2006 Pontiac G6
2006 Pontiac G6 TSBs (Technical Service Bulletins)
There are also 2 Pontiac recalls » 3 defect investigations » 70 TSBs » for the Pontiac G6.
Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB title & date, & either contact your local dealer or click on the links below.
ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use to track each bulletin -- yes, it's a very screwed up situation that's almost completely unhelpful to you as the consumer. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.
STEERING
- TSB #060232007 -- CLUNK, KNOCK OR RATTLE NOISE FROM FRONT OF VEHICLE WHILE DRIVING OR TURNING OVER BUMPS AT LOW SPEEDS. *KB (DIAGNOSE NOISE - LUBRICATE INNER AND OUTER STEERING SHAFT, REPOSITION I-SHAFT, ADD FOAM TO RADIATOR SURGE TANK MOUNTING BRACKET (NHTSA ID #10020816, MARCH 01 2008)
- TSB #060232002 -- NORMAL OPERATING CHARACTERISTICS OF ELECTRIC POWER STEERING (EPS) SYSTEM DURING EXTENDED LOCK-TO-LOCK (MAXIMUM STEERING WHEEL ROTATION) USAGE. *TT (NHTSA ID #10019478, DECEMBER 01 2006)
STEERING:WHEEL AND HANDLE BAR
STEERING:ELECTRIC POWER ASSIST SYSTEM
- TSB #3795 -- ELECTRIC STEERING IS INOPERATIVE WITH C0545. *AK (NHTSA ID #10019283, no date provided)
- TSB #3797 -- INTERMITTENT STEERING WHEEL DITHER AFTER FRONT END ALIGNMENT WAS PERFORMED. *TT (NHTSA ID #10018531, no date provided)
SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
- TSB #4658 -- ADJUSTABLE PEDALS WILL NOT ADJUST INOPERATIVE. *NJ UPDATED 3/13/09. *PE (NHTSA ID #10023415, DECEMBER 01 2008)
- TSB #PIC--4330B -- CHEVROLET: UNABLE TO RELEARN THE BRAKE PEDAL POSITION (BPP) SENSOR. *PE (NHTSA ID #10028285, DECEMBER 01 2008)
- TSB #PIC-4330A -- GMC: UNABLE TO RELEARN THE BRAKE PEDAL POSITION (BPP) SENSOR. HAVE DIFFICULTY PERFORMING THE BRAKE PEDAL POSITION (BPP) RELEARN. MODELS CHEVROLETS, PONTIACS AND SATURNS. *PE (NHTSA ID #10026163, JULY 01 2008)
ENGINE AND ENGINE COOLING
- TSB #050601027 -- REVISED CAMSHAFT POSITION ACTUATOR FASTENER INSTALLATION PROCEDURE. *TT (NHTSA ID #10017819, SEPTEMBER 01 2005)
- TSB #3642 -- SES LIGHT WITH A P0230 DTC AND NO PERFORMANCE CONCERNS - REPLACE ECM. *TT (NHTSA ID #10018533, no date provided)
- TSB #3631 -- TICKING OR CLICKING TYPE NOISE OR SOUND THAT CAN BE HEARD IN THE PASSENGER COMPARTMENT. *TT (NHTSA ID #10018619, no date provided)
- TSB #3646A -- SES LIGHT DUE TO DTCS P1516 AND P1682 - ECM CALIBRATION PENDING. *TT (NHTSA ID #10018604, no date provided)
ENGINE AND ENGINE COOLING:ENGINE
- TSB #PIC-5003 -- GENERAL MOTORS: NO CRANK/NO COMM WITH U2106, U2108, U2109 (LE5 ONLY). THIS CONDITION HAS BEEN IDENTIFIED AS A LOOSE GROUND G105 BEHIND THE A/C COMPRESSOR. *PE (NHTSA ID #10028764, OCTOBER 01 2008)
- TSB #07-06-02-006 -- COOLANT LEAKING FROM ENGINE (REPLACE COOLANT CROSSOVER PIPE GASKETS). VEHICLES WITH 3.5L OR 3.9L ENGINE. *PE (NHTSA ID #10025683, MAY 01 2008)
- TSB #PIP4331 -- SERVICE ENGINE SOON LIGHT ILLUMINATED AND DTC P0011, P0016, P0300. EQUIPPED WITH 3.5L LZE, LZ4 (VIN CODES K, N) & 3.9L LZ9, LZ8, LGD ENGINE (VIN CODES 1, R, W). *NJ (NHTSA ID #10024224, FEBRUARY 01 2008)
