This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
In May of 2022 at approximatley 46,000 miles a family members 2019 Ford Ranger had the A/C unit on, but VERY hot air was blowing on drivers side. After inspection and Pin Point Test the Ford Dealership determined a manufactures Drivers Side Temp Blend Door was malfunctioning and was replaced at full charge of both parts and labor to the owner. A few days later after the manufactures malfunctioning part was replaced, the VERY same issue developed and caused a family member to pass out due to over 100 degress inside the vehicle. After OTHER inspection by the Ford Dealership it was determined the manufactures Blend Door Acuator, was malfunctioning and was replaced at full charge of both parts and labor to the owner. ON THE WEEK OF APRIL 10, 2023, THIS VIN'S FORD RANGER HAS EXPERIENCED THE EXACT SAME ISSUES AND HAS BEEN DETERMINED THE EXACT SAME MANUFACTURES PARTS ARE MALFUNCTIONING. THIS MUST BE DETERMINED AS A RECALL!
With high outside temperatures A/C unit was on, but only the heating system was working. Air Conditioning system was not functuning and heating system would not go off. With windows down, inside tempearture was over 100 degrees and passing out due to heat was happening. Ford Dealer inspected the problem and said it was a manufacture malfunction. After repairing, the same issue developed again five days later. Ford dealer said it was another malfunctioning manufacture part.
The contact owns a 2019 Ford Ranger. The contact stated while driving 40 MPH with the heating system activated, the contact heard an abnormal sound coming from the vents. The contact stated that both cold air and heat was coming through the vents. The vehicle was not diagnosed or repaired. The manufacturer was contacted and stated that the vehicle was out of warranty. The failure mileage was 39,081.
The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal cracking sound, and then the heating system became inoperable. The contact stated that he was freezing while driving in 20-degree weather. The contact was concerned that if he became stranded in traffic during a snowstorm, he would freeze. The vehicle was taken to the dealer, where it was diagnosed that the heating duct was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and agreed to cover a portion of cost of the repair. The failure mileage was approximately 46,000.
The actuator motor is not working. This is a common complaint of the 2019 Ford Ranger and is noted in Ford's SSM 49264. Certainly a service bulletin identifying a need to replace the entire climate control housing assembly is worthy of a recall. This truck has 23, 000 miles on it and is just out of warranty.
A D V E R T I S E M E N T S
- Van Wert, IA, USA