NHTSA Campaign #07E066000 EQUIPMENT:ELECTRICAL

AUGUST 28
2007

175 vehicles recalled

2004 DODGE RAM -- Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel rv travel trailers. Due to incorrect wiring of the harness, the trailer lights may not operate properly.

If the trailer lights are not working properly, a vehicle crash can occur.

All of the defective tow packages are still at the distributor level and have not been sold to any consumers. For detailed information & supporting documents, see the official NHTSA page concerning recall #07E066000 »

NHTSA Campaign #07E009000 SUSPENSION

FEBRUARY 01
2007

3,350 vehicles recalled

2004 DODGE RAM 2500 -- Certain lki enterprises, Inc., brand name superlift suspension, pitman arms sold as replacement equipment for 2003-2007 Dodge Ram 2500 and 3500 4X4 light trucks. Due to inadequate heat treatment during production, the affected pitman arms may develop cracks in the upper splined attachment attachment to the steering output shaft. Movement between the pitman arm and the output shaft may deform splines, resulting in premature wear and fatigue failure of the affected pitman arm.

Pitman arm wear or failure may lead to loss of vehicle control, possibly resulting in a vehicle crash.

Lki will notify owners and replace the pitman arm, if necessary. The recall began on March 12, 2007. Owners may contact lki at 1-800-551-4955. For detailed information & supporting documents, see the official NHTSA page concerning recall #07E009000 »

NHTSA Campaign #06E049000 EXTERIOR LIGHTING

MAY 24
2006

27,176 vehicles recalled

2004 DODGE RAM -- Certain ck motorsports combination headlights, clear corner, bumper, and side marker lights sold as replacement lamps for use on the passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.

Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Ck motorsport will notify owners and replace the noncompliant lamps free of charge. The recall began on July 1, 2006. Owners may contact ck motorsport at 1-909-610-7211. For detailed information & supporting documents, see the official NHTSA page concerning recall #06E049000 »

NHTSA Campaign #06E023000 EXTERIOR LIGHTING:HEADLIGHTS

MARCH 13
2006

292,000 vehicles recalled

2004 DODGE RAM -- Certain anzo combination headlamp assemblies sold as replacement lamps for use on certain passenger vehicles. Some combination lamps are not equipped with amber side reflectors which fail to conform to Federal Motor Vehicle Safety Standard no. 108, "Lamps, Reflective Devices, And Associated Equipment.¿

Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash.

Anzo will notify owners and replace the headlamps free of charge. The recall began May 9, 2006. Owners may contact anzo usa at 909-468-3688. For detailed information & supporting documents, see the official NHTSA page concerning recall #06E023000 »

NHTSA Campaign #05V462000 POWER TRAIN:AUTOMATIC TRANSMISSION

OCTOBER 06
2005

250,433 vehicles recalled

2004 DODGE RAM 2500 -- On certain pickup trucks equipped with diesel engines and automatic transmissions, in an attempt to exit the vehicle quickly without shutting off the engine and removing the key, the driver may inadvertently leave the automatic transmission shift control in indicated reverse.

This error is an unintended action that may result in a lack of transmission park pawl engagement and possibly delayed rearward movement of the vehicle.

Dealers will perform a software modification to equip these vehicles with an out-of-park alarm. Owners may contact DaimlerChrysler at 1-800-853-1403. For detailed information & supporting documents, see the official NHTSA page concerning recall #05V462000 »

NHTSA Campaign #04V385000 ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

AUGUST 03
2004

2,261 vehicles recalled

2004 DODGE RAM -- On certain pick-up trucks equipped with 4.7L engines, the generator wiring harness may short circuit due to contact with a valve cover stud.

A short circuit in the generator harness can cause an under hood fire.

Dealers will inspect the alternator wiring insulation for damage and repair and add a tie-strap clip to the valve cover stud to retain the wiring. This recall began on August 13, 2004. Owners should contact DaimlerChrysler at 1-800-853-1403. For detailed information & supporting documents, see the official NHTSA page concerning recall #04V385000 »

NHTSA Campaign #04V221000 EQUIPMENT:OTHER:LABELS

MAY 06
2004

6,183 vehicles recalled

2004 DODGE RAM 2500 -- The vehicle certification label on some pickup trucks lists incorrect tire, wheel, and recommended inflation pressure information which does not conform to the requirements of Federal Motor Vehicle Safety Standard no. 120, 'Tire Selection And Rims For Vehicles Other Than Passenger Cars.'

Installing the incorrect tire/rim sizes and loading the vehicle to the weights shown on the label can cause tire failure and result in a crash without warning.

Owners will be provided with vehicle certification label overlays containing the corrected information relative to vehicle tire and rim size, and recommended inflation pressure. This recall began on May 5, 2004. Owners should contact DaimlerChrysler at 1-800-853-1403. For detailed information & supporting documents, see the official NHTSA page concerning recall #04V221000 »

NHTSA Campaign #03V503000 POWER TRAIN:AUTOMATIC TRANSMISSION

DECEMBER 04
2003

514 vehicles recalled

2004 DODGE RAM 2500 -- On certain pickup trucks, the transfer case to transmission attaching fasteners may not be tightened correctly. This could cause the transmission adapter or transfer case housing to crack and leak fluid.

Continued operation can result in propeller shaft separation and damage to fuel system components, which could lead to a fuel leak. Fluid and/or fuel leakage in the presence of an ignition source can cause an underbody fire.

Dealers will retighten the transfer case to transmission fasteners. Owner notification began on December 22, 2003. Owners should contact DaimlerChrysler at 1-800-992-1997. For detailed information & supporting documents, see the official NHTSA page concerning recall #03V503000 »