAT THE PRESSURE SEAL IS NOT AVAILABLE FROM GM SPO PARTS. Read More »
CHEVROLET/GMC: REPLACEMENT REAR STABILIZER BAR (RELOCATE LINK BRACKETS). IF THE REAR STABILIZER BAR NEEDS REPLACING, THE NEW BAR IS SHORTER AND WILL REQUIRE RELOCATION OF THE STABILIZER BAR LINK BRACKETS. Read More »
This warranty administration bulletin provide policy information on a revised customer concern not duplicated/verified labor operation numbers and how to submit CCND. Read More »
GMC/CHEVROLET: SERVICE BRAKE SOON INDICATOR WITH DTC C0272. SOME CUSTOMERS MAY STATE THE SERVICE BRAKE SOON INDICATOR COMES ON. MAY ALSO COMMENT THE AUDIBLE BRAKE WARNING BUZZER IS SOUNDING. Read More »
CHEVROLET/GMC: BRAKE ASSIST PUMP MOTOR ON AND WARNING LIGHT/CHIME. OWNERS MAY COMMENT WHEN TURNING THE STEERING WHEEL WITH THE BRAKE APPLIED THAT THE HYDRAULIC BRAKE ASSIST PUMP TURNS ON AND THE BRAKE WARNING LAMP AND CHIME MAY SOUND. Read More »
CHEVROLET/GMC: BRAKE ASSIST PUMP MOTOR ON AND WARNING LIGHT/CHIME. OWNERS MAY COMMENT WHEN TURNING THE STEERING WHEEL WITH THE BRAKE APPLIED THAT THE HYDRAULIC BRAKE ASSIST PUMP TURNS ON AND THE BRAKE WARNING LAMP AND CHIME MAY SOUND. Read More »
CHEVROLET/GMC: BRAKE ASSIST PUMP MOTOR ON AND WARNING LIGHT/CHIME. OWNERS MAY COMMENT WHEN TURNING THE STEERING WHEEL WITH THE BRAKE APPLIED THAT THE HYDRAULIC BRAKE ASSIST PUMP TURNS ON AND THE BRAKE WARNING LAMP AND CHIME MAY SOUND. Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
GMC/CHEVROLET: THE SPEEDOMETER IS INOPERATIVE, ABS LAMP MAY BE ON AND IF EQUIPPED THE TRANSFER CASE MAY NOT SHIFT OR MAKE RANDOM PHANTOM SHIFTS. MODELS INCLUDE THE KODIAK AND TOPKICK 4500/5500 SERIES. Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR
ISUZU/GMC/CHEVROLET: DIAGNOSTIC INFORMATION FOR INOPERATIVE AIR SEATS, AIR HORN AND/OR EXHAUST BRAKE AND RELEASE OF NEW AUXILIARY AIR COMPRESSOR RELAY AND PRESSURE SWITCH ON RPO K16 VEHICLES. *PE Read More »
SERVICE BRAKES, AIR:SUPPLY:LOW PRESSURE WARNING:SWITCH
ISUZU/GMC/CHEVROLET: DIAGNOSTIC INFORMATION FOR INOPERATIVE AIR SEATS, AIR HORN AND/OR EXHAUST BRAKE AND RELEASE OF NEW AUXILIARY AIR COMPRESSOR RELAY AND PRESSURE SWITCH ON RPO K16 VEHICLES. *PE Read More »
GMC/CHEVROLET: THE SPEEDOMETER IS INOPERATIVE, ABS LAMP MAY BE ON AND IF EQUIPPED THE TRANSFER CASE MAY NOT SHIFT OR MAKE RANDOM PHANTOM SHIFTS. MODELS INCLUDE THE KODIAK AND TOPKICK 4500/5500 SERIES. Read More »
This informational bulletin provides information on close coupled converters and there affect on newly installed engines or engines during there break in period. Read More »
GMC/CHEVROLET: ENGINES, WITH EGR SYSTEM, HAS LEAKAGE FROM EGR COOLER ENGINE COOLANT INTO THE COMBUSTION CHAMBER. MODEL 2002-15 SILVERADO, SIERRA, 2004-09 KODIAK C4500-C5500, TOPKICK C4500-C5500, 2006-15 EXPRESS, SAVANA. Read More »
This informational bulletin provides information to technicians regarding intake manifold inspection/replacement after severe internal engine damage. Read More »
This technical bulletin provides repair information for repairing the IP to body harness connector to correct a customer concern for intermittent Malfunction Indicator Lamp (MIL) illuminated with Reduced Engine Power displayed and DTC ... Read More »
This informational bulletin provides information to technicians regarding intake manifold inspection/replacement after severe internal engine damage. Read More »
This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or ... Read More »
This informational bulletin provides information on the proper oils to use on GM vehicles including information regarding the differences of the Dexos oils. Read More »
LBZ, LLY, ENGINE WITH ROUGH IDLE, POOR PERFORMANCE, BLACK/WHITE EXHAUST SMOKE, MIL/SES LIGHT ON AND ONE OR MORE OF THE FOLLOWING DTC'S P003A, P060B, P0230, P0403, P0401, P0606, P2146, P2149, P2152, P2155. Read More »
REDUCED ENGINE POWER, SES LIGHT ILLUMINATED, DTC'S P0107 OR P0108 SET DUE TO MAP SENSOR DISCONNECTION (REPLACE AIR CLEANER ASSEMBLY AND RECONNECT MAP SENSOR CONNECTOR). *KB Read More »
OIL SEEPAGE FROM TURBO AIR CHARGE COOLER HOSES OR HOSE BLOWING OFF DURING ACCELERATION. POSSIBLE DIAGNOSTIC TROUBLE CODE P0299. *TT UPDATED 04-24-07. *KB Read More »
GM: AN 'ENGINE POWER IS REDUCED' MESSAGE APPEARS AND THERE IS A STORED TROUBLE CODE. THIS IS CAUSED BY WEAR OF THE INTERNAL FUEL INJECTOR. *RM Read More »
