This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
the paint, it is flaking and rusting underneath. yes it is avail for inspection the paint flakes off in sheets while driving down the road it has been seen by the local dealership i first started noticing it when i was washing the vehicle.
Paint failure and delamination on a 2021 Kia Telluride with Snow White Pearl (SWP) paint. The paint on the roof above the windshield and the hood has begun peeling in sheets, exposing the underlying layer. The vehicle has not been in any accidents and has never been repainted. The paint failure appears to be a manufacturing defect involving the adhesion of the factory paint. The issue began around year 4-?"5 of ownership at approximately 60,000 miles. The affected areas continue to expand as the paint separates from the vehicle surface. The vehicle is available for inspection. A dealership inspection appointment has been scheduled. This appears consistent with other reported cases of paint delamination on Kia vehicles with Snow White Pearl paint.
The satin window trim at the bottom the passenger and driver windows have come loose due to poor adhesive. The heat softened the glue over time and metal satin trim fell off in the middle of the expressway and the other 3 bottom trims have gotten loose due to the bad / wrong glue used to adhere them. The new model have this recall, but this issue is happening also to the 2020 SX trim. The issue is the trim is metal and it gets hot in the sun and the heat softens the glue which then over time the metal starts to separate from the plastic trim housing and fall off while driving which a can cause an accident / injury.
The sunroof malfunctioned while I was attempting to open it, producing a loud pop and causing the glass to become misaligned while the vehicle was parked. There have been numerous reports of this same issue, including incidents in which the sunroof glass has shattered. This appears to be a known defect; however, Kia has refused to acknowledge responsibility or perform the necessary repairs. Kia has quoted the cost of repair at $5,800.
- Pearland, TX, USA
Search CarComplaints.com for these popular complaint phrases...
Several oil housing changes. I-??m not the first owner, the oil housing has been changed once already and I-??m going to have to do it a second time, the car is only 5 years old. I-??ve only owned the vehicle 2 years. The dealership did no diligence to check it, I went to the dealership for years and due to negligence with my oil changes and recalls I stopped going, now I-??m having to pay out of pocket for issues they-??ve caused. I thought I messed up my car and had a part dragging at the bottom, when I took it in to the dealership they said it was previously not bolted down properly. I had a recall, I was told 3 times my lights were connected and I was -??good to go-?? each time I got in and the car said my lights were not connected. After this I never came back! Not sure if it-??s the dealership issue or on the car for my oil housing leak.
The 2020 Kia Telluride has an issue with the metal window trim pieces. It was purchased as a Certified Pre-Owned vehicle and we have had to have the trim piece replaced at least three times by the Kia Dealer. The piece keep becoming loose and falling off. Some of the pieces on my vehicle have jus fallen off. At interstate speeds of 70 MPH it would be very dangerous. Fortunately, no incident has happened that has hurt anyone, yet. The 2023-2025 models have been recalled for this exact same issue, and it needs to happen for ALL Kia Telluride models including the 2020-2023 models. It is dangerous and Ken Ganley Kia of New Port Richey is no longer assisting with any sort of warranty or repair unless I do the work. I am having to reach out to Kia and open a case number every time and the dealership is no longer being helpful. This is our primary vehicle used for getting children to school, leisure travel, and daily commuting. Attached are three different incidents of the exact same issue happening. 8/24/2025, 8/11/2025, and 11/21/2025. The dealership also repair some when we initially purchased the vehicle. All work orders can be provided via Ken Ganley Kia of New Port Richey.
The original Telluride muffler developed a hole in the rear wall, hidden by the exhaust pipes. Within a week of the noise being noticeable I visited a car wash, afterwards someone asked me what I'd done to my rear bumper? I hadn't hit anything. When I looked, I was shocked. About 15" of the silver trimwork was torn off, still attached. Today I had the muffler replaced at Midas here in Toledo( (at a considerable cost) I asked the manager to look at the damage and told him it wasn't there until after the carwash. He said that the heat from the hole in the muffler had melted the bumper enough so that the brushes in the carwash were able to catch the edge and pull it off. Why is the muffler positioned SO CLOSE to the bumper? Tomorrow(11/18) I will visit the Taylor Kia Dealership(where I purchased the Telluride in 2020. Can there be a recall" Can future Tellurides be equiped with heat shield/different muffler placement"
Windshield cracked from minor item being thrown up by car in front of me. Engine burns out no oil on dipstick with regular maintenance engine tick transmission slips axle boot ripped oil pan cracked due to it being faulty
Sunroof could not be retracted due to track breaking during normal operation. Repairs have been made and part is not available for inspection. Passenger safety put at risk due to exposure to rain and cold in the passenger compartment. Problem confirmed at an independent service center. Vehicle was inspected at the service center. This happened without warning. Other owners have experienced the same problem.
We bought this brand new and have the paint peeling off. It-??s a 2020 so paint should not be pealing off. I have read that they are aware of this paint issue but nothing is done yet about it.
I have the white pearl paint on my 2020 Telluride. It-??s chipping in chunks on the roof and in smaller batches across the body. I paid extra for this paint and from recent research, I-??m reading this is a common issue. I-??d like this to be repaired. I only have 37,000 miles on the vehicle. I first noticed it as small chips and now it-??s present in more locations and expanding in width and length.
The roof paint is delaminating. The problem has only gotten worst. The color is pearl white. Multiple calls to Kia consumer service and dealer- No action and response.
The Pearl white paint used on Kia and Hyundai models does not adhere to the primer coat underneath causing bubbling and eventual paint peeling issues overtime that is premature in nature. This has been reported in numerous locations across the internet as found by a basic search for the issue. Consumers are left to foot the bill on a improper manufacturing issue that should be taken care of by the manufacturer.
Car was parked in the driveway when a large piece of the roof paint fell off. The car is the white/pearl color. Color is reportedly known to have defect.
Driver side power folding mirror is malfunctioning. It will sometimes get stuck in one position and won-??t retract unless manually repositioned. It has not yet been inspected by the manufacturer. No warning lamps have appeared. A Google search of the issue suggests this may be a common issue with the vehicle make and model.
A D V E R T I S E M E N T S
- Shafter, CA, USA