- TSB #060604002 -- SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, MULTIPLE POWERTRAIN CONTROL MODULE (PCM) DIAGNOSTIC TROUBLE CODE (DTC) P1404 AND/OR P0404. 06-06-04-002 NOT YET RECEIVED. *TT UPDATED 04-27-07. *KB (NHTSA ID #10019473, MARCH 01 2007)
- TSB #060601014 -- L36, L67, L26, L32, LA1, LX9, MN7, M15. TICKING OR KNOCKING TYPE NOISE COMING FROM THE ENGINE OR TRANSMISSION AREA. *KB (NHTSA ID #10021117, JANUARY 01 2007)
- TSB #050604076 -- INTERMITTENT EXTENDED CRANK ON HOT ENGINE (LZE, LZ4, LZ9)ONLY (REPROGRAM PCM WITH NEW SERVICE CALIBRATION). *AK (NHTSA ID #10019580, MARCH 01 2006)
- TSB #060603001 -- NO CRANK, NO START, BLOWN FUSE. *TT (NHTSA ID #10019509, FEBRUARY 01 2006)
- TSB #05548A -- PROGRAM BULLETIN (CUSTOMER SATISFACTION PROGRAM)-ENGINE HARMONIC BALANCER NOT SEATED. *SC (NHTSA ID #10016502, AUGUST 01 2005)
- TSB #4126 -- SEVERE ENGINE DAMAGE IN ONE CYLINDER. *KB (NHTSA ID #10021672, no date provided)
- TSB #4196 -- CYLINDER HEAD GASKET REPLACEMENT. *KB (NHTSA ID #10022805, no date provided)
- TSB #3662 -- LOW OIL PRESSURE LIGHT/GAUGE. *TT (NHTSA ID #10018919, no date provided)
- TSB #3399 -- ENGINE CRANKS BUT WILL NOT START. *SC (NHTSA ID #10017048, no date provided)
- TSB #3404 -- MACHINING DEBRIS ON THE OIL FILTER ELEMENT. *SC (NHTSA ID #10016822, no date provided)
- TSB #3859 -- LOW OIL PRESSURE - INSPECT OIL FILTER FOR DAMAGE. *KB UPDATED 10/18/07. *NJ (NHTSA ID #10020923, no date provided)
- TSB #3535A -- CRANK NO START (LX9) ONLY. *SC (NHTSA ID #10017009, no date provided)
- TSB #3657 -- HARSH SHIFT, NO POWER AND SES/MIL LIGHT ON WITH DTC P0742. *KB (NHTSA ID #10021001, no date provided)
- TSB #3756 -- OIL LEAK AT CRANKSHAFT/BALANCER SEAL. *TT (NHTSA ID #10019935, no date provided)
ENGINE AND ENGINE COOLING:COOLING SYSTEM
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM
- TSB #060849008 -- ERRATIC FUEL GAUGE (DOES NOT GO TO FULL OR MOVES OFF FULL TOO QUICKLY) (REPROGRAM PCM). *AK (NHTSA ID #10019896, MARCH 01 2006)
- TSB #3712A -- FUEL GAUGE WILL NOT GO TO FULL/ GAUGE DROPS TO FAST. *AK (NHTSA ID #10019281, no date provided)
- TSB #3712 -- FUEL GAUGE WILL NOT GO TO FULL/GAUGE DROPS TOO FAST (LX9 ONLY). *TT (NHTSA ID #10017304, no date provided)
POWER TRAIN:AUTOMATIC TRANSMISSION
- TSB #08-07-30-016 -- DIAGNOSTIC INFORMATION ON MH1, MN8, MT1, M15 TRANSMISSION SLIPS, WILL NOT SHIFT OR MAY OVERHEAT, SES/MIL MAY BE ILLUMINATED, DTCS P0218, P0894 SET. *PE UPDATED 8/12/08. *PE (NHTSA ID #10025421, APRIL 01 2008)
- TSB #070730025 -- INFORMATION ON 4T40-E (MN4) AND 4T45-E (MN5) FRONT WHEEL DRIVE AUTOMATIC TRANSMISSION VALVE BODY RECONDITIONING, DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, HARSH SHIFTS, SLIPS, NO DRIVE, NO REVERSE. *NJ (NHTSA ID #10023942, OCTOBER 01 2007)
- TSB #060730023 -- 4T65E TRANSMISSION 1-2 SHIFT SHUDDER AT LIGHT TO MODERATE ACCELERATION. REPLACE COMPLETE SECOND CLUTCH ASSEMBLY. *KB (NHTSA ID #10020766, SEPTEMBER 01 2006)
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
