TSB List for the 1997 Mercury Cougar

Technical Service Bulletins (TSBs) for the 1997 Cougar are official communications between Mercury & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.

  • STEERING
  • SUSPENSION
  • SERVICE BRAKES, HYDRAULIC:SWITCHES:BRAKE LIGHT
  • SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
  • SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
  • SERVICE BRAKES, AIR:DISC:ROTOR
  • ENGINE AND ENGINE COOLING
  • ENGINE AND ENGINE COOLING:ENGINE
  • ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
  • ENGINE AND ENGINE COOLING:COOLING SYSTEM
  • ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
  • ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
  • ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
  • ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
  • FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
  • POWER TRAIN
  • POWER TRAIN:MANUAL TRANSMISSION
  • POWER TRAIN:AUTOMATIC TRANSMISSION
  • POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
  • POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
  • POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
  • POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
  • POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
  • POWER TRAIN:AXLE ASSEMBLY
  • ELECTRICAL SYSTEM
  • ELECTRICAL SYSTEM:STARTER ASSEMBLY
  • ELECTRICAL SYSTEM:WIRING
  • ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
  • ELECTRICAL SYSTEM:IGNITION
  • ELECTRICAL SYSTEM:IGNITION:MODULE
  • EXTERIOR LIGHTING:HEADLIGHTS
  • EXTERIOR LIGHTING:BRAKE LIGHTS
  • VISIBILITY:WINDSHIELD
  • VISIBILITY:WINDSHIELD WIPER/WASHER
  • VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE
  • STRUCTURE:BODY
  • STRUCTURE:BODY:DOOR
  • LATCHES/LOCKS/LINKAGES:DOORS:LATCH
  • TIRES
  • SEATS
  • SEATS:FRONT ASSEMBLY:POWER ADJUST
  • EQUIPMENT:ELECTRICAL
  • EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
  • EQUIPMENT:APPLIANCE:AIR CONDITIONER
  • UNKNOWN OR OTHER
  • STEERING

    • TSB #98216

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #603669

      A STEERING WHEEL MOVEMENT FELT WHEN DRIVING OVER ROUGH SURFACES. Read More »

    SUSPENSION

    • TSB #BC3281970206

      Date Announced:
      FEB 06, 1997
      NHTSA ID:
      #51877

      VEHICLES EXHIBIT A PULL WHILE BRAKING - CHECK FOR KINKED BRAKE LINES , REPLACE IF NECESSARY - REPLACE LOWER ARM AND STRUT BUSHINGS ON THE SIDE THE VEHICLE PULL TO. *TW Read More »

    SERVICE BRAKES, HYDRAULIC:SWITCHES:BRAKE LIGHT

    • TSB #02176

      Date Announced:
      SEP 02, 2002
      NHTSA ID:
      #10008580

      LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ Read More »

    SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

    • TSB #99194

      Date Announced:
      SEP 20, 1999
      NHTSA ID:
      #6090082

      INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT Read More »

    • TSB #985A18

      Date Announced:
      MAR 18, 1998
      NHTSA ID:
      #601018

      SOME VEHICLES MAY EXHIBIT BRAKE ROUGHNESS (BRAKE PEDAL PULSATION, STEERING WHEEL SHAKE AND / OR NIBBLE) UNDER LIGHT BRAKE APPLICATIONS FROM 105 TO 0 KM/H (65 TO 0 MPH). *YC Read More »

    • TSB #985A11

      Date Announced:
      MAR 18, 1998
      NHTSA ID:
      #601009

      SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC Read More »

    • TSB #96222

      Date Announced:
      OCT 21, 1996
      NHTSA ID:
      #50941

      BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW Read More »

    SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

    • TSB #985A5

      Date Announced:
      MAR 18, 1998
      NHTSA ID:
      #601003

      HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC Read More »

    • TSB #9814

      Date Announced:
      JAN 19, 1998
      NHTSA ID:
      #605562

      SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT Read More »

    SERVICE BRAKES, AIR:DISC:ROTOR

    • TSB #9845

      Date Announced:
      MAR 02, 1998
      NHTSA ID:
      #601264

      AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC Read More »

