2003 Chevrolet Cavalier
2003 Chevrolet Cavalier TSBs (Technical Service Bulletins)
There are also 2 Chevrolet recalls » 8 defect investigations » 148 TSBs » for the Chevrolet Cavalier.
Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB title & date, & either contact your local dealer or click on the links below.
ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use to track each bulletin -- yes, it's a very screwed up situation that's almost completely unhelpful to you as the consumer. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.
STEERING
- TSB #01-02-32-001 -- CONCERNS WITH CLUNK NOISE FROM FRONT OF VEHICLE TURNING MANEUVER / STEERING WHEEL ROTATION.*JB (LUBRICATE OR REPLACE INTERMEDIATE SHAFT AS APPROPRIATE). UPDATED 10/05/07. *NJ UPDATED 4/1/08. *NJ UPDATED 7/1/2008 *PE (NHTSA ID #618086, APRIL 01 2008)
- TSB #010232001F -- CLUNK FELT/NOISE HEARD FROM STEERING COLUMN, STEERING GEAR AND/OR FRONT OF VEHICLE DURING TURNING MANEUVER AND/OR STEERING WHEEL ROTATION. *TT (NHTSA ID #10019516, FEBRUARY 01 2006)
- TSB #040235004D -- CLUNK NOISE FROM FRONT OF VEHICLE DURING TURNING MANEUVER/STEERING WHEEL ROTATION. *TT *NM (NHTSA ID #10008657, NOVEMBER 01 2005)
- TSB #030232001B -- MOMENTARY REDUCTION OF POWER STEERING PS ASSIST ON INITIAL START UP WITH LOW AMBIENT TEMPERATURES. THIS SERVICE BULLETIN REPLACES 030232001A. *EH (NHTSA ID #10012093, JULY 01 2004)
- TSB #010232001C -- SOME CUSTOMERS MAY COMMENT ON A CLUNK TYPE NOISE COMING FROM THE FRONT OF THE VEHICLE DURING A TURNING MANEUVER. *TT (NHTSA ID #10004280, SEPTEMBER 01 2003)
- TSB #032403 -- A RATTLE /THUMPING TYPE NOISE HEARD AND SOMETIMES FELT THROUGH THE FLOORBOARD, PRIMARILY ON THE PASSENGER SIDE, WHEN TRAVELING OVER ROUGH ROADS. *TT *JB (NHTSA ID #10001864, MARCH 24 2003)
STEERING:COLUMN
STEERING:HYDRAULIC POWER ASSIST SYSTEM
- TSB #030232001A -- MOMENTARY REDUCTION ON POWER STEERING (P/S) ASSIST ON INITIAL START UP WITH LOW AMBIENT TEMPERATURES. *TT (NHTSA ID #10004762, OCTOBER 01 2003)
- TSB #022403 -- INTERMITTENT CONDITION OF A MOMENTARY REDUCTION IN POWER STEERING ASSIST AT STARTUP. *TT *JB (NHTSA ID #10001842, FEBRUARY 24 2003)
SUSPENSION
- TSB #040308015A -- SQUEAKING NOISE IN FRONT END ON TURNS. *TT (NHTSA ID #10011062, MAY 01 2005)
- TSB #040308010 -- CHANGES TO LABOR TIME GUIDE RELATING TO FRONT SUSPENSION LABOR OPERATIONS COMPONENTS. *EH (NHTSA ID #10012182, JUNE 01 2004)
- TSB #010310005C -- WHEEL SQUEAK ON VEHICLES WITH 14 AND 15 INCH WHEEL COVERS. *TT (NHTSA ID #10004752, OCTOBER 01 2003)
- TSB #010310005B -- WHEEL SQUEAK ON VEHICLES WITH 14 AND 15 INCH WHEEL COVERS. *TT (NHTSA ID #10001257, MARCH 01 2003)
- TSB #020308008 -- RATTLE, CREAK, POPPING TYPE NOISE FROM FRONT OF VEHICLE WHEN TURNING. *TT (NHTSA ID #10000465, NOVEMBER 01 2002)
