2004 Toyota Sienna
2004 Toyota Sienna TSBs (Technical Service Bulletins)
There are also 5 Toyota recalls » 38 defect investigations » 73 TSBs » for the Toyota Sienna.
Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB title & date, & either contact your local dealer or click on the links below.
ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use to track each bulletin -- yes, it's a very screwed up situation that's almost completely unhelpful to you as the consumer. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.
STEERING
- TSB #00107 -- STEERING INTERMEDIATE SHAFT IN HIGH ROAD SALT AREAS. *KB (NHTSA ID #10020994, JANUARY 19 2007)
- TSB #00304 -- STEERING INTERMEDIATE SHAFT NOISE. *MR THIS BULLETIN REPLACED PREVIOUS BULLETIN 003-04, DATED FEB 6 2004. *TT (NHTSA ID #10006138, FEBRUARY 06 2004)
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
SUSPENSION:FRONT
SERVICE BRAKES, HYDRAULIC
- TSB #00804 -- INTERMITTENT VSC ACTIVATION AFTER STARTING THE ENGINE AND DRIVING STRAIGHT FROM A STOP POSITION. THIS CONDITION IS ALWAYS ACCOMPANIED BY THE INSTRUMENT PANEL VSC LIGHT AND AUDIBLE WARNING BUZZER TURNING ON AT THE SAME TIME. *NM UPDATE. (NHTSA ID #10011806, NOVEMBER 30 2004)
- TSB #00204 -- REAR DISC BRAKE GROAN NOISE. *TT A VIN HAS BEEN ADDED TO THE PRODUCTION CHANGE INFORMATION TABLE. *TT (NHTSA ID #10006562, MARCH 10 2004)
- TSB #00403 -- DIAGNOSTIC TROUBLE CODE (DTC) C1234 - YAW RATE SENSOR. *TT (NHTSA ID #10005249, NOVEMBER 24 2003)
ENGINE AND ENGINE COOLING
- TSB #01605 -- FUEL INJECTOR TICKING NOISE. *TT *SC (NHTSA ID #10015493, APRIL 08 2005)
- TSB #00403 -- VSC INDICATOR IS ILLUMINATED AND SETTING FAULT CODE DIAGNOSTIC TROUBLE CODE YAW RATE SENSOR MAY BE SETTING AN IMPROPER DIAGNOSTIC CODE. *EH (NHTSA ID #10011483, NOVEMBER 24 2003)
ENGINE AND ENGINE COOLING:ENGINE
- TSB #05506 -- ENGINE PINGING OR KNOCKING NOISE. *KB (NHTSA ID #10022731, SEPTEMBER 07 2007)
- TSB #04305 -- NO START IN SUB-FREEZING AMBIENT AIR TEMPERATURES. *TT (NHTSA ID #10017317, MAY 09 2006)
- TSB #00205 -- MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0346 (CAMSHAFT POSITION SENSOR A CIRCUIT RANGE/PERFORMANCE [BANK 2]). *TT (NHTSA ID #10015533, FEBRUARY 02 2005)
- TSB #00105 -- MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0031, P0051, P2238, AND/OR P2241. *TT (NHTSA ID #10015534, FEBRUARY 02 2005)
- TSB #04804 -- REPAIR MANUAL SUPPLEMENT: LEV II EVAP SYSTEM CHECK - DIAGNOSTIC TROUBLE CODE (DTC) P0441, P0442, P0446, P0451, P0452, P0453, P0455 AND P0456. *NM (NHTSA ID #10011803, NOVEMBER 12 2004)
- TSB #04104 -- MALFUNCTION INDICATOR LAMP (MIL) ON, DIAGNOSTIC TROUBLE CODE (DTC) P0037, P0038 OR P0136. *NM (NHTSA ID #10010158, SEPTEMBER 15 2004)