    ENGINE AND ENGINE COOLING

    • TSB #0222

      Date Announced:
      FEB 04, 2002
      NHTSA ID:
      #630628

      SOME VEHICLES MAY EXHIBIT AN INTAKE MANIFOLD CROSSOVER (FIRST RUNNER) COOLANT SEEPAGE CONDITION. *TT Read More »

    • TSB #99B29

      Date Announced:
      DEC 01, 1999
      NHTSA ID:
      #612219

      SOME VEHICLES MAY EXPERIENCE ENGINE COOLANT LEAKS AT THE ENGINE FRONT COVER GASKET. OWNER NOTIFICATION PROGRAM PROVIDING REPLACEMENT OF THE ENGINE FRONT COVER GASKET. *TT Read More »

    • TSB #99207

      Date Announced:
      OCT 04, 1999
      NHTSA ID:
      #6089651

      SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT Read More »

    • TSB #13186

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090542

      INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS Read More »

    • TSB #99131

      Date Announced:
      JUN 28, 1999
      NHTSA ID:
      #606484

      CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT Read More »

    • TSB #97050110617

      Date Announced:
      MAY 01, 1997
      NHTSA ID:
      #52896

      VEHICLES MAY EXPERIENCE ILLUMINATION OF THE ENGINE COOLING INDICATOR LIGHT. *TW Read More »

    ENGINE AND ENGINE COOLING:ENGINE

    • TSB #07212

      Date Announced:
      OCT 01, 2007
      NHTSA ID:
      #10023943

      SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. Read More »

    • TSB #02221

      Date Announced:
      NOV 11, 2002
      NHTSA ID:
      #10008304

      ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ Read More »

    • TSB #870197

      Date Announced:
      OCT 22, 2002
      NHTSA ID:
      #10000592

      INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. Read More »

    • TSB #99B29#1

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613562

      INFORMATION REGARDING REPLACMENT OF ENGINE FRONT COVER GASKET. **MR Read More »

    • TSB #6996

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090309

      INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT Read More »

    • TSB #6997

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090310

      SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT Read More »

    • TSB #13180

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090538

      INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS Read More »

    • TSB #9874

      Date Announced:
      APR 13, 1998
      NHTSA ID:
      #601343

      A NEW SILICONE GASKET AND SEALANT. *YC Read More »

    • TSB #983224

      Date Announced:
      FEB 12, 1998
      NHTSA ID:
      #607436

      SOME VEHICLES MAY HAVE WATER CONTAMINATION IN THE AIR FILTER AND / OR THE MASS AIR FLOW SENSOR. *TT Read More »

    • TSB #97610

      Date Announced:
      MAR 17, 1997
      NHTSA ID:
      #51990

      BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD Read More »

    ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

    • TSB #0214

      Date Announced:
      JAN 21, 2002
      NHTSA ID:
      #630001

      SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »

    • TSB #01246

      Date Announced:
      DEC 10, 2001
      NHTSA ID:
      #630515

      ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT Read More »

    • TSB #01205

      Date Announced:
      OCT 15, 2001
      NHTSA ID:
      #627927

      SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »

    • TSB #0147

      Date Announced:
      MAR 05, 2001
      NHTSA ID:
      #619424

      SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT Read More »

    • TSB #99816

      Date Announced:
      MAY 03, 1999
      NHTSA ID:
      #606420

      FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT Read More »

    • TSB #983107

      Date Announced:
      FEB 25, 1998
      NHTSA ID:
      #607401

      BRIEF INFORMATION REGARDING ENGINES BEING ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *TT Read More »

    • TSB #983108

      Date Announced:
      FEB 01, 1998
      NHTSA ID:
      #607402

      EFFECTIVE MARCH 2, 1998M3.8L ENGINE ASSEMBLY IS ADDED TO FQR(FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *AK Read More »