- TSB #010310005A -- SQUEAK TYPE NOISE COMING FROM FRONT OR REAR WHEELS. VARIOUS MODELS INCLUDING THE 2001 TOYOTA CAVALIER. *TT (NHTSA ID #10000179, OCTOBER 01 2002)
- TSB #3263 -- FRONT SUSPENSION NOISE ON TURNS. *EH (NHTSA ID #10011819, no date provided)
SUSPENSION:FRONT
SERVICE BRAKES, HYDRAULIC
SERVICE BRAKES, HYDRAULIC:ANTILOCK:ABS WARNING LIGHT
SERVICE BRAKES, AIR
SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR
- TSB #00966 -- ANTI-LOCK BRAKING SYSTEM (ABS) FRONT WHEEL SPEED CODES - JUMPER HARNESS. *TT (NHTSA ID #10007816, JANUARY 01 2004)
- TSB #00966B -- ABS FRONT WHEEL SPEED CODES - JUMPER HARNESS. *TT (NHTSA ID #10007293, JANUARY 01 2004)
- TSB #3477 -- TECH 2 DISPLAYS ASTERISK FOR THE LEFT FRONT WHEEL SPEED SENSOR. *TT (NHTSA ID #10014875, no date provided)
PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE
ENGINE AND ENGINE COOLING
- TSB #050601002 -- ENGINE FAILURE DUE TO WATER INGESTION HYDRO LOCK. *EH (NHTSA ID #10013471, JANUARY 01 2005)
- TSB #610 -- ENGINE IDLE FLARE WHEN THE CLUTCH IS DEPRESSED. ALSO LOW SPEED ENGINE DECEL STALL WHEN COMING TO A STOP. GM TECH LINK. *TT (NHTSA ID #10015768, OCTOBER 01 2004)
- TSB #030601018 -- NEW CYLINDER BORE LINER REPLACEMENT PROCEDURE. THIS SERVICE BULLETIN REPLACES 030601018A. *EH (NHTSA ID #10012103, JULY 01 2004)
ENGINE AND ENGINE COOLING:ENGINE
- TSB #030604030 -- MULTIPLE DRIVEABILITY SYMPTOMS OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE DUE TO CLOGGED FUEL INJECTORS. *TT (NHTSA ID #10002166, MARCH 01 2007)
- TSB #050604026 -- VEHICLE HESITATES, NO START, LACK OF POWER, LOW FUEL PRESSURE. *TT (NHTSA ID #10017407, MAY 01 2005)
- TSB #040604063 -- ENGINE IDLE FLAIR WHEN CLUTCH DEPRESSED OR DECEL STALL. *TT (NHTSA ID #10011046, SEPTEMBER 01 2004)
- TSB #05202004 -- INTERMITTENT IDLE CONCERNS. *TT (NHTSA ID #10013273, MAY 20 2004)
- TSB #01353 -- ENGINE MISFIRE DUE TO INJECTOR FRETTING CORROSION. *TT (NHTSA ID #10007937, JANUARY 01 2004)
- TSB #3014 -- STALL, HESITATION, STUMBLE WITH NO DIAGNOSTIC TROUBLE CODES (DTCS). *TT (NHTSA ID #10008776, JANUARY 01 2004)
- TSB #030601022 -- GUIDELINES FOR CYLINDER BORE LINER/PISTON SLEEVE REPLACEMENT ON THE L4 ECOTEC ENGINE. *TT (NHTSA ID #10011117, JANUARY 01 2004)
- TSB #01525 -- ENGINE STALL HESITATION STUMBLE WITH NO DIAGNOSTIC TROUBLE CODES (DTCS). *TT (NHTSA ID #10005461, JANUARY 01 2004)
- TSB #00434 -- ENGINE WILL CRANK BUT NOT START, ALSO MAKES NOISE WHILE CRANKING. 2.2 L61 ENGINE. *TT (NHTSA ID #10007528, JANUARY 01 2004)
- TSB #01995 -- REPLACING A 02 OR 03 2.2L L61 WITH A 04 2.2L L61 ENGINE REPLACEMENT.*MR (NHTSA ID #10007055, JANUARY 01 2004)
- TSB #03064 -- ON-BOARD DIAGNOSTIC SYSTEM SOFTWARE UPGRADE - OBD SYSTEM IMPROVEMENTS. *TT (NHTSA ID #10005744, DECEMBER 01 2003)
