This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
March 10,2023 2019 Ram 2500 Cummins 6.7L Diesel I picked up my truck from the dealership this morning, after they did the outstanding CP4 fuel pump recall. I drove the vehicle home (approx 20) miles. Parked the car in the driveway for about 3 hours. Then took a short trip to the store. After the store, when leaving the parking lot I noticed an electrical/plastic smell. Within in seconds smoke started to come through the air vents. I pulled the truck over, turned off the truck, open the hood when fire exspelled from the engine compartment. Immediately call the fire department. They arrived in minutes to put out the fire, but at that point the whole front end of the truck was on fire and smoking (dense white/gray smoke). Then there was a loud burst of flame that came from the engine compartment. The fire worked its way into the cab compartment, burned it completely. The truck is totaled.
RE: "If the manufacturer has failed or is unable to remedy this safety recall for your vehicle in a timely manner, please contact the NHTSA Vehicle Safety Hotline at: 1-888-327-4236 or TTY: 1-800-424-9153 or file an online complaint with NHTSA. This recall was issued in November 2022. My local dealer, Carson Dodge in Carson City, Nevada, will not honor the recall and will not fix my vehicle. I have repeatedly asked for the repair and keep getting blown off, telling me I'm on an indefinite waiting list. I insisted once to confirm I am on the waiting list and where I am at. I was told my car would be repaired in February 2023. February came and went and they still refuse to repair the car or provide a date when the repair might be possible. The fuel pump has now failed and the car has been dead in my driveway for a week and a half. I am without my primary means of transportation to get to work. Calls and emails to the service manager at Carson Dodge have been ignored and unanswered. I am reaching out to you to request assistance. The dealer will not fix the car and will not communicate with me. The car is non-operational now and will have to be towed. I desperately need my vehicle and I am respectfully requesting assistance with a recalcitrant dealership.
I have been having issues starting my truck when I took it in they said it was an ecu reflags needed. I believe it is an open recall y78 for over a year and they do not have the part. But my truck all of a sudden loss power on the freeway doing 65 my wife and daughter started crying I barely made it to the edge of the freeway with being hit within inches of a semi truck. We sat on the side of the freeway with trucks passing us shaking our truck from the wind. Finally I had to call Chp to have cars slow down when it became night time I fears for the safety of my wife and daughter. Yes the issue now is it won-€™t start at all but they are telling me go somewhere else it could take 2-3 months to fix the issue. No one inspected it yet just that it wouldn-€™t start. It was continuously having power surges but too light. Then all of a sudden loss power and it says service exhaust system see dealer.
We bought our truck in November 22, 2022, used certified pre-owned with 22135 miles, On 12/27/2022 message code came on water in fuel tank. 12/29/2022 dealership service helped us to drain fuel filters and cleared the code. 12/30/2022 same code came back. 1/8/2023. Truck broke down with a major total fuel system damaged. Parts were ordered, but repairs did not start yet. Everyone is trying to say it is a user error. We refilled DEF liquid correctly after which the gage showed was almost full. Dealership was blaming bad diesel was used, but as a consumer how in the world will i know which brand or company: they all are governed to sell proper diesel. We only drove about 3000 miles. There's no way possible for such to happen. Dealership told us ok to drive and keep refilling fresh diesel. We learned that there was already a recall for fuel system back in September of 2022. Supposedly if diligently and correctly it was taken care of, this same problem should have not come back at least for the next 10000+ miles. We only put on about 3000 miles from the date of purchase. Also according to inspection of dealership and service history, they also replaced fuel filters in October of 2022. Truck broke down even before our first payment was to be due. Currently our truck is not drivable and we are in 7 yrs loan. Absolutely ridiculous. There must of been a hidden tank leak that caused fuel contamination. Dealership where our truck is confirmed DEF liquid was mixed with diesel gas and a corrosion around some parts. Please help us! This is a nightmare. Thank you so much in advance!
