NHTSA Campaign #06E043000 FUEL SYSTEM, GASOLINE

MAY 19
2006

88,303 vehicles recalled

1994 CHEVROLET SUBURBAN -- Certain replacement fuel filters, fram brand name P/N G3727, with date codes X52911 through X60801 sequentially or X600141 and a mexico country or origin marking on the fuel filter housing manufactured from October 18, 2005, through March 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on "document search" and then "bus applications"). the connector on the fuel filter was not manufactured to honeywell's specification. As a result, the O-ring may not seat correctly on the fuel line.

This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. In the presence of an ignition source, a fire could occur.

Honeywell will notify owners and replace the fuel filters free of charge. The recall began on October 18, 2006. Owners may contact fram customer service at 1-800-890-2075 (option 1). For detailed information & supporting documents, see the official NHTSA page concerning recall #06E043000 »

NHTSA Campaign #03V159000 VISIBILITY:WINDSHIELD WIPER/WASHER

APRIL 28
2003

1,755,876 vehicles recalled

1994 CHEVROLET SUBURBAN -- On certain minivans, pickup trucks, and sport utility vehicles with certain model-engine combinations, the windshield wiper motor may fail due to cracked solder joints on the controller circuit board. The windshield wipers could work intermittently or not at all.

If this were to occur during bad weather, driver visibility would be reduced, which could result in a crash.

Dealers will replace the wiper motor circuit board and cover. Owner notification began on June 19, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Chevrolet at 1-800-222-1020, GMC at 1-800-462-8782, or Oldsmobile at 1-800-442-6537. For detailed information & supporting documents, see the official NHTSA page concerning recall #03V159000 »

NHTSA Campaign #01I006000 SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

JULY 02
2001

255,770 vehicles recalled

1994 CHEVROLET SUBURBAN -- This is not a safety recall in accordance with the Safety Act. However, it is deemed a safety improvement campaign by the Agency. Vehicle description: 1992-1994 Chevrolet and GMC Suburbans equipped with vacuum power-brake assist and ebc4 anti-lock brake (ABS) modules. These vehicles exhibit poor brake system performance.

This could be attributed to brake pedal feel.

Dealers will install a new brake pedal pad. In addition, dealers will inspect the brake-booster output rod and replace it if necessary. For detailed information & supporting documents, see the official NHTSA page concerning recall #01I006000 »

NHTSA Campaign #99V025000 SERVICE BRAKES, HYDRAULIC:SWITCHES:BRAKE LIGHT

FEBRUARY 05
1999

988,587 vehicles recalled

1994 CHEVROLET SUBURBAN -- Vehicle description: Pickup trucks, crew cabs, utility trucks and sport utility vehicles. These vehicles were built with the polarity of the wiring for the zero adjust brake switch reversed from what was specified on the switch drawing. With the reversed polarity, the contacts in the brake switch can wear out prematurely. The brake switch will perform normally until the brake switch contacts wear out, resulting in loss of the brake lamps without any warning to the driver.

This would fail to warn a following driver that the vehicle is braking and could lead to a crash.

Dealers will replace the brake switch and reverse the wiring. For detailed information & supporting documents, see the official NHTSA page concerning recall #99V025000 »

NHTSA Campaign #98V150001 VISIBILITY:WINDSHIELD WIPER/WASHER

JULY 01
1998

1,557,585 vehicles recalled

1994 CHEVROLET SUBURBAN -- Vehicle description: Light duty pickup trucks and sport utility vehicles, 2 and 4-wheel drive. Solder joints near the wiring harness connector can crack causing the windshield wipers to work intermittently.

This condition can result in inoperative wipers, reducing a driver's visibility, and increasing the risk of a vehicle crash.

Dealers will replace the wiper motor circuit board and cover. For detailed information & supporting documents, see the official NHTSA page concerning recall #98V150001 »

NHTSA Campaign #95I005000 ENGINE AND ENGINE COOLING:ENGINE:DIESEL

DECEMBER 13
1994

60,000 vehicles recalled

1994 CHEVROLET SUBURBAN -- Vehicle description: Light duty pickup trucks, vans and motorhomes equipped with electronically fuel injected 6.5L diesel engine. This is not a safety recall in accordance with federal regulation part 573. However, it is deemed a safety improvement campaign by the Agency. The campaign will improve the overall driveability of these vehicles.

Certain vehicles can exhibit some driveability concerns such as poor throttle response, stalling, misfire, poor hot or cold starting, extended cranking of a hot engine, or stalling after start. Trucks with manualtransmissions can exhibit poor acceleration from start or could stall during deceleration.

Dealers will install some recently developed enhancements which will improve the overall driveability of these vehicles. For detailed information & supporting documents, see the official NHTSA page concerning recall #95I005000 »