- TSB #071103 -- THIS VME MESSAGE CONCERNS A CYLINDER BORELINER TOOL NOW AVAILABLE FOR THE L61 2.2 LITER ENGINE. THE TOOL IS REFERENCED IN SERVICE BULLETIN 030601018. THE PURPOSE OF THE TOOL IS TO EXTEND THE TOTAL SERVICE LIFE OF THE BLOCK. *TT (NHTSA ID #10003816, JULY 11 2003)
- TSB #030601018 -- NEW CYLINDER BORE LINER REPLACEMENT PROCEDURE. *TT (NHTSA ID #10002130, JUNE 01 2003)
- TSB #1749019 -- INFORMATION ON TRANSFERRING ORIGINAL FUEL RAIL TO GOODWRENCH ENGINE. *AK (NHTSA ID #10019208, no date provided)
- TSB #3433 -- SERVICE ENGINE SOON (SES) LIGHT AND SEVERE ENGINE MISFIRE ON CYLINDERS 1 AND 4 OR CYLINDERS 2 AND 3. *TT UPDATED 08-15-07. *KB (NHTSA ID #10017032, no date provided)
- TSB #3859 -- LOW OIL PRESSURE - INSPECT OIL FILTER FOR DAMAGE. *KB UPDATED 10/18/07. *NJ (NHTSA ID #10020923, no date provided)
ENGINE AND ENGINE COOLING:COOLING SYSTEM
- TSB #071503 -- COOLANT LOSE, EVIDENCE FLUID ON THE GARAGE FLOOR, ETC., OR COOLANT WARNING LIGHT COMING ON. *TT (NHTSA ID #10003789, JULY 15 2003)
- TSB #071003 -- THIS VME MESSAGE IS A WATER PUMP REPLACEMENT DUE TO A KNOWN CAM DRIVELINE. SOME CUSTOMERS MAY QUESTION ABOUT WHINE NOISE COMING FROM THE FRONT ENGINE AREA. *TT (NHTSA ID #10003815, JULY 10 2003)
FUEL SYSTEM, GASOLINE
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS
FUEL SYSTEM, OTHER
POWER TRAIN
- TSB #01604 -- 4T40E, 4T45E CHANGE IN APPEARANCE OF FORWARD, SECOND AND REVERSE CLUTCH WAVE PLATE. *TT (NHTSA ID #10007135, JANUARY 01 2004)
- TSB #030729005A -- CLUNK NOISE FROM FRONT END DURING LOW SPEED TURNS OR MANEUVERS. *TT (NHTSA ID #10004732, OCTOBER 01 2003)
- TSB #030730036 -- TRANSMISSION SLIPS IN 4TH GEAR, STUCK IN 2ND GEAR OR SES/TCS LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODES (DTCS) P0753, P0758, P1860, C1223, C1224 OR C1275 MAY BE SET. *TT (NHTSA ID #10004381, AUGUST 01 2003)
- TSB #030729005 -- CLUNK NOISE FROM FRONT END DURING LOW SPEED TURNS OR MANEUVERS. *TT (NHTSA ID #10002861, JUNE 01 2003)
- TSB #030730021 -- NEUTRAL FLARE AND/OR RPM FLARE WHILE IN DRIVE, NO 1-2 UPSHIFT, SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODES (DTCS) P1810, DIAGNOSTIC TROUBLE CODE P1815 SET. *TT (NHTSA ID #10002392, MAY 01 2003)
- TSB #020730050 -- ENGINEERING CHANGES TO THE VALVE BODY, PRESSURE REGULATOR VALVE, 2-3 ACCUMULATOR VALVE AND BORE FOR 2002-2003 MODEL YEAR 4T45E TRANSAXLES AND SUBSEQUENT OVERHAUL PROCEDURES WHICH AFFECT 1995-2001 MODEL YEAR TRANSAXLES. *TT (NHTSA ID #10000759, DECEMBER 01 2002)
- TSB #3447 -- 4T40E OR 4T45E WILL NOT SHIFT NO DIAGNOSTIC TROUBLE CODES. *TT (NHTSA ID #10017086, no date provided)
POWER TRAIN:CLUTCH ASSEMBLY
POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/LINKAGE
- TSB #020731003A -- CLUTCH PEDAL BUZZ OR VIBRATION. *TT (NHTSA ID #10004285, MARCH 01 2004)
- TSB #01522 -- CLUTCH PEDAL STAYS TO FLOOR REPEAT SLAVE CYLINDER FAIL. SIT BULLETIN 1405756. *TT (NHTSA ID #10005459, JANUARY 01 2004)
