definitely annoying
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
27,500 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2006 Dodge Caravan fuel system problems

fuel system problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2006 Dodge Caravan:

Unsubscribe any time. We don't sell/share your email.

2006 Dodge Caravan Owner Comments

problem #2

Dec 092014

Caravan 4-cyl

  • 55,000 miles


When attempting to fill the tank with gas, even on near-empty tank, gas pump clicks off and gas spills out and runs down the body of the car onto the ground. Dodge issued a recall for durango and other Chrysler vehicles for a faulty check valve in the tank but not for my car (Caravan). I'd like to lodge a complaint. Dodge tells me that fixing this problem will cost me $1720 for a new gas tank. I believe Dodge should fix it for me because it is dangerous to have gas spill out when attempting to fill.

- Austin, TX, USA

problem #1

Aug 042011

Caravan 6-cyl

  • miles
06 Dodge Caravan (fmi handicap conversion)- issue spewing gasoline: >filled up approx 9am Aug 4th 2011 > parked at residence > 2pm preparing to go out-of-town > heard humming from left rear > noticed gas cap appear "cross-threaded" & was "hissing" > me in a electric wheelchair, parked facing cap > my son turned cap > gas spewed out like a fire hydrant point blank in my face > gas did not just spray, it spewed out over a half a tank, spewing it 18-20 feet, lasting about a minute. > Dodge mfg srv ctr said (troy), "not sure what caused it, we think it was a closed solenoid purge valve cause mech blew in it & couldn't get no air through it" > I said "you think?!" > he (troy) stated..."all we can say is, go fill it up, drive it around, & see if it does it again" > no error code nor did the "check engine" light ever come on...it should have! note: I'm a 42yr completely disabled [muscular dystrophy-no movement in legs/arms/body], I'm in a electric wheelchair...I have no choice but to use the van, but no one has given me a certain diagnosis, no one knows what could cause the gas to build so much pressure. The cap can't be "cross-threaded", there was so much pressure it in the process of blowing up....thank god it didn't! please help?

- Blackshear, GA, USA

Not what you are looking for?