    ENGINE AND ENGINE COOLING:COOLING SYSTEM

    • TSB #BC0192970201

      Date Announced:
      JAN 02, 1997
      NHTSA ID:
      #51063

      LOW COOLANT LIGHT STAYS ON. THE LOW FLUIDS MODULE IN THE CLUSTER NOT MAKING ELECTRICAL CONTACT WTH THE FLEX CURCUIT IN THE CLUSTER. *JD Read More »

    ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

    • TSB #BC3243970210

      Date Announced:
      FEB 10, 1997
      NHTSA ID:
      #51865

      ENGINE COOLING LIGHT ON - POSSIBLE OIL LEAK AT UPPER JAM NUT ON THE UPPER TRANSMISSION COOLER LINE. *TW Read More »

    ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

    • TSB #982010

      Date Announced:
      OCT 12, 1998
      NHTSA ID:
      #603695

      EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC Read More »

    • TSB #9864

      Date Announced:
      MAR 30, 1998
      NHTSA ID:
      #601312

      INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT Read More »

    • TSB #BC0407961115

      Date Announced:
      NOV 15, 1996
      NHTSA ID:
      #50753

      INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED PARTS. *TW Read More »

    • TSB #BC0490961112

      Date Announced:
      NOV 12, 1996
      NHTSA ID:
      #50763

      INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED COMPONENT. *TW Read More »

    • TSB #BC9714961101

      Date Announced:
      NOV 01, 1996
      NHTSA ID:
      #50860

      DIAGNOSTIC INSTRUCTIONS FOR SERVICING EVAPORATIVE EMISSION PURGE FLOW SYSTEM. *TW Read More »

    ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

    • TSB #982310

      Date Announced:
      NOV 23, 1998
      NHTSA ID:
      #603724

      MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK Read More »

    • TSB #9834

      Date Announced:
      FEB 16, 1998
      NHTSA ID:
      #600588

      AIR INLET-WATER IN AIR INLET ELBOW-MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATES DUE TO WATER CONTAMINATION OF AIR FILTER AND/OR MASS AIR FLOW SENSOR (MAF)- VEHICLE SWITH 4.6L ENGINE. *AK Read More »

    ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

    • TSB #05N04

      Date Announced:
      DEC 14, 2005
      NHTSA ID:
      #10018959

      EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. Read More »

    FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM

    • TSB #97M91

      Date Announced:
      JAN 19, 1998
      NHTSA ID:
      #605621

      INFORMATION REGARDING ADDITIONAL COVERAGE FOR INTAKE MANIFOLD MALFUNCTIONS. *TT Read More »

    • TSB #96225

      Date Announced:
      OCT 21, 1996
      NHTSA ID:
      #50944

      MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW Read More »

    POWER TRAIN

    • TSB #9943

      Date Announced:
      MAR 08, 1999
      NHTSA ID:
      #604751

      INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT Read More »

    POWER TRAIN:MANUAL TRANSMISSION

    • TSB #996041

      Date Announced:
      MAY 01, 1999
      NHTSA ID:
      #606956

      VEHICLES MAY EXHIBIT A HARD TO SHIFT CONDITION IN COLD WEATHER. *TT Read More »

    • TSB #11791

      Date Announced:
      AUG 01, 1998
      NHTSA ID:
      #615292

      SOME VEHICLES WITH CD4E TRANSMISSION MAY EXHIBIT A CONDITION OF NO CRANK / NO START IN PARK. VEHICLE WILL CRANK AND START IN NEUTRAL. *TT Read More »

    • TSB #4674

      Date Announced:
      AUG 01, 1998
      NHTSA ID:
      #615213

      SOME VEHICLES WITH CD4E TRANSMISSION MAY EXHIBIT A CONDITION OF NO CRANK / NO START IN PARK. VEHICLE WILL CRANK AND START IN NEUTRAL. *TT Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION

    • TSB #03261

      Date Announced:
      JAN 05, 2003
      NHTSA ID:
      #10008279

      NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT Read More »

    • TSB #0015

      Date Announced:
      JAN 10, 2000
      NHTSA ID:
      #612203

      INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS Read More »

    • TSB #99152

      Date Announced:
      JUL 26, 1999
      NHTSA ID:
      #608431

      INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT Read More »