- TSB #020731003 -- CLUTCH PEDAL BUZZ OR VIBRATION. *TT (NHTSA ID #634966, MAY 01 2002)
- TSB #3915 -- CLUTCH PEDAL STAYS TO FLOOR. *TT (NHTSA ID #10019423, no date provided)
POWER TRAIN:MANUAL TRANSMISSION
POWER TRAIN:AUTOMATIC TRANSMISSION
- TSB #070730025 -- INFORMATION ON 4T40-E (MN4) AND 4T45-E (MN5) FRONT WHEEL DRIVE AUTOMATIC TRANSMISSION VALVE BODY RECONDITIONING, DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, HARSH SHIFTS, SLIPS, NO DRIVE, NO REVERSE. *NJ (NHTSA ID #10023942, OCTOBER 01 2007)
- TSB #020730039E -- FIRM TRANSMISSION SHIFTS, SHUDDER/CHUGGLE, TRANSMISSION WON'T DOWNSHIFT ON DECELERATION, SERVICE ENGINE SOON LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODE P0742 SET. *TT UPDATE. *TT (NHTSA ID #10004756, AUGUST 01 2005)
- TSB #030730012A -- TRANSAXLE OR TRANSMISSION SLIPS, WON'T SHIFT, NO REVERSE, 2ND, 3RD OR OVERDRIVE, ERRATIC SHIFTS. *TT (NHTSA ID #10004722, AUGUST 01 2005)
- TSB #030729005 -- CLUNK NOISE FROM FRONT END DURING LOW SPEED TURNS OR MANEUVERS. THIS SERVICE BULLETIN REPLACES 030729005A. *EH (NHTSA ID #10012102, JULY 01 2004)
- TSB #030730021A -- NEUTRAL FLARE AND/OR RPM FLARE WHILE IN DRIVE, NO 1-2 UPSHIFT, SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODES (DTCS) P1810, DIAGNOSTIC TROUBLE CODE P1815 SET. *TT (NHTSA ID #10005579, NOVEMBER 01 2003)
- TSB #020730039C -- FIRM TRANSMISSION SHIFTS, SHUDDER/CHUGGLE, TRANSMISSION WON'T DOWNSHIFT ON DECELERATION, SERVICE ENGINE SOON LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODE P0742 SET. *TT (NHTSA ID #10002840, JUNE 01 2003)
- TSB #01432 -- AUTOMATIC TRANSMISSION POOR ACCELERATION, PERFORMANCE. *TT (NHTSA ID #10004412, JANUARY 01 2003)
- TSB #020730039A -- FIRM TRANSMISSION SHIFTS, SHUDDER/CHUGGLE, TRANSMISSION WON'T DOWNSHIFT ON DECELERATION, SERVICE ENGINE SOON LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODE P0742 SET. *TT (NHTSA ID #10000773, DECEMBER 01 2002)
- TSB #3253 -- VEHICLE WILL NOT MOVE IN EITHER DIRECTION. TRANSMISSION MAY SHOW OVER FULL. P90 4T40E 4T45E NO MOVEMENT DRIVE OR REVERSE. CONVERTER MAY BE EMPTY OF FLUID. *TT (NHTSA ID #10017096, no date provided)
- TSB #3669 -- M86/M94 TRANSMISSION INFORMATION TO DISASSEMBLE THIRD FOURTH AND FIFTH GEAR. *AK (NHTSA ID #10019228, no date provided)
POWER TRAIN:AXLE ASSEMBLY
ELECTRICAL SYSTEM
- TSB #08089-B -- GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE (NHTSA ID #10027804, NOVEMBER 01 2008)
- TSB #04083 -- NO DIELECTRIC GREASE BEING APPLIED TO REAR LIGHT BULB SOCKET. *EH (NHTSA ID #10014001, NOVEMBER 01 2004)
- TSB #01592 -- 2003-2004 GENERATION 5 ONSTAR STEERING WHEEL CONTROL FUNCTION EXPLANATION. SIT BULLETIN 1416474. *TT (NHTSA ID #10005438, JANUARY 01 2004)
- TSB #01411 -- FALSE CODE B3785. SERVICE VME. *TT (NHTSA ID #10004215, NOVEMBER 18 2003)
