All four tires are wearing unevenly. The outside of the tires are worn down much more than the middle and inside edge of tires. I noticed this six months ago, have called Toyota and brought the truck to the dealership and they stated there is no issue. I had the exact same Make/Model/Trim (3rd Generation Tundra TRD Pro) from 2022, and the tires wore out in the exact same manner. A safety recall was issued for this and all four tires were replaced and the alignment was adjusted to a "new standard" because it was determined that on this trim level, the original factory alignment was incorrect. This issue still hasn't been resolved as it is happening the exact same on the 2025 as it did on previous model years of the same trim. Toyota and dealership both refuse to even consider that this may be the same issue requiring a recall and replacement of tires and proper alignment. An internet search and an NHTSA search on this issue shows multiple instances of this complaint and nothing has been done to rectify.

- Fairfax, VA, USA

Alignment issues from the factory that Toyota refuses to rectify.

- Ardmore, OK, USA

All four tires on my 2025 Toyota Tundra experienced severe and abnormal outside edge wear at approximately 13,000 miles. The vehicle was purchased new and maintained according to manufacturer recommendations, including tire rotations every 5,000 miles at authorized Toyota dealerships. An authorized Toyota dealership inspected the vehicle, documented the abnormal tire wear, and performed alignment measurements. The dealership issued a written recommendation stating that a four-wheel alignment was needed to extend tire life and/or correct drivability concerns. Alignment measurements showed values outside specification. The tire manufacturer reviewed photos and documentation and confirmed the wear pattern is caused by vehicle alignment and not a tire manufacturing defect. The condition affected all four tires and required premature replacement, creating a potential safety concern due to reduced tread depth and handling stability. The issue appears to be related to steering or suspension geometry rather than normal tire wear.

- Delray Beach, FL, USA