[ switch models ] 1995 Chevrolet 1500 Pickup 1995 Chevrolet Beretta 1995 Chevrolet Blazer 1995 Chevrolet Camaro 1995 Chevrolet Caprice 1995 Chevrolet Corsica 1995 Chevrolet Impala 1995 Chevrolet Lumina 1995 Chevrolet Monte Carlo 1995 Chevrolet S-10 Pickup 1995 Chevrolet Silverado 1995 Chevrolet Suburban 1995 Chevrolet Tahoe 1995 Chevrolet Tracker [ switch years ] 2005 Chevrolet Cavalier 2004 Chevrolet Cavalier 2003 Chevrolet Cavalier 2002 Chevrolet Cavalier 2001 Chevrolet Cavalier 2000 Chevrolet Cavalier 1999 Chevrolet Cavalier 1998 Chevrolet Cavalier 1997 Chevrolet Cavalier 1996 Chevrolet Cavalier 1994 Chevrolet Cavalier 1993 Chevrolet Cavalier 1992 Chevrolet Cavalier 1991 Chevrolet Cavalier 1990 Chevrolet Cavalier 1989 Chevrolet Cavalier 1988 Chevrolet Cavalier 1987 Chevrolet Cavalier 1986 Chevrolet Cavalier 1984 Chevrolet Cavalier

1995 Chevrolet Cavalier

1995 Chevrolet Cavalier TSBs (Technical Service Bulletins)

There are also 6 Chevrolet recalls » 1 defect investigations » 75 TSBs » for the Chevrolet Cavalier.

Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB title & date, & either contact your local dealer or click on the links below.

ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use to track each bulletin -- yes, it's a very screwed up situation that's almost completely unhelpful to you as the consumer. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.

STEERING

• TSB #150900 -- THIS MESSAGE CONCERNS VEHICLES EXHIBITING A CLUNK NOISE COMING FROM THE FRONT OF THE VEHICLE. CUSTOMERS MAY STATE THAT A CLUNK NOISE IS HEARD WHEN TURNING THE STEERING WHEEL. *TT (NHTSA ID #619039, SEPTEMBER 15 2000)

STEERING:GEAR BOX (OTHER THAN RACK AND PINION)

• TSB #533301 -- UNKNOWN (NHTSA ID #4031300, MARCH 01 1995)
• TSB #533301 -- CLUNK NOISES FROM FRONT OF VEHICLE WHEN RIDING OVER LARGE BUMPS. *TW (NHTSA ID #39815, MARCH 01 1995)

SUSPENSION:FRONT

• TSB #01967 -- FRONT SUSPENSION STEER NOISE SMOOTH ROAD TURNS. *MR (NHTSA ID #10006895, JANUARY 01 2004)
• TSB #GM533202 -- KNOCKING NOISE HEARD AT LOW SPEEDS OVER ROUGH ROADS. *TW (NHTSA ID #41084, APRIL 01 1995)

SUSPENSION:REAR:SHOCK ABSORBER

• TSB #733403 -- REAR SHOCK NOISE IN TRUNK AREA - SOUNDS LIKE LOOSE LUMBER. *TW (NHTSA ID #52341, APRIL 01 1997)

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

• TSB #000524001 -- INFORMATION REGARDING SNOW INTRUSION INTO REAR DRUM BRAKE ASSEMBLIES. **MR (NHTSA ID #613590, APRIL 01 2000)
• TSB #735018 -- COMMENTS THAT THE REAR BRAKES MAY DRAG/HEAT UP OR REAR OF CAR IS SQUATTING DUE TO AGGRESSIVE REAR BRAKE. *YC (NHTSA ID #600221, JANUARY 01 1998)

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER

• TSB #435006A -- UNKNOWN (NHTSA ID #43021, MAY 01 1995)

SERVICE BRAKES, HYDRAULIC:ANTILOCK

• TSB #9709015015A -- COMPLAINTS THAT THE ABS INDICATOR LAMP IS "ON". *YC (NHTSA ID #54329, SEPTEMBER 01 1997)
• TSB #970801735026 -- COMMENT THAT THE ABS LIGHT IS ON WITH DIAGNOSTIC TROUBLE CODES (DTC'S) 46 AND 86 SET AS CURRENT OR HISTORY. *YC (NHTSA ID #54419, AUGUST 01 1997)
• TSB #535010 -- UNKNOWN (NHTSA ID #43030, MAY 01 1995)

