This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
I purchased this vehicle with less than 50K miles on it. There was a slight shudder on the test drive, but the salesman and I deduced it was the aggressive tread of the tires it came with. I made the purchase anyway as my previous two F150s were great vehicles, and until this truck, service questions were usually rectified well within expectations. After a couple of weeks, there were several little "incidents" of clanking sound when turning the truck on, and now and then, the sound was accompanied by a harsh change in gears, from Park to Reverse and then to Drive. Overall, the shudder came back regularly, and I can recreate it at will; 99% of the time, it would happen at less than 30mph and around 1,500 to 2,000 rpm between 4th & 6th gear. I brought the vehicle back in for regular servicing and mentioned the shudder. I also offered twice for the mechanics to ride with me. But, they took it out alone and then reported they could not recreate the issue. I was at highway speed yesterday, and the truck began slowing down on its own in heavy traffic. I had the accelerator almost to the floor before it would respond so we could get out of the way of other traffic and safely off the highway. This morning (10/27/22), the check engine light is on, and the conversation with the Ford dealership was not fruitful. The earliest opening they have to run a diagnostic is 11/7/22. And, they reported that "if it's a transmission issue, we can't do anything about it, right now" with no apparent reason or estimated time of when. They advised me to check with another FORD service shop since the truck remains under warranty. This is going to be a challenging conversation as there are only a handful of other options in our region of West Virginia. Most of them require a long-drive, or in my case, an expensive tow.
The 10 speed transmission has sever lag in shifting causing the vehicle to stop in intersections and in heavy traffic. It is failing to shift gears at low speeds and into reverse without significant engine revving (RPMs). I took the vehicle to Roush Ford Columbus Ohio (10/25/2022) and they reset the Adaptive Transmission. The next day (10/26/2022) the vehicle was worse and not drivable. The vehicle had not previously had any service lights on. Now after service there is a check engine light on that came on after driving a 1/4 mile.
Trucks transmission makes a loud noise when shifting from park to drive, trucks transmission also jerks when letting off the accelerator. Trucks engine makes a knocking noise when idling truck has 36000 miles on it!
10R80 transmission disengages. 2018 F150 with 136,000 miles, transmission began intermittent shifting at approximately 120,000 miles. Reported to dealership, asked for TCM/ECM update. Dealership refused, saying there was no update for this vehicle. Replaced the valve body and shift solenoids at 134,000 no change. At roughly 135,000 miles called a different Ford dealership in my area, service writer stated there is still no software update for this vehicle, & casually said it's probably a clutch problem. The transmission 'works' properly when it is gear, it does not select or shift properly. At times, the transmission disengages and throttle control is lost, sometimes during these events the engine races, other times it goes to idle. Either way, throttle pedal is ineffective. Contrary to the service writer's assumption, this is not clutches, it is software. This condition is dangerous as the transmission often disengages when accelerating onto the roadway, during these episodes, the driver has to take evasive action to avoid being hit from behind or worse, in cross traffic, from the side.
My 10 speed ford started acting up. First it started with rough and hard shifting into third gear and no has gotten progressively worse to jumping out of gear when trying to accelerate onto the highway or just simple driving to the store. Now it will not hardly move. Ford told me I needed a new transmission for $8000. Dont have 8k and this is my only vehicle.
- Floresville, TX, USA
Search CarComplaints.com for these popular complaint phrases...
Vehicle slips out of gear between 3rd and 4th gear and between 7th and 8th gear causing vehicle to slow down unexpectedly. I can make vehicle available for inspection. Took to ford dealer in South Carolina and was told there is no fix other than a new transmission.
This 2018 F150 developed a cranking noise when starting the engine. Dealership tried two software upgrades per manufacturer notices to solve the issue. The issue was not solved and was said to be Cam Phasers need to be replaced. Manufacturer internal document to dealer stated that driving the vehicle with this problem would not cause any problems and is safe to drive. Dealership had been waiting months for parts. Set-up for an appointment was for later this month, but last month while driving on the Interstate the engine light which was on from the engine issue but a new light, the wrench light came on with the engine light flashing. All power was being lost and had to dodge other vehicles to move over to emergency lane as I had no control of the vehicle. While waiting 12 hours for a tow, I had researched this issue online and found that the manufacturer had a memo out not to drive the vehicle under this condition and have a flatbed tow the vehicle to the nearest dealership and do not start the vehicle up. That this was a catastrophic power train failure and ECU failure. The vehicle sits at the dealership now and is still waiting to be looked at as it cannot start up and has to be pushed within the service area.
