[ switch models ] 2000 Volvo S70 2000 Volvo V40 2000 Volvo V70 2000 Volvo V70 XC [ switch years ] 2005 Volvo S80 2001 Volvo S80 1999 Volvo S80

2000 Volvo S80

2000 Volvo S80 TSBs (Technical Service Bulletins)

There are also 4 Volvo recalls » 2 defect investigations » 69 TSBs » for the Volvo S80.

Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB title & date, & either contact your local dealer or click on the links below.

ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use to track each bulletin -- yes, it's a very screwed up situation that's almost completely unhelpful to you as the consumer. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.

STEERING

• TSB #6411 -- SUBJECT REGARDING SOFTWARE FUNCTION ID 664, STEERING WHEEL MODULE -DIAGNOSTIC TROUBLE CODE, ELECTRONIC CONTROL MODULE-928C, AND CENTRAL ELECTRONIC MODULE-1A5B. *YD (NHTSA ID #626878, SEPTEMBER 27 2001)

STEERING:GEAR BOX (OTHER THAN RACK AND PINION)

• TSB #4430023 -- INFORMATION ON INSTALLING AN ADDITIONAL GUIDE SLEEVE - AUTOMATIC GEARBOX. *TT (NHTSA ID #613431, JANUARY 01 2000)

SUSPENSION:FRONT:CONTROL ARM

• TSB #6103 -- SUBJECT REGARCING BALL JOINT REPLACEMENT, RECALL 99. *TT (NHTSA ID #616756, JANUARY 24 2001)

SUSPENSION:REAR

• TSB #7206 -- REAR SUSPENSION POPPING/SPRING NOISE. TO INCLUDE VOLVO XC90 1999-2000. *SC (NHTSA ID #10016668, JUNE 28 2005)

ENGINE AND ENGINE COOLING

• TSB #25149C -- CLEANING THE CRANKCASE VENTILATION. *AK (NHTSA ID #10019763, FEBRUARY 20 2006)
• TSB #25149B -- CHECKING CRANKCASE VENTILATION SYSTEM. *AK (NHTSA ID #10019762, FEBRUARY 20 2006)

ENGINE AND ENGINE COOLING:ENGINE

• TSB #2322 -- CRANK NO START, NO FUEL PRESSURE. *TT (NHTSA ID #10000301, OCTOBER 15 2002)
• TSB #2114 -- INFORMATION ON OIL LEAKAGE FROM FLYWHEEL / FLEXPLATE, REAR CRANKSHAFT. *TT (NHTSA ID #619536, APRIL 11 2001)
• TSB #210028 -- SUBJECT REGARDING INSPECTION OF ENGINE OIL FILLER GRATE. *TT (NHTSA ID #610587, MARCH 01 2000)
• TSB #2220007 -- INFORMATION DESCRIBING HOW TO REPLACE THE PISTON COOLING VALVE. *TT (NHTSA ID #610428, DECEMBER 01 1999)

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

• TSB #2842 -- SOME VEHICLES MAY EXHIBIT ROUGH COLD START. *TT (NHTSA ID #629022, JANUARY 30 2002)
• TSB #2826 -- SUBJECT ON ENGINE RPM FLUCTUATIONS WHILE STOPPING. *YH (NHTSA ID #626114, AUGUST 17 2001)
• TSB #2820 -- SUBJECT REGARDING ENGINE PERFORMANCE B6294S3-NON TURBOCHAGED ENGINE. *YD (NHTSA ID #624126, JULY 30 2001)
• TSB #2837 -- EXPERIENCING ROUGH COLD START ON VEHICLES EQUIPPED WITH A B6284T6 ENGINE. *TT (NHTSA ID #621861, JUNE 22 2001)
• TSB #2820 -- SUBJECT REGARDING ENGINE PERFORMANCE B6294S3 NON TURBOCHARGED ENGINES. *TT (NHTSA ID #621867, JUNE 22 2001)
• TSB #2825 -- SUBJECT REGARDING B6304S / B6294S ROUGH COLDSTART. *TT (NHTSA ID #620143, FEBRUARY 05 2001)
• TSB #2198 -- SERVICE CAMPAIGN ENVOLVING THE ENGINE OIL FILLER GRAKE LOCATED IN THE ENGINE OIL FILLER NECK OF CERTAIN VEHICLES. *TT (NHTSA ID #610590, APRIL 01 2000)

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

• TSB #141 -- EXCESSIVE HEAT MAY BE GENERATED BY THE RUNNING OF COOLING FAN. RECALL CAMPAIGN 141 TO INSPECT/REPLACE ENGINE COOLING FAN CONTROL MODULE (EFCM) AND COOLING FAN ASSEMBLY. *TT (NHTSA ID #10013850, JANUARY 01 2005)