SERVICE BRAKES, AIR

• TSB #4615 -- ABS PUMP RUNNING WHEN NOT NEEDED. *NJ (NHTSA ID #10023171, no date provided)

SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR

• TSB #00966 -- ANTI-LOCK BRAKING SYSTEM (ABS) FRONT WHEEL SPEED CODES - JUMPER HARNESS. *TT (NHTSA ID #10007816, JANUARY 01 2004)
• TSB #00966B -- ABS FRONT WHEEL SPEED CODES - JUMPER HARNESS. *TT (NHTSA ID #10007293, JANUARY 01 2004)

ENGINE AND ENGINE COOLING

• TSB #9702019774T -- VARIOUS INFORMATION REGARDING OVERNIGHT COLD SOAK CONDITIONS. *YC (NHTSA ID #52933, FEBRUARY 01 1997)

ENGINE AND ENGINE COOLING:ENGINE

• TSB #98054A -- SOME VEHICLES MAY DEVELOP A FAILURE OF THE CYLINDER HEAD GASKET LEADING TO EXTERNAL COOLANT LEAKS. *TT (NHTSA ID #607607, AUGUST 01 1999)
• TSB #98054 -- GENERAL MOTORS HAS DETERMINED THAT SOME VEHICLES EQUIPPED WITH 2.2 LITER ENGINES MAY DEVELOP A FAILURE OF THE CYLINDER HEAD GASKET LEADING TO EXTERNAL COOLANT LEAKS FROM THE CYLINDER HEAD GASKET TO ENGINE BLOCK JOINT. *TT (NHTSA ID #615097, OCTOBER 08 1998)
• TSB #98054 -- SOME VEHICLES MAY DEVELOP A FAILURE OF THE CYLINDER HEAD GASKET LEADING TO EXTERNAL COOLANT LEAKS FROM THE CYLINDER HEAD GASKET TO ENGINE BLOCK JOINT. *YC (NHTSA ID #603613, OCTOBER 01 1998)
• TSB #98876121A -- VEHICLES MAY EXHIBIT A CLATTERING NOISE AT IDLE SPEED ORIGINATING FROM THE TIMING CHAIN AND FRONT COVER AREA. *YC (NHTSA ID #601058, APRIL 01 1998)
• TSB #776001 -- INFORMATION CONCERNING ENGINE KNOCK/RATTLE OR TAP NOISE BEFORE ENGINE HAS REACHED OPERATING TEMPERATURE OR UNDER LIGHT LOAD CONDITIONS AT OPERATING TEMPERATURE (REPLACE PISTON AND/OR ROD ASSEMBLIES). AK (NHTSA ID #52935, JULY 01 1997)
• TSB #970501776109 -- EXHIBITING DIAGNOSTIC TROUBLE CODES P0300, P0301, P0302, P0303, AND P0304 INDICATING ENGINE MISFIRE CONDITIONS. *YC (NHTSA ID #53011, MAY 01 1997)
• TSB #776109 -- ENGINE STALL AT COLD START, ROUGH IDLE, OIL FILTER EXPANSION, HIGH OIL PRESSURE AND ENGINE MISFIRE DTC'S (REPLACE OIL PUMP WITH IMPROVED PRESS RELIEF VALVE BORE). *TW (NHTSA ID #52596, APRIL 01 1997)
• TSB #776001 -- KNOCK, RATTLE OR TAP NOISE FROM THE ENGINE BEFORE THE ENGINE HAS REACHED OPERATING TEMPERATURE OR UNDER LIGHT LOAD CONDITIONS AT OPERATING TEMPERATURE KNOCK, RATTLE OR TAP NOISE FROM THE ENGINE BEFORE THE ENGINE HAS REACHED OPERATING (NHTSA ID #51302, MARCH 01 1997)
• TSB #MSG95C53 -- GENERAL MOTORS HAS DECIDED THAT CERTAIN 1995 CAVALIER, CORSICA/BERETTA, S TRUCKS EQUIPPED WITH 2.2L (LN2) 4 CYCLINDER ENGINES MAY HAVE PUSH ROD THAT MAY BE IN IN HARD CONTACT WITH THE ANTI-ROTATION BRACKET SECURING THE ROLLER LIFTERS. IF (NHTSA ID #45832, AUGUST 01 1995)