My cam phasers rattle on cold start. Ford issued several customer service programs for this issue on the 2018 F150 3.5L ecoboosts however my truck was not covered even though it was also affected.
Regarding 2013-2018 F-150 vacuum system trying to engage the AWD system resulting in noise up front sounds like dragging metal. 2018 Ford F-150 with the grinding noise out of the front hubs. Had this going on for 1 1/2yrs & been in the shop 2-3 times with recurring every time. Found a YouTube that referenced a Technical Service Bulletin. I TOOK THE TSB TO THE DEALERSHIP SERVICE TECH and here-€™s what-€™s on the invoice.. confirmed customer concern, found there was a grinding racheting noise coming from the front end of the vehicle when driving in 2wd, found tsb 22-2019 for this concern following the tsb found the vehicle was equipped with auto 4wd, tsb stated to REMOVE THE VACUUM SUPPLY LINE TO THE IWE SOLENOID AND INSTALL 2 VACUUM CAPS IN THEIR PLACE. This is at Ford-€™s direction. Disable the system so that 2wd no longer active. It-€™s AWD all the time. Still can shift into 4wd. Tech says this issue is so prevalent that that-€™s Ford-€™s answer.. Unacceptable. Disable the 2wd drive because they can-€™t work the problem.
Harsh shifting Harsh down shifting delayed shifting between gears A complete malfunction at highway speeds. The truck goes from gear 10 to gear 1 and stays almost in neutral for up to 20 seconds, completely dangerous Ford ignores the problem even though thousands of people online are having the same issue. Dealer(s), 6 dealers contacted as of today, cannot get my truck in for 6-8 weeks. I have had the truck in the shop for shifting and transmission issues at least 4 times over the last 18 months. The "problem" goes away for a while but then comes right back. This time is by far the worst and no one seems to care. It is unacceptable and extremely dangerous. When your truck loses power and won't go back into gear while traveling 70 mph... it is absolutely terrifying!
Hard shifting with driving, when driving the pickup truck would stall and then go into gear real hard causing a hard shifting and it make the trucks RPM go up and not move, but then when the RPM comes down the truck will shift hard enough to feel the impact and could cause an accident.
Transmissions slips out of gear both during acceleration and at cruising speed. Vehicle has stalled in roadway in on-coming traffic due to transmission slipping out of gear. Problem exists consistently. 66,850 miles on the vehicle.
While shifting from park to drive or shifting from reverse to drive the vehicle makes a very loud bang pop sound from under or rear of vehicle. Dealership claims can't reproduce or it is normal which how would they know if they can't reproduce.
The contact owns a 2018 Ford F-150. The contact stated while driving at various speeds, the vehicle hesitated when the accelerator pedal was depressed. The contact stated no warning lights were illuminated while experiencing failure. The vehicle was taken to the dealer and the failure was unable to be diagnosed. The contacted stated that the dealer informed him that the failure was with the transmission. The contact was informed that he was not driving the vehicle correctly. The contact stated that the vehicle was taken to the dealer several times however, the mechanic was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 36,000.
Transmission on 2018 F150 XLT does not shift properly. When driving, the lower gears shift very hard, enough to snap your neck. I used the Tow/Haul transmission feature one day, and while coasting to a stop, the transmission shifted down so hard that everything in the truck went flying. I know that some of the 2018 F150 trucks have been recalled for this very reason but at this time, my VIN number has not been added to the list. My vehicle just hit 30,000 miles. I talked with my Ford dealer, Ford itself and the NHTSA.
Front Hubs, Bearings have gone bad, and they are on backorder. 6500 on waiting list. I have been on this list since Janurary. Was told today that the company making the part, are not even make them. This could cause an accident if the bearings lockup. The ABS and the traction control does not work. Making for unsafe driving. Especially with fall and winter coming.
I put the truck in park and left it idle with the air conditioning on for a passenger got out to go do something for a few minutes and the truck just started have flames come out of it from the middle of the truck until the truck completely burned the fire started with the truck running and idling and the the truck was parked on gravel
The transmission valve body wears over time and becomes out of sync with the electronic shifting strategies. This caused the clutches to burn up and the vehicle comes out of gear or drops into 1st gear at highway speeds. Transmission was inspected and replaced due to the damage. Prior to the interstate failure was some random hard shifting but no warning lamps or messages.
A D V E R T I S E M E N T S
- Dunbar, WV, USA