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

• TSB #2829 -- SUBJECT REGARDING MASS AIR FLOW SENSOR REPLACEMENT. *TT (NHTSA ID #621847, MAY 24 2001)

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)

• TSB #149 -- WARRANTY COVERAGE SHOULD A CUSTOMER EPXERIENCE A DEFECT WIT THE ETM SYSTEM BEYOND THE TERMS OF THE NORMAL NEW CAR WARRANTY. *TT TROUBLESHOOTING ELECTRONIC THROTTLE SYSTEM (ETS). *TT CHECKING CRANKCASE VENTILATION SYSTEM. *TT CLEANI (NHTSA ID #10018801, FEBRUARY 20 2006)

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

• TSB #0031 -- NEW BRACKET IN THE SUB-FRAME FOR MOUNTING THE CATALYTIC CONVERTER. *TT (NHTSA ID #10005275, NOVEMBER 01 2003)

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

• TSB #23-31 -- NEW FUEL PUMP FOR STARTING PROBLEMS WHEN PARKED DOWNHILL. *NJ UPDATED 6/5/08. *NJ (NHTSA ID #10023657, APRIL 16 2008)

FUEL SYSTEM, OTHER

• TSB #2316 -- THIS BULLETIN MENTIONS THAT DUE TO A CHANGE IN TECHNICAL INFORMATION - DCS 23-16 (FUEL GAUGE DOES NOT SHOW FULL TANK) DATED 1/11/01 HAS BEEN DELETED AND THE INFORMATION IS NO LONGER VALID. *TT (NHTSA ID #616751, JANUARY 18 2001)
• TSB #2316 -- ON SOME VEHICLES, IT IS POSSIBLE THAT THE FUEL GAUGE WILL NOT SHOW A FULL READING AFTER THE CAR HAS BEEN FILLED UP WITH FUEL. *TT (NHTSA ID #616753, JANUARY 11 2001)

POWER TRAIN:MANUAL TRANSMISSION

• TSB #0032 -- SUBJECT REGARDING GEAR SELECTOR ASSEMBLY, DIAGNOSTIC TROUBLE CODE, TRANSMISSION CONTROL MODULE 0094. *YD (NHTSA ID #627788, OCTOBER 01 2001)

POWER TRAIN:AUTOMATIC TRANSMISSION

• TSB #430027 -- TRANSMISSION SHUDDER DURING UPSHIFT (MOST COMMON DURING THE 2-3 SHIFT). *TT (NHTSA ID #10000921, JANUARY 01 2003)
• TSB #430027 -- AUTOMATIC TRANSMISSION, SHUDDER DURING UPSHIFT. *TT (NHTSA ID #10000860, JANUARY 01 2003)
• TSB #4317 -- SUBJECT REGARDING QUALITY UPGRADE SOFTWARE DEVELOPED FOR AUTOMATIC TRANSMISSION. *TT (NHTSA ID #635267, APRIL 05 2002)
• TSB #4430027 -- THIS BULLETIN DESCRIBES THE FAULT TRACING AND CORRECTIVE ACTION FOR TRANSMISSION SHUDDER DURING UPSHIFT (2-3 SHIFTS). *TT (NHTSA ID #610591, MARCH 01 2000)

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

• TSB #4002 -- TRANSMISSION CONTROL MODULE (TCM) UPGRADES AVAILABLE TO CORRECT COMPLAINTS/SYMPTOMS. *TT (NHTSA ID #10016434, JULY 07 2006)
• TSB #4430032 -- SUBJECT REGARDING GEAR SELECTOR ASSEMBLY, DIAGNOSTIC TROUBLE CODE TRANSMISSION CONTROL MODULE 0094. *SLC (NHTSA ID #626889, OCTOBER 01 2001)
• TSB #3300001 -- SUBJECT REGARDING TRANSMISSION SOFWARE UPGRADE. *YD (NHTSA ID #623996, AUGUST 01 2001)
• TSB #36107 -- SERVICE MANAGER BULLETIN REGARDING TRANSMISSION SOFTWARE UPGRADE. *TT (NHTSA ID #620876, JULY 19 2001)
• TSB #43003 -- THIS BULLETIN DESCRIBES HOW TO MOVE THE CABLE HARNESS THAT CARRIES THE CABLES FOR THE GEAR SELECTOR MODULE WHEN DIAGNOSTIC TROUBLE CODE (DTC) TRANSMISSION CONTROL MODULE (TCM) 0094 IS STORED. *TT (NHTSA ID #620882, JULY 01 2001)
• TSB #107 -- SUBJECT REGARDING SERVICE UPGRADE TO ENSURE POPER OVERALL TRANSMISSION SHIFT FUNCTION PERFORMANCE AND / OR SHIFT QUALITY. *TT (NHTSA ID #620874, JULY 01 2001)