    • TSB #9996

      Date Announced:
      MAY 17, 1999
      NHTSA ID:
      #606428

      EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. Read More »

    • TSB #982312

      Date Announced:
      NOV 23, 1998
      NHTSA ID:
      #603740

      ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC Read More »

    • TSB #9888

      Date Announced:
      APR 27, 1998
      NHTSA ID:
      #601238

      INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC Read More »

    • TSB #97511

      Date Announced:
      MAR 03, 1997
      NHTSA ID:
      #51945

      FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD Read More »

    • TSB #BC0226970201

      Date Announced:
      JAN 02, 1997
      NHTSA ID:
      #51082

      ERRATIC SHIFTHING OF THE TRANSMISSION. *JD Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

    • TSB #042107

      Date Announced:
      DEC 13, 2004
      NHTSA ID:
      #10014086

      GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT Read More »

    • TSB #04217

      Date Announced:
      NOV 01, 2004
      NHTSA ID:
      #10013369

      GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)

    • TSB #9773

      Date Announced:
      MAR 31, 1997
      NHTSA ID:
      #51910

      VIBRATION- SHUDDER OR VIBRATION UNDER LIGHT TO MODERATE ACCELERATION ABOVE 56 KM/H (35 MPH) WHILE IN 3RD OR 4TH GEAR- VEHICLES EQUIPPED WITH AODE OR 4R70W TRANSMISSION. *JD Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

    • TSB #03148

      Date Announced:
      JUL 21, 2003
      NHTSA ID:
      #10003748

      NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT Read More »

    • TSB #002310

      Date Announced:
      NOV 13, 2000
      NHTSA ID:
      #616522

      SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

    • TSB #9887

      Date Announced:
      APR 27, 1998
      NHTSA ID:
      #601237

      EXPERIENCING A TORQUE CONVERTER CLUTCH SHUDDER OR VIBRATION. *YC Read More »

    • TSB #962612

      Date Announced:
      DEC 16, 1996
      NHTSA ID:
      #50997

      TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW Read More »

    • TSB #96249

      Date Announced:
      NOV 18, 1996
      NHTSA ID:
      #50908

      TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW Read More »

    • TSB #BC0810961011

      Date Announced:
      OCT 11, 1996
      NHTSA ID:
      #50412

      VEHICLES EQUIPPED W/ AN AODE OR 4R70W TRANS HAS A CONCERN OF SHUDDER FROM THE TRANSMISSION TORQUE CONVERTER CLUTCH IN 3RD OR 4TH GEAR OR DURING 3-4 SHIFT. *TT Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH

    POWER TRAIN:AXLE ASSEMBLY

    • TSB #0019

      Date Announced:
      JAN 10, 2000
      NHTSA ID:
      #612301

      INFORMATION REGARDING SEVERAL INTERNAL CHANGES THAT HAVE BEEN IMPLEMENTED ON THE MRX-75 TRANSAXLE TO IMPROVE SHIFT EFFORTS. *MJS Read More »

    • TSB #BC5197961001

      Date Announced:
      OCT 01, 1996
      NHTSA ID:
      #50474

      SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT Read More »

    ELECTRICAL SYSTEM

    • TSB #03181

      Date Announced:
      SEP 15, 2003
      NHTSA ID:
      #10004027

      REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT Read More »

    • TSB #98246

      Date Announced:
      DEC 07, 1998
      NHTSA ID:
      #604059

      FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »

    ELECTRICAL SYSTEM:STARTER ASSEMBLY

    • TSB #97111097234

      Date Announced:
      NOV 10, 1997
      NHTSA ID:
      #53660

      VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC Read More »

    ELECTRICAL SYSTEM:WIRING

    • TSB #99222

      Date Announced:
      OCT 18, 1999
      NHTSA ID:
      #6089681

      SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT Read More »

    • TSB #96246

      Date Announced:
      NOV 18, 1996
      NHTSA ID:
      #50905

      WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW Read More »

    ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH

    • TSB #BC2291970501

      Date Announced:
      MAY 01, 1997
      NHTSA ID:
      #52787

      COMPLAINTS OF FLASHING LOW COOLANT AND LOW WASHER FLUID WARNING LAMPS. *TW Read More »

    • TSB #BC105869705

      Date Announced:
      MAY 01, 1997
      NHTSA ID:
      #52866

      OCCASIONAL FLASHING OF THE LOW COOLANT AND LOW WASHER FLUID WARNING LAMPS SIMULTANEOUSLY DURING LOW TEMPERATURES. *TW Read More »

    ELECTRICAL SYSTEM:IGNITION

    • TSB #BC0696961023

      Date Announced:
      OCT 23, 1996
      NHTSA ID:
      #50368

      CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT Read More »

    ELECTRICAL SYSTEM:IGNITION:MODULE

    • TSB #9943

      Date Announced:
      MAR 08, 1999
      NHTSA ID:
      #604751

      INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT Read More »

    • TSB #BC3285970206

      Date Announced:
      FEB 06, 1997
      NHTSA ID:
      #51881

      VEHICLES MAY EXHIBIT FLASHINIG COOLANT AND LOW WASHER FLUID LAMPS AFTER ENGINE START AND DURING EXTREMELY LOW TEMPERATURES. *TW Read More »

    • TSB #962511

      Date Announced:
      DEC 02, 1996
      NHTSA ID:
      #50968

      POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW Read More »

    EXTERIOR LIGHTING:HEADLIGHTS

    • TSB #BC3274970207

      Date Announced:
      FEB 07, 1997
      NHTSA ID:
      #51872

      REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS ... Read More »

    EXTERIOR LIGHTING:BRAKE LIGHTS

    • TSB #99139

      Date Announced:
      JUN 28, 1999
      NHTSA ID:
      #606508

      CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT Read More »

    VISIBILITY:WINDSHIELD

    • TSB #96221

      Date Announced:
      OCT 21, 1996
      NHTSA ID:
      #50940

      WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW Read More »

    VISIBILITY:WINDSHIELD WIPER/WASHER

    • TSB #12098

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613082

      SOME VEHICLES WITH NON-FUNCTIONAL WINDSHIELD WIPERS MAY REQUIRE WIPER MOTOR REPLACEMENT. *MJS Read More »

    • TSB #985111

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613261

      SOME VEHICLES WITH NON-FUNCTIONAL WINDSHIELD WIPERS MAY REQUIRE WIPER MOTOR REPLACEMENT. *TT Read More »

    VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE

    • TSB #01156

      Date Announced:
      AUG 06, 2001
      NHTSA ID:
      #623944

      SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC Read More »

    STRUCTURE:BODY

    • TSB #982323

      Date Announced:
      NOV 23, 1998
      NHTSA ID:
      #603930

      INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC Read More »

    • TSB #9831

      Date Announced:
      FEB 16, 1998
      NHTSA ID:
      #600585

      REPAIRS TO VINYL COVERED SURFACES. *YC Read More »

    • TSB #9833

      Date Announced:
      FEB 16, 1998
      NHTSA ID:
      #600587

      SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC Read More »

    • TSB #BC105709705

      Date Announced:
      MAY 01, 1997
      NHTSA ID:
      #52853

      INSTRUCTIONS FOR RE-INSTALLING LOOSE FENDER CLADDING. *TW Read More »

    STRUCTURE:BODY:DOOR

    • TSB #99242

      Date Announced:
      NOV 15, 1999
      NHTSA ID:
      #6090184

      INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT Read More »

    • TSB #99-8-15

      Date Announced:
      MAY 03, 1999
      NHTSA ID:
      #606419

      SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT Read More »

    • TSB #98163

      Date Announced:
      AUG 17, 1998
      NHTSA ID:
      #6090873

      LOCKS FAILED. YD Read More »

    LATCHES/LOCKS/LINKAGES:DOORS:LATCH

    • TSB #96252

      Date Announced:
      DEC 02, 1996
      NHTSA ID:
      #50959

      LOCKS - REPLACE AND/OR REPAIR ANY LOCK COMPONENT - SERVICE TIP. *TW Read More »

