hardly worth mentioning
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
62,294 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2001 Ford Ranger exhaust system problems

exhaust system problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2001 Ford Ranger:

Unsubscribe any time. We don't sell/share your email.

2001 Ford Ranger Owner Comments

problem #2

Dec 022005

Ranger 6-cyl

  • 67,000 miles


The contact owns a 2001 Ford Ranger XLT. While the vehicle was parked, the contact noticed that the rear wheels were sitting lower to the ground than usual. The vehicle was taken to an independent mechanic where the rear suspension was repaired. A few years later, the vehicle was taken to an independent repair facility to be inspected where the contact was informed the entire undercarriage was severely corroded. In addition, the hinges which held the fuel tank to the frame were severely corroded. The vehicle was not repaired. The failure mileage was 67,000 and the current mileage was 104,000. Updated 01/25/11 the vehicle also had an evap leak.

- North Kingstown, RI, USA

problem #1

Feb 202006

Ranger 4WD

  • Automatic transmission
  • 57,587 miles
We purchased a 2001 Ford Ranger in October of 2000. In 2004 the pinion seal began leaking and there was an intermittent clicking/squeak in the drivers front side. The pinion seal was replaced and fluid was topped off. As well the excluder seals were replaced and lubed to repair the clicking squeak. This was all done under the warranty. On 05/24/05 the trucks check engine light came on. It was taken back to crater lake Ford and this emissions issue was fixed and we were told we would have to pay $203.39. After much discussion regarding the warranty and the fact that though this is not covered there should have been no issues this soon, we were finally told that there was a possible problem with this and they adjusted the bill to $18.49, did not charge the warranty an amount. However, they put on the receipt that the pinion seal was again leaking, though they did not mention this to us and did not state that they would fix it and that it would be covered. We have the best warranty that was available to purchase when we bought the truck. We tried several times to get the truck in, our schedules being very hectic. We took the truck in today, and were told that the pinion seal was not part of the warranty, that there was only a 12 month 12,000 mile warranty on it, even though they had fixed it under warranty over 3 years after purchase and it has begun leaking by there estimates less than a year after they replaced it. Of course this did little for our disposition and we took the truck and left. We have contacted customer service at crater lake Ford and at Ford Motor Corp. Now we receive a call stating that the services we were being seen for are covered and that we need to bring it back in. However, the seal is obviously an ongoing issue. We want them to fix the problem that is causing the pinion seal leak. They want to simply change the seal again. We want them to fix the problem, not the symptom.

- Central Point, OR, USA

Not what you are looking for?