- TSB #070730005 -- 4T45 TRANSMISSION, MIL/SES ON, DTC P1818, POWER DOOR LOCKS, CRUISE CONTROL, SHIFT INTERLOCK OR RETRACTABLE HARDTOP INOPERATIVE, ENGINE SPEED REVS LIMITED, HYBRIDS-AUTOSTOP, REGEN OR BOOST INOPERATIVE. (REPROGRAM TCM). *KB UPDATED 1 (NHTSA ID #10022473, APRIL 01 2009)
- TSB #05539 -- PRODUCT EMISSION RECALL TO REPLACE THE POWERTRAIN/ENGINE CONTROL MODULE (PCM/ECM). THE POWERTRAIN/ENGINE CONTROL MODULE (PCM/ECM) MAY HAVE BEEN MANUFACTURED WITH DAMAGED INTERNAL IC CHIPS, WHICH MAY AFFECT THE FUEL PUMP CONTROL AND EGR OUT (NHTSA ID #10017551, APRIL 01 2005)
ELECTRICAL SYSTEM
- TSB #3170 -- SERVICE ENGINE SOON LIGHT ON AND OR VARIOUS ELECTRICAL CONCERNS. *EH UPDATED 1/29/08. *NJ (NHTSA ID #10010552, DECEMBER 01 2007)
- TSB #3261B -- (RETAINED ACCESSORY POWER) RAP DEACTIVATES FROM DRIVERS DOOR ONLY. *TT (NHTSA ID #10018551, no date provided)
- TSB #3629 -- PROGRAMMING ALERT: PROGRESS BAR ON TECH 2 MAY NOT DISPLAY 100%. *TT (NHTSA ID #10018541, no date provided)
ELECTRICAL SYSTEM:BATTERY
ELECTRICAL SYSTEM:STARTER ASSEMBLY
- TSB #3550 -- STARTER STAYS ENGAGED AFTER ENGINE STARTS. *AK (NHTSA ID #10019233, no date provided)
- TSB #3649 -- INTERMITTENT LONG CRANK BUT WILL NOT START OR INTERMITTENT NO CRANK. *TT (NHTSA ID #10016547, no date provided)
ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS
- TSB #PIC3385 -- REPEATED PARK LPS FUSE OPEN. *KB (ADDITIONAL INFORMATION) UPDATED 4/1/08. *NJ (NHTSA ID #10020916, FEBRUARY 01 2008)
- TSB #3976 -- INTERMITTENT PARK LAMP FUSE GOES OPEN. *TT (NHTSA ID #10019829, OCTOBER 13 2006)
- TSB #3385A -- REPEATED PARK LPS FUSE OPEN (ADDITIONAL INFORMATION). *TT (NHTSA ID #10016549, no date provided)
DIGITAL INSTRUMENT PANEL
EXTERIOR LIGHTING
VISIBILITY:SUN ROOF ASSEMBLY
- TSB #060857004 -- WET HEADLINER, SEAT BELT, FRONT OR REAR FLOOR/SUNROOF WATER LEAK (INSPECT REAR DRAINS AND CORRECT ROUTING/INSTALL EXTENSIONS). *NJ (NHTSA ID #10023912, OCTOBER 01 2007)
- TSB #3472 -- PANORAMIC SUNROOF WIND RUSH NOISE. *TT (NHTSA ID #10014916, no date provided)
VISIBILITY:REARVIEW MIRRORS/DEVICES
VISIBILITY:WINDSHIELD WIPER/WASHER
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
VISIBILITY:REAR WINDOW WIPER/WASHER
VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:REAR WINDOW
AIR BAGS
- TSB #SB-08-09-41- -- GENERAL MOTORS: DIAGNOSTIC INFORMATION FOR INTERMITTENT RESTRAINTS, AIR BAG (SIR) INDICATOR/LAMP ON WITH DTC(S) B0012, B0013, B0016, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 OR B0044 SET. THIS MAY BE CAUSED BY A LOOSE, (NHTSA ID #10029924, FEBRUARY 01 2009)
- TSB #060941008 -- AIRBAG READINESS LIGHT ON WITH DTC B0081 OR B0092 SET IN PASSENGER PRESENCE SYSTEM (PPS) SDM. *KB (NHTSA ID #10021111, JANUARY 01 2007)
- TSB #050941009 -- PASSENGER AIR BAG STATUS INDICATOR LOOSE OR FALLS INTO CONSOLE. (RETAIN PASSENGER AIR BAG STATUS INDICATOR WITH TIE STRAP). *JB (NHTSA ID #10018680, NOVEMBER 01 2005)
- TSB #3772 -- PASSENGER AIR BAG ON/OFF MESSAGE PLATE AT FRONT OF CENTER CONSOLE. *TT (NHTSA ID #10018565, no date provided)