- September 17: GM Says Takata Airbag Recall of 980,000 Vehicles is Unnecessary news | 34 days ago
- September 9: General Motors Recalls 4 Million Vehicles recalls | 42 days ago
- August 27: GM Recalls 383,000 Cars, SUVs and Police Pursuit Vehicles recalls | 55 days ago
- August 17: Chevrolet Malibu Hybrid Recalled Due To Stalling recalls | 65 days ago
- July 29: GM Recalls Chevrolet Cruze Over Missing Headlight Codes recalls | 84 days ago
2003 Chevrolet Tahoe
7 Recalls & Safety Reports
Recall List for the 2003 Chevrolet Tahoe
Official recalls have been issued for the 2003 Chevrolet Tahoe by the NHTSA. The complete details of all recalls are listed below, along with what they cover and the recommended solutions.
Recalls don't cost you anything to get fixed, but most are time-limited, so if your car is affected you should call your local Chevrolet service department immediately!
If you have questions about a recall, write down your VIN & then call Chevrolet customer service.
2003 Chevrolet Tahoe WHEELS:CAP/COVER/HUB NHTSA Campaign #07E106000
Summary: Certain federal-mogul replacement wheel hub assemblies with the brand names: National, Carquest P/nos. 515020, 515021, 515025, 515053, 515054, 515059, and 515060, shipped between January 23, 2006, and December 20, 2007, sold for light duty and medium duty trucks. The inboard retention nut used to maintain hub bearing assembly can loosen resulting in an ABS light indication, noise, and/or wheel separation.
Consequence: Wheel separation can result in a vehicle crash.
Actions: Federal-mogul will notify customers and will replace the hub assembly free of charge. The recall began on February 7, 2008. Owners can contact federal-mogul toll-free at 877-489-6659. For detailed information & supporting documents, see the official NHTSA page concerning recall #07E106000 »
2003 Chevrolet Tahoe FUEL SYSTEM, GASOLINE NHTSA Campaign #06E043000
Summary: Certain replacement fuel filters, fram brand name P/N G3727, with date codes X52911 through X60801 sequentially or X600141 and a Mexico country or origin marking on the fuel filter housing manufactured from October 18, 2005, through March 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on "document search" and then "bus applications"). the connector on the fuel filter was not manufactured to honeywell's specification. As a result, the O-ring may not seat correctly on the fuel line.
Consequence: This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. In the presence of an ignition source, a fire could occur.
Actions: Honeywell will notify owners and replace the fuel filters free of charge. The recall began on October 18, 2006. Owners may contact fram customer service at 1-800-890-2075 (option 1). For detailed information & supporting documents, see the official NHTSA page concerning recall #06E043000 »
2003 Chevrolet Tahoe EXTERIOR LIGHTING NHTSA Campaign #06E026000
Summary: Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.
Consequence: Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Actions: Pro-a motors will notify owners and offer to repurchase the lamps. The recall began on April 3, 2006. Owners may contact pro-a motors at 323-838-2988. For detailed information & supporting documents, see the official NHTSA page concerning recall #06E026000 »
2003 Chevrolet Tahoe SEAT BELTS:REAR NHTSA Campaign #05V163000
Summary: On certain crew cab pickup trucks and sport utility vehicles, the 2nd row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. Appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. In addition to instructions on proper infant and young child restraint (with child seats or boosters), special verbiage for restraining older child is included in the owner's manual. Also, the suggested seat belt fit/routing for adults, irrespective of seating position, is described in the owner's manual text.
Consequence: A lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury.
Actions: Dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. The recall began on July 21, 2005. Owners may contact Cadillac at 1-866-982-2339, Chevrolet at 1-800-630-2438, GMC at 1-866-996-9463, or Hummer at 1-800-732-5493. For detailed information & supporting documents, see the official NHTSA page concerning recall #05V163000 »
2003 Chevrolet Tahoe SERVICE BRAKES, HYDRAULIC NHTSA Campaign #04V045000
Summary: Certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of Federal Motor Vehicle Safety Standard no. 135, "passenger car brake systems." Some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore.
Consequence: Consequently, the valve O-ring seal may fracture. Steering efforts may be slightly increased while braking or parking. Under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture.
Actions: Dealers are to replace the hydro-boost relief valve. The recall began on June 18, 2004. Owners should contact Cadillac at 1-866-982-2339; Chevrolet at 1-800-630-2438; GMC at 1-866-996-9463; or Hummer at 1-866-486-6376. For detailed information & supporting documents, see the official NHTSA page concerning recall #04V045000 »
2003 Chevrolet Tahoe STRUCTURE NHTSA Campaign #03V094000
Summary: Certain pickup truck, van, and mini van conversions equipped with Southern Comfort built running boards that contain certain courtesy lights manufactured by american technology components, Inc. These units contain a courtesy light or lights that might overheat when the wire harness is exposed to excessive moisture and road salt.
Consequence: This overheating condition can cause the running board to melt or cause a fire.
Actions: Dealers will replace the wiring harness on these running boards. Owner notification began March 7, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Southern Comfort at 1-800-745-6096. For detailed information & supporting documents, see the official NHTSA page concerning recall #03V094000 »
2003 Chevrolet Tahoe STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS NHTSA Campaign #03V037000
Summary: Certain sport utility vehicles fail to comply with requirements of Federal Motor Vehicle Safety Standard no. 214, "side impact protection." These vehicles are built with four welds on the rear door upper hinge. On some of these vehicles, one or two of the welds may not be to specification.
Consequence: As a result, the door strength may be degraded during a side impact vehicle crash.
Actions: Dealers will inspect the welds on the left rear door upper hinge. If a weld is found out-of-specification, a bolt will be installed to secure the hinge. Owner notification began February 17, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Cadillac at 1-800-458-8006, Chevrolet at 1-800-222-1020, or GMC at 1-800-462-8782. For detailed information & supporting documents, see the official NHTSA page concerning recall #03V037000 »
Browse Other Tahoe Years
- 2016 Chevrolet Tahoe
- 2015 Chevrolet Tahoe
- 2014 Chevrolet Tahoe
- 2013 Chevrolet Tahoe
- 2012 Chevrolet Tahoe
- 2011 Chevrolet Tahoe
- 2010 Chevrolet Tahoe
- 2009 Chevrolet Tahoe
- 2008 Chevrolet Tahoe
- 2007 Chevrolet Tahoe
- 2006 Chevrolet Tahoe
- 2005 Chevrolet Tahoe
- 2004 Chevrolet Tahoe
- 2003 Chevrolet Tahoe
- 2002 Chevrolet Tahoe
- 2001 Chevrolet Tahoe