ELECTRICAL SYSTEM

• TSB #1713 -- THIS BULLETIN MENTIONS THAT SEVERAL CHANGES HAVE BEEN TO THE ELECTRICAL SYSTEM ON SOME VEHICLES AS WELL AS DIFFERENT TERMINOLOGY USED TO DESCRIBE THE VARIOUS PRODUCTION WEEK CHANGES. *TT (NHTSA ID #610432, FEBRUARY 24 2000)
• TSB #1707 -- INFORMATION PERTAINING TO THE TRANSPORTATION SWITCH WHICH DISCONNECTS THE VEHICLE ELECTRICAL SYSTEM FROM THE BATTERY TO MINIMIZE BATTERY DRAIN. *TT (NHTSA ID #608293, JULY 09 1999)

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

• TSB #3202 -- ALTERNATOR CHARGING PROBLEMS. *SC (NHTSA ID #10016648, MAY 09 2005)

ELECTRICAL SYSTEM:IGNITION:MODULE

• TSB #2823 -- INFORMATION REGARDING OSCILLATING TORQUE DURING ACCELERATION. *YH (NHTSA ID #626280, AUGUST 17 2001)

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

• TSB #8817 -- SUBJECT REGARDING CAUTION: ACCESSORY INSTALLATION. *TT (NHTSA ID #615018, AUGUST 14 2000)

VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:CONTROLS/WIRING

• TSB #8743 -- CLIMATE CONTROL MODULE (CCM) MALFUNCTION. *TT (NHTSA ID #10000305, OCTOBER 25 2002)

AIR BAGS

• TSB #8815 -- VADIS INFORMATION REGARDING SRS DIAGNOSTIC TROUBLE CODES (DTCS), CONTINUE BUTTON IS GREYED OUT. *TT (NHTSA ID #613838, JUNE 02 2000)

SEAT BELTS

• TSB #8815 -- SUBJECT REGARDING SRS DIAGNOSTIC TROUBLE CODE, CONTINUE BUTTON IS GREYED OUT. *TT (NHTSA ID #614253, JUNE 02 2000)

STRUCTURE:BODY

• TSB #8821 -- EXPERIENCING CHIRPING SOUND FROM GLOVE BOX. *TT (NHTSA ID #616738, DECEMBER 22 2000)

VEHICLE SPEED CONTROL

• TSB #155 -- ELECTRONIC THROTTLE SYSTEM SOFTWARE UPGRADE. *TT (NHTSA ID #10019595, MARCH 20 2006)
• TSB #149 -- ELECTRONIC THROTTLE MODULE (ETM) EXTENDED WARRANTY. *TT (NHTSA ID #10019591, MARCH 16 2006)
• TSB #2703 -- CUSTOMERS MAY COMPLAIN OF THE CRUISE CONTROL NOT HOLDING THE DESIRED SPEED. *SLC (NHTSA ID #629514, JANUARY 24 2002)
• TSB #2703 -- WHILE DOWN HILL DRIVING, THE CRUISE CONTROL SYSTEM MAY NOT HOLD THE DESIRED SPEED. *TT (NHTSA ID #629025, APRIL 10 2001)
• TSB #2703 -- ON CERTAIN VEHCLES, DURING DOWNHILL DRIVING, THE CRUISE CONTROL SYSTEM MAY NOT HOLD THE DESIRED SPEED. *TT (NHTSA ID #620139, APRIL 10 2001)
• TSB #2703 -- SOME VEHICLES MAY EXHIBIT A CRUISE CONTROL SYSTEM THAT MAY NOT HOLD THE DESIRED SPEED DURING DOWNHILL DRIVING. *TT (NHTSA ID #610417, JANUARY 24 2000)

VEHICLE SPEED CONTROL:CRUISE CONTROL

• TSB #2835 -- COMPLAINTS OF IDLE SPEED BEING UNEVEN AND NOTICEABLE TO THE DRIVER, ESPECIALLY WITH THE INCREASED LOAD PRODUCED BY THE AIR CONDITIONING COMPRESSOR CYCLING ON AND OFF. *TT (NHTSA ID #630874, FEBRUARY 22 2002)
• TSB #2835 -- COMPLAINTS OF IDLE SPEED BEING UNEVEN AND NOTICEABLE TO THE DRIVER CAUSED BY A/C ENGAGEMENT. *TT (NHTSA ID #620867, JULY 05 2001)
• TSB #2835 -- COMPLAINTS OF IDLE SPEED BEING UNEVEN AND NOTICEABLE TO THE DRIVER, ESPECIALLY WITH THE INCREASED LOAD PRODUCED BY THE AIR CONDITIONING COMPRESSOR CYCLING ON AND OFF. *TT (NHTSA ID #621865, JUNE 22 2001)