- TSB #090903 -- THE BODY CONTROL MODULE (BCM) MAY SET A FALSE CODE OF B3785. GM VOICEMAIL LOG. *TT (NHTSA ID #10005059, SEPTEMBER 09 2003)
ELECTRICAL SYSTEM:BATTERY:CABLES
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
ELECTRICAL SYSTEM: SOFTWARE
EXTERIOR LIGHTING
EXTERIOR LIGHTING:HEADLIGHTS
EXTERIOR LIGHTING:TAIL LIGHTS
EXTERIOR LIGHTING:TURN SIGNAL
VISIBILITY
VISIBILITY:SUN ROOF ASSEMBLY
- TSB #030867009 -- SUNROOF WILL NOT OPEN OR CLOSE COMPLETELY DUE TO THE SUNROOF MOTOR. *TT (NHTSA ID #10005595, MARCH 01 2004)
- TSB #01598 -- SUNROOF SUPPLEMENTAL INFORMATION TO 03-08-67-009.*MR (NHTSA ID #10007178, JANUARY 01 2004)
- TSB #100703 -- JAMMED SUNROOF THAT WILL NOT OPEN OR A CLOSE COMPLETELY. GM VOICEMAIL LOG. *TT (NHTSA ID #10004981, OCTOBER 07 2003)
- TSB #030867004 -- PARTS AVAILABILITY FOR SUNROOF REPAIRS. *TT (NHTSA ID #10002878, JUNE 01 2003)
VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
- TSB #030864009A -- LEFT OUTSIDE BREAKAWAY MIRROR INOPERATIVE. *TT UPDATE. *TT (NHTSA ID #10004338, MARCH 01 2005)
- TSB #030864011A -- MIRROR VIBRATES AT HIGHWAY SPEEDS. *TT (NHTSA ID #10004339, SEPTEMBER 01 2003)
- TSB #022703 -- INOPERATIVE MANUAL OUTSIDE REARVIEW MIRROR(S). *TT *JB (NHTSA ID #10001851, FEBRUARY 27 2003)
- TSB #022503 -- OUTSIDE REARVIEW MIRROR ASSEMBLY APPEARING TO BE LOOSE OR A VIBRATION COMPLAINT. *TT *JB (NHTSA ID #10001845, FEBRUARY 25 2003)
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:BLOWER
VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:HEATER CORE
STRUCTURE
- TSB #510 -- RIGHT FRONT SPEAKER RATTLE. *SC (NHTSA ID #10016221, OCTOBER 01 2003)
- TSB #081903 -- SCREW MISSING FROM THE A-PILLAR CEILING STRIP FRONT DOOR AUXILIARY. *TT (NHTSA ID #10003822, AUGUST 19 2003)
- TSB #032403 -- INSTRUMENT CLUSTER PANEL LENS CRACKING OR GRAZING. *TT *JB (NHTSA ID #10001863, MARCH 24 2003)
STRUCTURE:BODY
- TSB #040842004 -- TAIL LAMP BRAKE INOPERATIVE. THIS SERVICE BULLETIN REPLACES 040842004. *EH (NHTSA ID #10012606, APRIL 01 2004)
- TSB #040842004 -- TAIL LAMP/BRAKE LAMP INOPERATIVE (REPLACE BULB AND SOCKET). *MJ *TT (NHTSA ID #10008682, MARCH 01 2004)
- TSB #030859003 -- RIGHT FRONT SPEAKER RATTLE. *TT (NHTSA ID #10004781, OCTOBER 01 2003)
- TSB #071603 -- RATTLE OR BUZZ FROM THE RIGHT FRONT SPEAKER. *TT (NHTSA ID #10003793, JULY 16 2003)
- TSB #030863002 -- CARPET WET ON DRIVER'S SIDE. *TT (NHTSA ID #10012570, JULY 01 2003)
- TSB #030859001 -- RATTLE NOISE FROM FRONT CENTER OF DASH AREA. *TT (NHTSA ID #10001119, FEBRUARY 01 2003)
- TSB #030849002 -- PLASTIC INSTRUMENT PANEL (I/P) CLUSTER LENS MAY CRAZE OR CRACK. *TT (NHTSA ID #10000940, JANUARY 01 2003)
- TSB #11072002 -- PAINT APPEARING NOT TO MATCH ON THE LEFT TO RIGHT SIDE OF THE FRONT FASCIA ASSEMBLY AT THE CENTERLINE. *TT (NHTSA ID #10008616, NOVEMBER 07 2002)