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

• TSB #99088A -- VOLUNTARY EMISSION CAMPAIGN INVOLVING VEHICLES EXHIBITING SYMPTONS RESULTING IN THE ILLUMINATION OF THE CHECK ENGINE LIGHT OR THE ENGINE RUNNING ROUGH. **MR (NHTSA ID #613594, APRIL 27 2000)
• TSB #99088REV -- INFORMATION REGARDING ADDITIONAL CORRECTIONS FROM PRIVIOUS CAMPAIGN 99088, CONDITIONS THAT CONCERN ROUGH RUNNING ENGINE AND CHECK ENGINE LIGHT ILLUMINATION. MJS (NHTSA ID #612655, APRIL 07 2000)
• TSB #99088A -- VEHICLES EXHIBIT SYMPTOMS RESULTING IN THE ILLUMINATION OF THE CHECK ENGINE LIGHT OR THE ENGINE RUNNING ROUGH (INSPECTION, CLEAN/REPLACE AND SEAL PCM, AND INSTALL PROTECTIVE PCM SHIELD ASSEMBLY). *MJS (NHTSA ID #612668, APRIL 01 2000)
• TSB #576112 -- UNKNOWN (NHTSA ID #43042, MAY 01 1995)

ENGINE AND ENGINE COOLING:COOLING SYSTEM

• TSB #98054 -- SUBJECT REGARDING ADDTIONAL INFORMATION FOR SPECIAL POLICY 98054 - COOLANT LOSS, VISIBLE COOLANT LEAKAGE, OR COOLANT ODOR. **MR (NHTSA ID #613596, MAY 02 2000)

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

• TSB #636604C -- COMMENTS THAT A METALLIC NOISE OR COLD RAP HEARD ON COLD EXHAUST SYSTEM. *TT (NHTSA ID #603835, SEPTEMBER 01 1998)
• TSB #98636604B -- COMMENTS THAT A METALLIC NOISE ON COLD EXHAUST SYSTEMS. *TT (NHTSA ID #601911, JUNE 01 1998)
• TSB #98636604A -- SOME OWNERS MAY COMMENT THAT A METALLIC NOISE OR (NHTSA ID #601051, APRIL 01 1998)
• TSB #MSG01155 -- UNKNOWN (NHTSA ID #43014, MAY 01 1995)

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY

• TSB #531510 -- FUEL FILLER DOOR LATCH RETAINER SNAP-IN LEGS LOOSE/NOT SECURED (INSTALL RETAINING CLIP). *SD (NHTSA ID #45816, AUGUST 01 1995)

POWER TRAIN

• TSB #030730021 -- NEUTRAL FLARE AND/OR RPM FLARE WHILE IN DRIVE, NO 1-2 UPSHIFT, SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODES (DTCS) P1810, DIAGNOSTIC TROUBLE CODE P1815 SET. *TT (NHTSA ID #10002392, MAY 01 2003)
• TSB #020730050 -- ENGINEERING CHANGES TO THE VALVE BODY, PRESSURE REGULATOR VALVE, 2-3 ACCUMULATOR VALVE AND BORE FOR 2002-2003 MODEL YEAR 4T45E TRANSAXLES AND SUBSEQUENT OVERHAUL PROCEDURES WHICH AFFECT 1995-2001 MODEL YEAR TRANSAXLES. *TT (NHTSA ID #10000759, DECEMBER 01 2002)

POWER TRAIN:CLUTCH ASSEMBLY

• TSB #677160 -- DELAY ENGAGEMENT INTO DRIVE AFTER COLD SOAK (REPLACE WITH REVISED FORWARD CLUTCH HOUSING ASSEMBLY COMPLETE). *TW (NHTSA ID #52592, FEBRUARY 01 1997)

POWER TRAIN:AUTOMATIC TRANSMISSION

• TSB #030730021A -- NEUTRAL FLARE AND/OR RPM FLARE WHILE IN DRIVE, NO 1-2 UPSHIFT, SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODES (DTCS) P1810, DIAGNOSTIC TROUBLE CODE P1815 SET. *TT (NHTSA ID #10005579, NOVEMBER 01 2003)