WHEELS

• TSB #720006 -- RESONANCE SOUND (340 HZ) CAN OCCUR FROM THE WHEEL WHICH IS TRANSMITTED VIA THE SPRING STRUT. RUBBER SPRING SEATS (INSULATOR PLATES) HAVE BEEN DEVELOPED AS SERVICE SOLUTIONS. THIS SERVICE BULLETIN DESCRIBES HOW THESE INSULATING PLATES MUST (NHTSA ID #10002972, JULY 01 2003)
• TSB #6650003 -- THIS SERVICE BULLETIN DESCRIBES INSTALLING THE WHEEL DIRT DEFLECTORS ON THE LATER LINK.*TT (NHTSA ID #635181, MARCH 01 2002)

SEATS

• TSB #850036 -- FRONT SEAT, MECHANICAL, ADJUSTING. PLAY/CLEARANCE/CLICKING AT THE LOWER MOUNTINGS FOR THE FRONT HEIGHT ADJUSTER. *TT (NHTSA ID #10011529, DECEMBER 01 2004)
• TSB #8850018 -- SUBJECT REGARDING NEW TEST METHOD FOR WHIPS-INDICATOR. *TT (NHTSA ID #619101, FEBRUARY 01 2001)
• TSB #8850018 -- SUBJECT REGARDING NEW TEST METHOD FOR THE WHIPS-INDICATOR. *TT (NHTSA ID #620112, FEBRUARY 01 2001)
• TSB #8812 -- INFORMATION INTRODUCING THE TOP TETHER ANCHORAGE FOR CHILD SEAT. *TT (NHTSA ID #6089466, OCTOBER 27 1999)

SEATS:FRONT ASSEMBLY:POWER ADJUST

• TSB #8850014 -- CUSTOMER MAY EXPERIENCE MINIMAL FORE AND AFT MOVEMENT DURING ACCELERATION AND DECELERATION WHEN DRIVING A CAR EQUIPPED WITH POWER SEATS. *TT (NHTSA ID #618507, OCTOBER 01 2000)

INTERIOR LIGHTING

• TSB #3507 -- THIS BULLETIN MENTIONS THAT THE DOOR WARNING LAMPS HAVE BEEN DELETED FROM PRODUCTION. *TT (NHTSA ID #610437, FEBRUARY 02 2000)

EQUIPMENT

• TSB #3808 -- CUSTOMER MAY COMPLAIN OF FUEL GAUGE NOT SHOWING FULL AND TRIP COMPUTER DISTANCE TO EMPTY. *TT (NHTSA ID #621838, MAY 24 2001)

EQUIPMENT:ELECTRICAL

• TSB #3630 -- TRIP COMPUTER SCROLLING FUNCTION, ERRATIC. *YD (NHTSA ID #626885, OCTOBER 03 2001)

EQUIPMENT:ELECTRICAL:AIR CONDITIONER

• TSB #8732 -- SUBJECT REGARDING DELAYED AIR CONDITIONER COMPRESSOR START UP. *TT (NHTSA ID #629018, JANUARY 30 2002)
• TSB #8741 -- INFORMATION REGARDING EVAPORATOR TEMPERATURE SENSOR. *YH (NHTSA ID #626868, OCTOBER 11 2001)
• TSB #8732 -- SUBJECT REGARDING DELAYED A/C COMPRESSOR START UP. *TT (NHTSA ID #615903, NOVEMBER 22 2000)

UNKNOWN OR OTHER

• TSB #1722 -- CERTIFIED PRE-OWNED UPGRADE MY1999 AND 2000 S80 PEACE OF MIND ENHANCEMENT PROGRAM. *TT (NHTSA ID #10002436, MAY 22 2003)
• TSB #8732 -- SUBJECT REGARDING SW-DELAYED A/C COMPRESSOR START UP. *YD (NHTSA ID #624080, JULY 30 2001)
• TSB #2511 -- SOME MODELS MAY HAVE A CONDITION WHERE THE CHECK ENGINE AND ELECTRONIC THROTTLE SYSTEM LIGHTS ON THE DASH PANEL MAY ILLIMINATE. *TT (NHTSA ID #6089460, DECEMBER 01 1999)