I have been trying for a year to get my recall performed. When I go to the dealer they say there is no parts available and I should contact FCA Recall Assistance. When I call FCA Recall Assistance they say parts are available and that I should try a different dealer. I have tried 3 dealerships and no one will fix the recall. I can't even register the vehicle because in California recalls need to be performed for registration. I do not know who else to turn to.
- Santa Rosa, CA, USA
Search CarComplaints.com for these popular complaint phrases...
The contact owns a 2019 Ram 2500. The contact received notification of NHTSA Campaign Number: 21V880000 (Fuel System, Diesel) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the vehicle had failed to immediately start a few times and it took a few attempts before the vehicle started. The contact noticed a ticking noise and when accelerating and or decelerating a grinding noise would come form the engine compartment of the vehicle. The were no warning lights. The failure occurred intermittently. The approximate failure mileage was 39,239. Remedy not yet available or Parts distribution disconnect.
Y78 Fuel Pump in 2019 Ram 2500 Cummins is going out. Has see dealer warning. Ram is saying no parts available until next year. Not an acceptable remedy.
Issue with high pressure fuel pump and loss of turbo boost. At first Mopar/ Dodge refused to replace the fuel pump regardless of the recall. After hours on the phone they finally agreed to replace fuel pump but said no idea why turbo isn-€™t working correctly.
FCA recall Y78 NHTSA 21V-880 is open on my truck, states "fuel starvation may result in an unexpected loss of motive power, which can cause vehicle crash without prior warning" Contacted local dealer, was told no parts available contact FCA recall assistance. Was told there was nothing they could do, I am to drive my vehicle until parts are available despite my vehicle being unsafe for myself and other drivers. Refused to transfer me, then finally did transfer me to Delivin the highest supervisor at FCA recall dept. Was told same thing, drive until crash or until parts arrive. Was also advised I could pay for parts then get reimbursed (even though recall parts not available. Was told there was a separate department to call if I did get into a crash. Kept telling me to contact dealer. Finally, Devin hung up on me. Contacted dealer again was told nothing they could do, i should contact Chrysler corporate. Contacted corporate spoke to Nicolette she told me same thing, drive until crash or parts available. Told her I felt unsafe, vehicle was unsafe. She hung up on me. I called back, spoke to Laurie she was nice and helpful but nothing else she could do, said supervisor would call me back. This vehicle, as per the recall description, is unsafe and should not be driven. I have been told now by all FCA representatives that FCA wants me to continue to drive an unsafe vehicle. I have also been told I could "pay for the parts and get reimbursed" but that the recall parts were not available.
While traveling home with a toddler, the high pressure fuel pump failed. It left my vehicle with no power or ability to move under it-€™s own power. It flashed a brief warning and then shut off, with no ability to restart. It left myself and my child stranded on the side of a busy byway. The dealership has confirmed that the issue was the high pressure fuel pump. Their remedy (at the direction of Ram) is to replace all necessary components, but to wash the fuel tank (instead of replace) and to reinstall the same make and model of fuel pump, that is know to be faulty. The 2019-€™s have a recall with the only remedy being to replace with the original design. However, 2020 version (which are mechanically identical) also have a recall where they are being instructed to install an updated version of the high pressure fuel pump. This leaves me with faulty equipment that is known to be prone to failure, yet the 2020 versions are receiving a much better and not prone to failure solution.
As I was pulling out of the parking to to merge with traffic, the truck lost all lost all response to the accelerator pedal midway into merging with on coming traffic. I was able to get the truck into the turn lane to avid being hit by traffic. as the truck costed to a stop the dash indicated that the to see dealer for exhaust system service.