- TSB #03704 -- ENGINE BANK 1 AND BANK 2 A/F AND 02 IDENTIFICATION. VARIOUS TOYOTA MODELS. *TT (NHTSA ID #10010021, SEPTEMBER 03 2004)
- TSB #02904 -- MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0171 AND/OR P0174 ENGINE RUNNING LEAN. *TT (NHTSA ID #10009542, AUGUST 04 2004)
- TSB #00504 -- MALFUNCTION INDICATOR LAMP (MIL) ON CONDITION WITH ENGINE MISFIRE DIAGNOSTIC TROUBLE CODE (DTC) P0300, P0301, P0302, P0303, P0304, P0305, OR P0306. *TT (NHTSA ID #10007115, APRIL 12 2004)
- TSB #00404 -- MALFUNCTION INDICATOR LAMP (MIL) ON DIAGNOSTIC TROUBLE CODE (DTC) P0010 OR P0020. *TT (NHTSA ID #10006554, MARCH 23 2004)
- TSB #00203 -- OXYGEN SENSOR (O2S) MONITOR THRESHOLD VALUES FOR ALL TOYOTA MODELS FROM 1996 TO 2003 AND VARIOUS 2004 MODELS INCLUDING COROLLA, ECHO AND SCION XA & XB MODELS. *TT (NHTSA ID #10005755, DECEMBER 17 2003)
- TSB #02003 -- MALFUNCTION INDICATOR LAMP (MIL) ON CONDITION WITH DIAGNOSTIC TROUBLE CODE (DTC) P0441, P0442 AND/OR P0446. *TT (NHTSA ID #10005756, DECEMBER 17 2003)
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
- TSB #0506 -- WARRANTY COVERAGE ENHANCEMENT - ISOLATED REPORTS FROM EXTREME COLD CLIMATE AREAS THAT THE RADIATOR MAY CRACK AT THE BASE OF ONE OR MORE OF THE RADIATOR TUBES, RESULTING IN COOLANT LEAKAGE - CUSTOMER SUPPORT PROGRAM. *TT (NHTSA ID #10018857, JANUARY 30 2006)
- TSB #04017 -- LIMITED SERVICE CAMPAIGN (LSC) 40I TO REPLACE THE RADIATOR. COLD WEATHER CONDITIONS MAY CAUSE THE BASE OF THE RADIATOR WALL TO CRACK, RESULTING IN THE LEAKAGE OF ENGINE COOLANT. *TT THIS IS AN AMENDED VERSION. *TT (NHTSA ID #10010604, OCTOBER 27 2004)
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
- TSB #SSC30K -- FUEL TANK REPLACEMENT - URGENT TO DEALERS. *TT (NHTSA ID #10003582, AUGUST 20 2003)
- TSB #TC03018 -- FUEL TANK REPLACEMENT. SPECIAL SERVICE CAMPAIGN 30K. *TT (NHTSA ID #10003579, AUGUST 11 2003)
POWER TRAIN
- TSB #00204 -- THE PROPER IDENTIFICATION OF THE 7 SOLENOIDS USED IN THE U151E/U151F TRANSMISSIONS. *TT (NHTSA ID #10007125, APRIL 06 2004)
- TSB #00703R -- ENGINE CONTROL MODULE (ECM) CALIBRATION - SHIFTING ENHANCEMENT. REVISED. *TT (NHTSA ID #10005656, NOVEMBER 07 2003)
- TSB #00703 -- ENGINE CONTROL MODULE (ECM) CALIBRATION - SHIFTING ENHANCEMENT. *TT UPDATE. *TT (NHTSA ID #10005252, NOVEMBER 07 2003)
POWER TRAIN:MANUAL TRANSMISSION
POWER TRAIN:AUTOMATIC TRANSMISSION
- TSB #TC00203 -- ENGINE CONTROL MODULE (ECM) RESET MEMORY FUNCTION WHENEVER AN AUTOMATIC TRANSMISSION IS REPLACED, OVERHAULED OR INDIVIDUAL COMPONENTS ARE REPLACED. 00-03 ALL MODELS. *TT (NHTSA ID #10003361, JUNE 10 2003)