- TSB #09092002 -- FRONT LICENSE PLATE MOUNTING BRACKET LOCATION. *TT (NHTSA ID #10009434, SEPTEMBER 09 2002)
VEHICLE SPEED CONTROL
VEHICLE SPEED CONTROL:CABLES
VEHICLE SPEED CONTROL:CRUISE CONTROL
INTERIOR LIGHTING
EQUIPMENT
- TSB #050846006A -- INFORMATION ON UPGRADING CERTAIN ONSTAR GENERATION 5 ANALOG/DIGITAL-READY SYSTEMS TO ONSTAR GENERATION 6 DUAL-MODE (ANALOG/DIGITAL). *TT (NHTSA ID #10015018, SEPTEMBER 01 2005)
- TSB #3050A -- 02-05 ONSTAR EQUIPPED VEHICLES EMITTING BEEPING NOISE BEFORE CONNECTING TO ONSTAR. *TT (NHTSA ID #10009623, JANUARY 01 2004)
- TSB #3047 -- 99 THROUGH 05 YEAR VEHICLES, EQUIPPED WITH THREE-BUTTON ONSTAR SYSTEMS. *TT (NHTSA ID #10009607, JANUARY 01 2004)
- TSB #010846002C -- PROGRAMMING OF REPLACEMENT ONSTAR VEHICLE COMMUNICATION AND INTERFACE MODULES (VCIM). *TT (NHTSA ID #10002836, JUNE 01 2003)
- TSB #052903 -- CLARIFICATION OF SERVICE BULLETIN 02-08-44-012. CERTAIN STEPS IN THE SERVICE BULLETIN TO DISABLE OR ENABLE THE REMOTE KEYLESS ENTRY RADIO PERSONALIZATION FEATURE HAS BEEN DELETED IN THE TECH 2 SOFTWARE. CONCERN WILL BE UPDATED IN JULY REL (NHTSA ID #10003676, MAY 29 2003)
- TSB #10082002 -- THIS MESSAGE IS TO PROVIDE DEALERS WITH AN AWARENESS OF TWO NEW COMMANDS AVAILABLE VIA VOICE RECOGNITION IN THE ONSTAR GENERATION FIVE EQUIPPED VEHICLES. THE TWO COMMANDS ARE ONSTAR AND EMERGENCY. *TT (NHTSA ID #10013128, OCTOBER 08 2002)
- TSB #3044 -- GENERATION 5 ONSTAR STEERING WHEEL CONTROL FUNCTION. *TT (NHTSA ID #10010363, no date provided)
EQUIPMENT:ELECTRICAL
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
- TSB #040846004 -- ONSTAR SYSTEM INOPERATIVE ONSTAR SYSTEM STATUS LIGHT IS RED RADIO LOCKED IN PHONE MODE OR DTC B1000. *EH (NHTSA ID #10013440, JANUARY 01 2005)
- TSB #01759 -- XM RAPID ACTIVATION UTILIZATION. *MR (NHTSA ID #10006302, JANUARY 01 2004)
- TSB #01662 -- XM ERROR ON A RADIO DISPLAY. *TT (NHTSA ID #10007248, JANUARY 01 2004)
- TSB #01390 -- XM RADIO MUST BE TUNED TO CHANNEL 1 THROUGH 66 DURING ACTIVATION ATTEMPT. 2004 CHEVROLET CANYON, GMC DENALI, GMC COLORADO ALSO INCLUDED. *TT (NHTSA ID #10004195, NOVEMBER 18 2003)
- TSB #09262002 -- CONCERNS THAT INVOLVE THE DISPLAY OF NO SIGNAL ON THE RADIO HEAD IN AN AREA THAT IS KNOWN TO HAVE GOOD XM RECEPTION. *MJ (NHTSA ID #10008629, SEPTEMBER 26 2002)
EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
EQUIPMENT:ELECTRICAL:AIR CONDITIONER
- TSB #611 -- BINDING MODE VALVE-HVAC. *SC (NHTSA ID #10016265, NOVEMBER 01 2004)
- TSB #030138005A -- HARD TO CHANGE HVAC MODE OR TEMPERATURE SETTINGS. *TT UPDATE. *AR (NHTSA ID #10002377, AUGUST 01 2004)
- TSB #030138012 -- UNDERHOOD RATTLE OR GROWL NOISE WITH AIR CONDITIONER ON. *TT (NHTSA ID #10004363, MARCH 01 2004)
- TSB #01682 -- HVAC MODE CONTROL HARD TO CHANGE SETTINGS. *TT (NHTSA ID #10007242, JANUARY 01 2004)