GENERAL MOTORS: LBZ, LLY, LMM MIL/SES LIGHT N DTC P0087-FUEL RAIL PRESSURE (FRP) TOO LOW, LACK OF PERFORMANCE, NO POWER, ENGINE RUNS ROUGH, NO START (DIAGNOSE FUEL SYSTEM COMPONENTS). *PE UPDATED 3/1/10. Read More »
This warranty administration bulletin provide policy information on a revised customer concern not duplicated/verified labor operation numbers and how to submit CCND. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
GMC/CHEVROLET: ENGINES, WITH EGR SYSTEM, HAS LEAKAGE FROM EGR COOLER ENGINE COOLANT INTO THE COMBUSTION CHAMBER. MODEL 2002-15 SILVERADO, SIERRA, 2004-09 KODIAK C4500-C5500, TOPKICK C4500-C5500, 2006-15 EXPRESS, SAVANA. Read More »
This informational bulletin provides dealership personnel with information on flexible fuel vehicles (FFVs) and the usage of E85 fuel in GM vehicles. Read More »
This informational bulletin provides technicians with information regarding automatic transmission oil cooler flow test essential tool J-45096 TransFlow?. Read More »
This Preliminary Information communication provides information to the technician about vehicles that have not engagement into drive, delayed, no engagement into reverse, and or a range inhibit. Read More »
CHEVROLET/GMC: DELAYED OR NO DRIVE AND DELAYED OR NO REVERSE WITH DTC'S, RANGE INHIBIT. MODEL YEARS 2001-2013. *PE UPDATED ON 06/08/2011. *KB UPDATED ON 06/16/2011. *KB UPDATED 11/26/12. Read More »
This informational bulletin provides technicians with information regarding automatic transmission oil cooler flow test essential tool J-45096 TransFlow?. Read More »
This Preliminary Information communication provides information to the technician about vehicles that have not engagement into drive, delayed, no engagement into reverse, and or a range inhibit. Read More »
GMC/CHEVROLET: THE SPEEDOMETER IS INOPERATIVE, ABS LAMP MAY BE ON AND IF EQUIPPED THE TRANSFER CASE MAY NOT SHIFT OR MAKE RANDOM PHANTOM SHIFTS. MODELS INCLUDE THE KODIAK AND TOPKICK 4500/5500 SERIES. Read More »
GMC/CHEVROLET: THE SPEEDOMETER BEING INOPERATIVE AND/OR THE SES MIL ON. WHEN CHECKING FOR DTCS THE ECM WILL HAVE A P0502 OR P0500 SET. THIS ISSUE MAY BE INTERMITTENT AND FOLLOWING NORMAL DIAGNOSITC IN SI2000 MAY NOT LEAD TO A CORRECTION. Read More »
This warranty administration bulletin provide policy information on a revised customer concern not duplicated/verified labor operation numbers and how to submit CCND. Read More »
This technical bulletin provides repair information for repairing the IP to body harness connector to correct a customer concern for intermittent Malfunction Indicator Lamp (MIL) illuminated with Reduced Engine Power displayed and DTC ... Read More »
This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Read More »
This warranty administration bulletin provide policy information on a revised customer concern not duplicated/verified labor operation numbers and how to submit CCND. Read More »
ISUZU/GMC/CHEVROLET: DIAGNOSTIC INFORMATION FOR INOPERATIVE AIR SEATS, AIR HORN AND/OR EXHAUST BRAKE AND RELEASE OF NEW AUXILIARY AIR COMPRESSOR RELAY AND PRESSURE SWITCH ON RPO K16 VEHICLES. *PE Read More »
CHEVROLET/GMC: WIRE HARNESS CHAFES NEAR AIR CLEANER AND DUCTWORK. MAY ENCOUNTER A CONCERN OF REDUCED POWER MODE OR THE SES LIGHT ON WITH DTCS P0101, P0106, P0107, P0108, P0299, P0652 SETTING. Read More »
GMC/CHEVROLET: THE SPEEDOMETER IS INOPERATIVE, ABS LAMP MAY BE ON AND IF EQUIPPED THE TRANSFER CASE MAY NOT SHIFT OR MAKE RANDOM PHANTOM SHIFTS. MODELS INCLUDE THE KODIAK AND TOPKICK 4500/5500 SERIES. Read More »
This informational bulletin provides information to advise dealers about seat belt buckles not operating and/or seat belt warning light illumination, as well as difficulty latching and unlatching the buckle or the buckle release button ... Read More »
This informational bulletin provides information to advise dealers about seat belt buckles not operating and/or seat belt warning light illumination, as well as difficulty latching and unlatching the buckle or the buckle release button ... Read More »
ISUZU/GMC/CHEVROLET: DIAGNOSTIC INFORMATION FOR INOPERATIVE AIR SEATS, AIR HORN AND/OR EXHAUST BRAKE AND RELEASE OF NEW AUXILIARY AIR COMPRESSOR RELAY AND PRESSURE SWITCH ON RPO K16 VEHICLES. *PE Read More »