- TSB #TC00203 -- WHENEVER AN AUTOMATIC TRANSMISSION IS REPLACED, OVERHAULED OR INDIVIDUAL COMPONENTS ARE REPLACED, USE THIS PROCEDURE TO CLEAR ENGINE CONTROL MODULE (ECM) LEARNED VALUES TO PREVENT SUBSEQUENT DRIVEABILITY COMPLAINTS. REVISED NOTICE. TUND (NHTSA ID #10005619, JUNE 10 2003)
- TSB #TC00203 -- WHENEVER AN AUTOMATIC TRANSMISSION IS REPLACED, OVERHAULED OR INDIVIDUAL COMPONENTS ARE REPLACED, USE THIS PROCEDURE TO CLEAR ENGINE CONTROL MODULE (ECM) LEARNED VALUES TO PREVENT SUBSEQUENT DRIVEABILITY COMPLAINTS. REVISED NOTICE. T-1 (NHTSA ID #10005618, JUNE 10 2003)
ELECTRICAL SYSTEM
- TSB #01205 -- REPAIR MANUAL SUPPLEMENT: LASER CRUISE CONTROL BEAM AXIS ADJUSTMENT. *AK (NHTSA ID #10018279, NOVEMBER 01 2005)
- TSB #00604 -- PERSONAL LIGHT OPERATION. *TT (NHTSA ID #10007646, MAY 21 2004)
- TSB #00104 -- MALFUNCTION INDICATOR LAMP (MIL) ON DIAGNOSTIC TROUBLE CODE (DTC) P0748, P0798, P0985 OR P0986. *TT (NHTSA ID #10006553, MARCH 23 2004)
- TSB #EL01103 -- POWER SLIDING DOOR DRIVE CABLE ROUTING. *TT (NHTSA ID #10003365, JUNE 26 2003)
- TSB #00203 -- SERVICE MAINTENANCE REMINDER LIGHT RESET PROCEDURE. *TT (NHTSA ID #10003250, MARCH 07 2003)
ELECTRICAL SYSTEM:WIRING
VISIBILITY:REAR WINDOW WIPER/WASHER
VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:BLOWER
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
STRUCTURE:BODY
- TSB #00304 -- BACK DOOR STAY LEAK AND COLD WEATHER SHUDDER IMPROVEMENT. *TT (NHTSA ID #10006561, OCTOBER 02 2006)
- TSB #01604 -- REAR NO. 2 SEAT STORAGE POSITION. *TT (NHTSA ID #10010313, JULY 09 2004)
- TSB #00604 -- WINDOW SHADE CLIP FALLING OFF. *TT (NHTSA ID #10006552, MARCH 30 2004)
STRUCTURE:BODY:DOOR
- TSB #TSB-0085-09 -- TOYOTA: VEHICLES MAY EXPERIENCE A CONDITION WHERE THE POWER FUNCTION OF THE SLIDING DOOR IS INOPERATIVE. *PE (NHTSA ID #10029190, MARCH 13 2009)
- TSB #TSB-0085-09 -- TOYOTA: VEHICLES MAY EXPERIENCE A CONDITION WHERE THE POWER FUNCTION OF THE SLIDING DOOR IS INOPERATIVE. *PE (NHTSA ID #10029190, MARCH 13 2009)
- TSB #01107 -- POWER BACK DOOR & POWER SLIDING DOOR DIFFICULT CLOSE. *NJ (NHTSA ID #10024010, DECEMBER 15 2007)
- TSB #07017 -- CUSTOMER SUPPORT PROGRAM - WARRANTY COVERAGE EXTENSION FOR THE FRONT DOOR CHECK ON CERTAIN 2004-2007 MY SIENNA VEHICLES. *NJ (NHTSA ID #10023697, OCTOBER 23 2007)
- TSB #00307 -- DOOR CHECK POPPING NOISE. *KB (NHTSA ID #10021711, MARCH 23 2007)
- TSB #00404 -- SLIDING DOOR RATTLE. *TT (NHTSA ID #10007114, JANUARY 26 2006)
- TSB #NV00903 -- FRONT DOOR WIND NOISE. REVISED. *TT (NHTSA ID #10003956, JULY 09 2003)
- TSB #NV00903 -- FRONT DOOR WIND NOISE. *TT (NHTSA ID #10003449, JULY 09 2003)