- TSB #01685 -- HVAC MODE CONTROL HARD TO CHANGE SETTINGS. *TT (NHTSA ID #10006374, JANUARY 01 2004)
- TSB #01289 -- CHIRP OR SQUEAK ON ACCELERATION FROM STOP. SERVICE VME. *TT (NHTSA ID #10004098, NOVEMBER 18 2003)
- TSB #062703 -- FOLLOW UP TO A SERVICE VME SENT OUT ON MAY 29TH REGARDING THE AIR CONDITIONER SIX CVC COMPRESSORS AND POSSIBLE NOISES ASSOCIATED WITH THEM. *TT (NHTSA ID #10003724, JUNE 27 2003)
- TSB #061903 -- TROUBLESHOOTING/REPAIRING AIR CONDITIONING CHIRP OR SQUEAK DURING INITIAL ACCELERATION. *TT (NHTSA ID #10003707, JUNE 19 2003)
- TSB #060303 -- CONCERNS WITH REPLACEMENT OF THE 6CVC AIR CONDITIONER COMPRESSOR FOR A NOISE COMPLAINT. *TT (NHTSA ID #10003688, JUNE 03 2003)
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- TSB #08-089B -- GMC: SPECIAL COVERAGE ADJUSTMENT-ANALOG ONSTAR DEACTIVATION. CSC LETTER WAS RECEIVED. *PE (NHTSA ID #10026805, SEPTEMBER 01 2008)
- TSB #07082004 -- GM SERVICE TECHNICAL COLLEGE. *EH (NHTSA ID #10013184, JULY 08 2004)
UNKNOWN OR OTHER
- TSB #000089008E -- SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND. THIS BULLETIN PROVIDES INFORMATION REGARDING RECREATIONAL (DINGHY) TOWING FOR CERTAIN VEHICLES INCLUDING 1988-2004 CHEVROLET AND GMC LI (NHTSA ID #10005527, OCTOBER 01 2005)
- TSB #020846010E -- PROGRAMMING ONSTAR MODULE FOR CANADIAN FRENCH VOICE RECOGNITION. *TT UPDATE. *TT UPDATED *EH (NHTSA ID #10002998, NOVEMBER 01 2004)
- TSB #04059 -- EMISSION LABEL - REPLACE - VEHICLE EMISSION CONTROL LABELS THAT ARE WRINKLED, DAMAGED, OR COMPLETELY MISSING. *NM (NHTSA ID #10010178, SEPTEMBER 01 2004)
- TSB #020730022B -- SERVICE ENGINE SOON LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0716 AND / OR P0717, P0730, P0753, P0758, P1860, P1887 OR OTHER MISCELLANEOUS TRANSMISSION TROUBLE CODES SET. *TT (NHTSA ID #10004755, OCTOBER 01 2003)
- TSB #000089008B -- SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND. THIS BULLETIN PROVIDES INFORMATION REGARDING RECREATIONAL (DINGHY) TOWING FOR CERTAIN VEHICLES INCLUDING 1988-2004 CHEVROLET AND GMC LI (NHTSA ID #10004278, SEPTEMBER 01 2003)
- TSB #020844012A -- ENABLE OR DISABLE REMOTE KEYLESS ENTRY (RKE) RADIO PERSONALIZATION FEATURE. *TT (NHTSA ID #10002841, JUNE 01 2003)
- TSB #022803 -- CONCERN OF THE HEATER NOT BLOWING COLD AIR, THE MODE SETTING NOT OPERATING OR AIR SEEMINGLY ONLY TO COME OUT OF CERTAIN VENTS. *TT *JB (NHTSA ID #10001853, FEBRUARY 28 2003)
- TSB #01444 -- XM DEALER ASSISTANCE LINE INFORMATION. *TT (NHTSA ID #10004411, JANUARY 01 2003)
- TSB #020730022A -- SERVICE ENGINE SOON LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0716 AND / OR P0717, P0730, P0753, P0758, P1860, P1887 OR OTHER MISCELLANEOUS TRANSMISSION TROUBLE CODES SET. *TT (NHTSA ID #634931, SEPTEMBER 01 2002)
- TSB #4014 -- PARTS UPDATE - TIMING CHAIN TENSIONER DESIGN CHANGE. *KB (NHTSA ID #10021074, no date provided)