I was driving home from the market and the truck slowed down to 16 mph. I could not go any faster. I pulled over to the middle of the street and turned the truck off for a minute. I then restarted it and attempted to drive it somewhere safe. The truck finally came to a stop right before an intersection. I had to get out because cars were coming fast. I was afraid someone was going to hit me. I called AAA right away. They told me the tow truck was on the way and that they would send the police. The police never showed up. The tow truck got there in about 15 minutes. The only information i have is the fuel system has a error code of P0087 and reads Fuelrail system pressure-too low. Check engine light is on, It did say something about the fuel system and the truck will not start. No one has looked at the truck yet. I will be calling the dealer this coming week to see about getting it checked out and having recall issues taken care of.
Being told that the fuel pump is not available by my local dealership and was told if the vehicle fails to operate I will be unable to be provided a loaner vehicle until a part can be manufactured I need to file a complaint this is new low mileage truck and if it goes down. Am I just of luck?
High pressure pump failure. Already recalled but not being repaired in a timely manner. Vehicle is in dealership parking lot, site says remedy not available but there is and manufacturer is not releasing it. The high pressure pump in the newest vehicles is the remedy.
Engine started to slip or misfire. Became worse and then light came on saying Exhaust Emission Service was needed. The truck lost power as it limped to the side of the road. The Service Electronic Ignition light then came on and truck turned off. Would not crank again.
Cp4 failed while driving down the road. Lost power and could not accelerate. Coasted to the side of the road. No warning. Was stranded on the side of IH310 in New Orleans area. Beings I was out of town I had to take it to a shop where they confirmed it was a cp4 pump failure and had to replace the pump and injectors out of pocket. Vehicle was inspected by a service provider and no issues before this.
Driving home one evening and truck started losing power and downshifting and completely disabled on the road. Transmission was blowing fluid out of the dipstick tube and engine was running horribly then died all of a sudden and wouldn-€™t start back up. Come to find out after having transmission repaired by a shop because Ram refused to warranty it, that the CP4 high pressure fuel pump has Grenaded and sent metal all through my fuel system and my truck is completely disabled with a -€œvoid-€ warranty due to a dealer claiming I didn-€™t perform a service on my truck that isn-€™t due for another 17,000 miles.
The 2019 to 2020 model year Ram 2500 heavy duty equipped with a 6.7L cummins diesel engine has a major safety issue that could cause a stall and increase the risk of a crash. The Bosch CP4.2 fuel injection pump has a very high rate of sudden failure leading to immediate stoppage on the engine and engine braking system. The pump destroys itself and takes out the rest of the entire fuel system leading to repairs in the $20,000 usd range. Fca & Ram have attempted to revise the pump in late (July) 2020 to solve the issue but the failures keep occurring. For the 2021 model year, fca & Ram have changed the pump entirely and reverted back to using an older, safer, more reliable design. No public announcements of neither the pump revision in 2020, nor the pump change in 2021 have been made. The issue is so prevalent that the replacement pumps and repairs generally have a 30-90 day wait period where the customer is without the primary vehicle. This problem is a substantiated safety risk. According to a Texas judge in a Bosch CP4.2 lawsuit, when another automaker, GM tried to dismiss the case saying the pump failure is not a safety issue, the court responded: "the worst case scenario of a truck spontaneously stalling at high speeds is not a mere inconvenience. Nor is it a mere inconvenience to spend between $8,000 to $20,000 on repairs to make the trucks fit for their ordinary purpose. The court rejects GM's suggestion that the risk of spontaneous engine failure while driving is not, as a matter of law, unreasonably dangerous, depriving the vehicles of fitness for their purpose of transportation.". Toyota agrees: "if a vehicle stall occurs while driving at higher speeds, this could increase the risk of a crash". fca & Ram have remedied the situation for the 2021 model year, however the 2019 and 2020 owners are still at risk. The NHTSA needs to force the hand of fca to recall.
I started my pickup and pulled out of garage put in park to close my garage door and with 2-3 minutes at idle, smoke was coming into the cab, got out of vehicle and opened hood and found flames coming from fuel injection pump area, was able to get fire out before it burnt the truck completely.
A D V E R T I S E M E N T S
- Lake In The Hills, IL, USA