Notes: Engine cradle rot is a serious problem in the 2004-05 Chrysler Pacifica. Chrysler admits they didn't apply enough coating to the vehicle's sub-frame during assembly, but only offered to cover a very small portion of the vehicles they messed up.

So what happens when your engine cradle rots? Well, the engine could fall out for starters. It could also cause problems with the suspension and other components but did I mention THE ENGINE CAN FALL OUT? The worst part is you might not know because there's no way to see the problem without getting under the car.

If you have a 2004-05 Pacifica, make sure to have your mechanic inspect your sub-frame for rust and corrosion.


really awful
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
0 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2005 Chrysler Pacifica steering problems

steering problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2005 Chrysler Pacifica:

Unsubscribe any time. We don't sell/share your email.

2005 Chrysler Pacifica Owner Comments

problem #1

Sep 052007


  • Automatic transmission
  • miles


Today I took my 2005 Chrysler Pacifica into the shop for new tires, I was told they could not do an alignment because the tie rods looked bad and to take it to the dealer, I did. I then found out from my local dealer that unfortunately that is all they see is Chrysler car has less than 45K miles and I have been told that the entire front end suspension is worthless and right now I have bad gear boxes, a broken engine mount, and can count on having front axel problems as well. The dealer also had a 2004 brought in today and that car and mine were raised up and the repair men showed me and everyone else around the identical problems on both cars.

- Lebanon, OH, USA

Not what you are looking for?