POWER TRAIN:DRIVELINE

• TSB #9573T4001 -- GRINDING AND/OR GROWLING NOISE IN PARK ON INCLINE.*SD (NHTSA ID #45881, AUGUST 01 1995)

POWER TRAIN:DRIVELINE:DRIVESHAFT

• TSB #637205 -- LEAK IN THE AXLE SEAL AREA (SHORTEN VENT HOSE). *TW (NHTSA ID #51268, JANUARY 01 1997)

POWER TRAIN:AXLE ASSEMBLY

• TSB #990730030A -- OWNERS OF SOME VEHICLES EQUIPPED WITH HYDRA-MATIC 3T40, 4T60, 4T60-E OR 4T65-E TRANSAXLES MAY COMMENT ON A GRINDING AND / OR GROWLING NOISE THAT IS NOTICEABLE WHEN STANDING IN PARK ON A HILL OR SLOPE WITH THE ENGINE RUNNING AND THE PARKING (NHTSA ID #619370, APRIL 01 2001)
• TSB #990730030 -- SOME VEHICLES EQUIPPED WITH HYDRA-MATIC 3T40, 4T60 OR 4T60-E TRANSXALES MAY COMMENT ON A GRINDING AND / OR GROWLING NOISE THAT IS NOTICEABLE WHEN IN PARK ON INCLINE. *TT (NHTSA ID #6089996, DECEMBER 01 1999)

ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH

• TSB #010849009 -- SUBJECT REGARDING REVISED INSTRUMENT PANEL CLUSTER (IPC) REPLACEMENT. NLM (NHTSA ID #622716, JUNE 01 2001)
• TSB #536403 -- UNKNOWN (NHTSA ID #43010, MAY 01 1995)

EXTERIOR LIGHTING:FOG LIGHTS

• TSB #291001 -- CUSTOMER CONCERN OF PREMATURE FOG LAMP FAILURE. *TT (NHTSA ID #628053, OCTOBER 29 2001)

EXTERIOR LIGHTING:BRAKE LIGHTS

• TSB #051603 -- PROPER INSTALLATION INSTRUCTIONS FOR THE HIGH MOUNTED STOP LAMP THAT IS INTEGRATED IN THE REAR SPOILER. SOME DEALERS HAVE COMPLAINED ABOUT THE LAMP NOT FITTING PROPERLY OR THAT PARTS ARE BEING DAMAGED DURING INSTALLATION. *TT (NHTSA ID #10003650, MAY 16 2003)

EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS

• TSB #96075 -- RECALL 96V-250 - GENERAL MOTORS HAS DECIDED THAT CERTAIN 1995 AND 1996 J AND N MODEL VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) 108, LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT - THESE VEHICLES MAY EXHI (NHTSA ID #52087, JANUARY 01 1997)

VISIBILITY:REARVIEW MIRRORS/DEVICES

• TSB #990864015 -- CONCERNS WITH THE LEFT HAND MANUAL MIRROR NOT ADJUSTING WHEN THE ADJUSTMENT LEVER IS MOVED. *TT (NHTSA ID #608373, SEPTEMBER 01 1999)

VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

• TSB #030864009A -- LEFT OUTSIDE BREAKAWAY MIRROR INOPERATIVE. *TT UPDATE. *TT (NHTSA ID #10004338, MARCH 01 2005)
• TSB #030864011A -- MIRROR VIBRATES AT HIGHWAY SPEEDS. *TT (NHTSA ID #10004339, SEPTEMBER 01 2003)
• TSB #731502 -- LEFT HAND MIRROR DOES NOT ADJUST WHEN ADJUSTMENT LEVER IS MOVED (ADJUST LEVER TO ALIGN WITH LEVER SLIDE). *TW (NHTSA ID #52598, MARCH 01 1997)

SEAT BELTS

• TSB #990940001 -- CUSTOMERS MAY COMPLAIN THAT THE FRONT SEAT SHOULDER BELT PLASTIC COVER WILL NOT STAY SNAPPED IN PLACE ON COUPE MODELS ONLY. *TT (NHTSA ID #606701, MAY 01 1999)

