really awful
Crashes / Fires:
0 / 0
Injuries / Deaths:
4 / 0
Average Mileage:
36,830 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2005 Dodge Grand Caravan exhaust system problems

exhaust system problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2005 Dodge Grand Caravan:

Unsubscribe any time. We don't sell/share your email.

2005 Dodge Grand Caravan Owner Comments

problem #3

Jan 102010

Grand Caravan 6-cyl

  • 105,490 miles


Check engine light on. Needs catalytic converter/erg valve.

- Aurora, IL, USA

problem #2

Aug 242005

Grand Caravan 6-cyl

  • Automatic transmission
  • 5,000 miles
I was burned on the forearm while reaching under my van for an item that had fallen on the ground. The exhaust pipe runs very close to the side of the vehicle and is not protected by any sort of heat shield.

- Norton, VA, USA

problem #1

Jul 302005

Grand Caravan 6-cyl

  • Automatic transmission
  • miles
My three young children were burnt on the exhaust pipe of our 2005 Dodge Grand Caravan w/sto & go seats. While reaching their leg under the van, to retrieve a quarter they dropped, they each received 1st & 2nd degree burns on their legs. The coin was only a few inches under the van; you could see it by standing on the passenger side of vehicle. When standing along the passenger side of vehicle you can plainly see the exhaust pipe just several inches under the sliding side door.

- N. Cape May, NJ, USA

Not what you are looking for?