    TIRES

    • TSB #9852

      Date Announced:
      APR 13, 1998
      NHTSA ID:
      #601290

      INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC Read More »

    • TSB #9753

      Date Announced:
      MAR 03, 1997
      NHTSA ID:
      #51933

      VIBRATION- TIRES- VIBRATION FELT WHILE DRIVING AT HIGHWAY SPEEDS- VEHICLES BUILT THROUGH 12/20/96 EQUIPPED WITH 16 INCH GOODYEAR TIRES. *JD Read More »

    • TSB #BC5195961001

      Date Announced:
      OCT 01, 1996
      NHTSA ID:
      #50472

      FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT Read More »

    SEATS

    • TSB #9751

      Date Announced:
      MAR 03, 1997
      NHTSA ID:
      #51931

      INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD Read More »

    SEATS:FRONT ASSEMBLY:POWER ADJUST

    • TSB #BC0702961022

      Date Announced:
      OCT 22, 1996
      NHTSA ID:
      #50372

      INFORMATION ON SIDE SHIELD FOR THE POWER DRIVER & PASSENGER SEAT. *TT Read More »

    EQUIPMENT:ELECTRICAL

    • TSB #BC1024397230

      Date Announced:
      JAN 23, 1997
      NHTSA ID:
      #51611

      VEHICLES BUILT BETWEEN AUGUST 1996 AND JANUARY 1997 MAY EXHIBIT FLASHING LOW COOLANT AND LOW WASHER FLUID LAMPS AFTER ENGINE START.JD Read More »

    EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

    • TSB #99129

      Date Announced:
      JUN 14, 1999
      NHTSA ID:
      #606460

      EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Read More »

    • TSB #9873

      Date Announced:
      APR 13, 1998
      NHTSA ID:
      #601341

      EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT Read More »

    • TSB #97090297184

      Date Announced:
      SEP 02, 1997
      NHTSA ID:
      #54070

      SOME VEHICLES MAY EXPERIENCE STATIC IN THE AM BAND OF THE RADIO WHILE DRIVING. *YC Read More »

    EQUIPMENT:APPLIANCE:AIR CONDITIONER

    • TSB #02208

      Date Announced:
      OCT 14, 2002
      NHTSA ID:
      #10013060

      CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH Read More »

    • TSB #99196

      Date Announced:
      SEP 20, 1999
      NHTSA ID:
      #6090087

      INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »

    • TSB #9735

      Date Announced:
      FEB 03, 1997
      NHTSA ID:
      #51662

      AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD Read More »

    • TSB #96226

      Date Announced:
      OCT 21, 1996
      NHTSA ID:
      #50945

      AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW Read More »

    UNKNOWN OR OTHER

    • TSB #01157

      Date Announced:
      AUG 06, 2001
      NHTSA ID:
      #623988

      INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC Read More »

    • TSB #991210

      Date Announced:
      JUN 14, 1999
      NHTSA ID:
      #606461

      FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT Read More »

    • TSB #99111

      Date Announced:
      JUN 14, 1999
      NHTSA ID:
      #606433

      INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT Read More »

    • TSB #98259

      Date Announced:
      DEC 21, 1998
      NHTSA ID:
      #603647

      SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. Read More »

    • TSB #BC2364970501

      Date Announced:
      MAY 01, 1997
      NHTSA ID:
      #52812

      INSTRUCTIONS FOR REMOVING AND REINSTALLING A LOOSE FENDER CLADDING. *TW Read More »

    • TSB #9768

      Date Announced:
      MAR 17, 1997
      NHTSA ID:
      #51987

      FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD Read More »

    • TSB #BC1023897230

      Date Announced:
      JAN 23, 1997
      NHTSA ID:
      #51604

      VEHICLE EXHIBITS A PULL WHILE BRAKING, FOLLOW PROCEDURES OUTLINED IN 06-00-4 & PINPOINT TEST "A" ON 06-00-5 OF THE 1997 SERVICE MANUAL. *JD Read More »

    Browse Other Cougar Years