really awful
Crashes / Fires:
1 / 0
Injuries / Deaths:
1 / 0
Average Mileage:
77,836 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2006 Ford Fusion seat belts / air bags problems

seat belts / air bags problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2006 Ford Fusion:

Unsubscribe any time. We don't sell/share your email.

2006 Ford Fusion Owner Comments

problem #5

Jul 312014


  • 100,000 miles


The contact owns a 2006 Ford Fusion. The contact stated that while driving at various speeds, the seatbelt light illuminated after securing the seatbelt. In addition, the contact stated that several attempts were made to unlatch the seatbelt but failed. The contact had to cut the drivers seatbelt to release from the seat. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 100,000.

- Mattapan, MA, USA

problem #4

Nov 172013

Fusion 4-cyl

  • 200,000 miles
The seat belts came all the way out and stayed out can't put them back.

- Winn, ME, USA

problem #3

Jun 012011


  • 55,000 miles
Contact owns a 2006 Ford Fusion. The contact stated that the front passenger and both rear interior door handles became fractured when engaged. In addition, the contact was driving 55 mph when the vehicle failed to respond to acceleration attempts over 55 mph. The seat belt mechanism also failed and the contact was unable to secure the seat belt. The contact took the vehicle to the dealer where the transmission was replaced. The interior door handles and the seat belt were not repaired. The manufacturer was not made aware of the failure. The failure mileage was 55,000.

- Hickory , MS, USA

problem #2

Jun 182011


  • 29,182 miles
2006 Ford Fusion passenger seat belt locked and would not release. The fasten seat belt warning kept alarming but the seat belt was buckled and locked. My husband put pressure by pulling on it and it released on its own. It work for 2 days then locked again and we can not get it open.

- Sumner, WA, USA

problem #1

Feb 032008

Fusion 4-cyl

  • Automatic transmission
  • 4,997 miles
The contact owns a 2006 Ford Fusion. While driving at an unknown speed, the contact noticed that the seat belt warning light would sporadically illuminate on the instrument control panel for approximately five to ten minutes. One month later, the seat belt warning light dimmed while all the passengers were properly restrained in their seat belts. When the front passenger attempted to exit the vehicle, the seat belt locked and prevented the passenger from exiting. The contact drove to a local police station and an officer removed the seat belt panel to free the passenger from the seat. The dealer informed the contact that he would have to repair the seat belt system at his own expense because it was not covered by the factory warranty. The current and failure mileages were 4,997.

- Palm Bay, FL, USA

Not what you are looking for?