This warranty administration bulletin provide policy information on GM of Canada New Vehicle Limited Warranty Tire Program and Global Warranty Management (GWM) Submission Information. Read More »
This warranty administration bulletin provide policy information new tire warranty program and global warranty management submission information. Read More »
ISUZU/GMC/CHEVROLET: DIAGNOSTIC INFORMATION FOR INOPERATIVE AIR SEATS, AIR HORN AND/OR EXHAUST BRAKE AND RELEASE OF NEW AUXILIARY AIR COMPRESSOR RELAY AND PRESSURE SWITCH ON RPO K16 VEHICLES. *PE Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT FINDING NEEDLE BEARINGS DURING AN OIL CHANGE. TECHNICIAN WILL GAIN ACCESS TO THE ROLLER ROCKERS TO INSPECT THEM. Read More »
This Preliminary Information communication provides information to the technician about vehicles that may have an issue when using Bluetooth voice recognition with an iPhone. Read More »
This Preliminary Information communication provides information to the technician about vehicles that have an OnStar system that will not power up. Technician should turn off the ignition and cancel retained accessory power. Read More »
This Preliminary Information communication provides information to the technician about connectivity concerns when connecting an Apple device via USB cord. Read More »
This Preliminary Information communication provides information to the technician about vehicles that are travelling from Canada to the United States. While in the United States they are unable to receive Turn-by-Turn directions. Read More »
This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Read More »
This Preliminary Information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. Read More »
This Preliminary Information communication provides information to the technician about vehicles that may have an issue when using Bluetooth voice recognition with an iPhone. Read More »
This warranty administration bulletin provide policy information on a revised customer concern not duplicated/verified labor operation numbers and how to submit CCND. Read More »
This Preliminary Information communication provides information to the technician on how to diagnose and repair vehicles that may have an OnStar Turn-By-Turn Navigation the system that is inoperative. Read More »
This Preliminary Information communication provides information to the technician about vehicles that have an OnStar system that will not power up. Technician should turn off the ignition and cancel retained accessory power. Read More »
This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Read More »
This Preliminary Information communication provides information to the technician about vehicles that are travelling from Canada to the United States. While in the United States they are unable to receive Turn-by-Turn directions. Read More »
This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Read More »
This Preliminary Information communication provides information to the technician on how to diagnose and repair vehicles that may have an OnStar Turn-By-Turn Navigation the system that is inoperative. Read More »
This warranty informational bulletin provides information on Light and Medium Duty Truck Warranty, Crossline Warranty Eligibility and Guidelines for Chevrolet/GMC Dealers Read More »
This warranty informational bulletin provides Light and Medium Duty Truck Warranty, Crossline Warranty Eligibility and Guidelines for Chevrolet/GMC Dealers Read More »
This informational bulletin provides information for dealers/technicians on when and how to submit a Field Product Report (FPR) (U.S. Dealers Only). Read More »
This warranty administration bulletin provide policy information on a revised customer concern not duplicated/verified labor operation numbers and how to submit CCND. Read More »
This warranty administration bulletin provides information on the Clarification of Use for Dealer Empowerment Labor Operations and Customer Enthusiasm Read More »
This informational bulletin provides a list off all the issues revolving around new vehicles for a one stop place to find growing concerns around them. Read More »
This warranty administration bulletin provide policy information on a revised customer concern not duplicated/verified labor operation numbers and how to submit CCND. Read More »