STRUCTURE:BODY:HATCHBACK/LIFTGATE
- TSB #TSB-0085-09 -- TOYOTA: VEHICLES MAY EXPERIENCE A CONDITION WHERE THE POWER FUNCTION OF THE SLIDING DOOR IS INOPERATIVE. *PE (NHTSA ID #10029190, MARCH 13 2009)
- TSB #TSB-0085-09 -- TOYOTA: VEHICLES MAY EXPERIENCE A CONDITION WHERE THE POWER FUNCTION OF THE SLIDING DOOR IS INOPERATIVE. *PE (NHTSA ID #10029190, MARCH 13 2009)
- TSB #0801 -- CUSTOMER SUPPORT PROGRAM - WARRANTY COVERAGE ENHANCEMENT FOR CERTAIN 2004 THROUGH 2006 MODEL YEAR SIENNA MODELS BACK DOOR STAY (REAR LIFTGATE STRUT). *NJ (NHTSA ID #10024084, JANUARY 23 2008)
STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE
TIRES
- TSB #0601 -- REPORTS REGARDING UNEVEN OR PREMATURE TIRE WEAR ON SOME FACTORY-EQUIPPED DUNLOP SP SPORT 4000 DSST P225/60R17 AND BRIDGESTONE B380 RFT P225/60R17 RUN-FLAT TIRES. CUSTOMER SUPPORT PROGRAM - WARRANTY COVERAGE ENHANCEMENT FOR ALL WHEEL DRIVE (NHTSA ID #10019910, SEPTEMBER 11 2006)
- TSB #00405 -- RUN FLAT TIRE REPAIR CRITERIA. *TT (NHTSA ID #10015824, MARCH 15 2005)
- TSB #01011901 -- CLASS ACTION LAWSUIT SETTLEMENT NOTICE. RUN FLAT TIRES MAY HAVE UNEVEN WEAR. *KB (NHTSA ID #10021265, no date provided)
TIRES:TEMPORARY/EMERGENCY SPARE TIRE
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
- TSB #00206 -- SEAT HEATER INOPERATIVE. *TT (NHTSA ID #10019332, JANUARY 18 2006)
- TSB #00504 -- SEAT HEATER ONLY WORKS ON HIGH. *TT (NHTSA ID #10010031, SEPTEMBER 20 2004)
EQUIPMENT:ELECTRICAL
- TSB #01005 -- DIAGNOSTIC GUIDE FOR REAR SEAT ENTERTAINMENT SYSTEMS. *TT (NHTSA ID #10015882, MAY 27 2005)
- TSB #00904 -- POWER WINDOW / ROOF INITIALIZATION PROCEDURES. *TT (NHTSA ID #10009415, AUGUST 10 2004)
- TSB #00404 -- POWER SLIDING DOOR INOPERATIVE. *TT (NHTSA ID #10007104, APRIL 19 2004)
- TSB #00302 -- DIAGNOSTIC TESTER IMMOBILIZER FUNCTIONS - REVISED. *TT (NHTSA ID #10003608, DECEMBER 11 2002)
EQUIPMENT:ELECTRICAL:AIR CONDITIONER
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
UNKNOWN OR OTHER
- TSB #07015 -- CUSTOMER SUPPORT PROGRAM - WARRANTY COVERAGE EXTENSION ON CERTAIN 2004 - EARLY 2005 MY 4RUNNER, LAND CRUISER AND SIENNA VEHICLES EQUIPPED WITH THE OPTIONAL REAR (BACK-UP) CAMERA. *NJ (NHTSA ID #10023698, OCTOBER 16 2007)
- TSB #04005 -- OWNER RENOTIFICATION OF NON-COMPLETED SPECIAL SERVICE CAMPAIGNS AND LIMITED SERVICE CAMPAIGNS. VARIOUS MODLES INCLUDING THE TOYOTA SCION XB MY2004. *TT (NHTSA ID #10007091, APRIL 09 2004)
- TSB #00104 -- ZERO POINT CALIBRATION. *MR *TT (NHTSA ID #10006139, FEBRUARY 04 2004)
- TSB #00503 -- 2004 MODEL YEAR PRE-DELIVERY SERVICE (PDS). ALL '04 MODELS EXCEPT PRIUS. *TT (NHTSA ID #10010553, AUGUST 04 2003)