STRUCTURE:FRAME AND MEMBERS

• TSB #MSG95C48 -- GENERAL MOTORS HAS DETERMINED THAT CERTAIN 1995 CHEVROLET CAVALIER MODELS MAY NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) 208, 'OCCUPANT CRASH PROTECTION'. THESE VEHICLES MAY HAVE BEEN BUILT WITH SOME WELDS OMITTED FROM TH (NHTSA ID #45829, JUNE 01 1995)

STRUCTURE:BODY

• TSB #831522 -- REAR COMPARTMENT (TRUNK) LID LATCH DIFFICULT TO UNLOCK / OPEN. *YC (NHTSA ID #603090, DECEMBER 01 1998)
• TSB #98731069 -- A RATTLE COMING FROM THE DOOR(S) WHEN THE DOOR WINDOW GLASS IS LOWERED. *YC (NHTSA ID #602773, SEPTEMBER 01 1998)
• TSB #971101731063 -- COMMENTS OF A RATTLE NOISE UNDER THE HOOD OR INSTRUMENT PANEL AREA. *YC (NHTSA ID #54196, NOVEMBER 01 1997)
• TSB #971101731060 -- VARIOUS AREAS OF THE VEHICLE CONVERTIBLE TOP COVER SHOWS WEAR OR PERMANENT DAMAGE. *YC (NHTSA ID #54190, NOVEMBER 01 1997)
• TSB #971001731508 -- COMMENTS THAT THE DECK LID WILL NOT OPEN WHEN THE INTERIOR REMOTE RELEASE HANDLE IS PULLED. *YC (NHTSA ID #54479, OCTOBER 01 1997)

STRUCTURE:BODY:DOOR

• TSB #990864026 -- ON SOME CONVERTIBLE MODELS, THE DOOR RATTLES WHEN CLOSING. *TT (NHTSA ID #6088948, OCTOBER 01 1999)

STRUCTURE:BODY:ROOF AND PILLARS

• TSB #990857019 -- CONDITIONS WITH WATER LEAK AT FRONT HEADER. *TT (NHTSA ID #606062, MAY 01 1999)
• TSB #731060B -- CONVERTIBLE TOP COVER SHOWS WEAR OR PERMANENT DAMAGE IN VARIOUS AREAS. YD (NHTSA ID #609730, JULY 01 1998)
• TSB #98731060A -- COMMENTS ON THE CONVERTIBLE TOP COVER SHOWING WEAR OR PERMANENT DAMAGE. *YC (NHTSA ID #600271, FEBRUARY 01 1998)
• TSB #631040A -- SCUFFED INTERIOR QUARTER TRIM PANELS ON CONVERTIBLE TOPS (ADD LOOP FASTENER TAPE/RE-STAKE REINFORCEMENT/ADD LOOP FASTENER). *TW (NHTSA ID #52351, APRIL 01 1997)

SEATS

• TSB #990850007 -- SOME CUSTOMERS MAY COMMENT THAT THERE IS A BULGE IN THE MATERIAL ON THE TOP BACKSIDE OF EITHER FRONT BUCKET SEAT. *TT (NHTSA ID #606544, APRIL 01 1999)
• TSB #98731616A -- SEAT BELT LATCH SLIDES TO SEAT BELT ANCHOR SLEEVE. *YC (NHTSA ID #601114, APRIL 01 1998)
• TSB #971101731616 -- COMMENTS THAT THE SEAT BELT LATCH SLIDES TO THE SEAT BELT ANCHOR SLEEVE. *YC (NHTSA ID #54064, NOVEMBER 01 1997)

SEATS:FRONT ASSEMBLY:RECLINER

• TSB #731601 -- RATTLE/SQUEAK FROM PASSENGER (RIGHT) SIDE OF REAR FOLDING SEATBACK AREA (REPOSITION RIGHT HAND FRAME ARM). *TW (NHTSA ID #51283, FEBRUARY 01 1997)

INTERIOR LIGHTING

• TSB #638139 -- INTERIOR DOME LIGHT STAYS ON ALL THE TIME (REROUTE WIRE HARNESS). *TW (NHTSA ID #51239, JANUARY 01 1997)
• TSB #538105 -- ERRATIC INTERIOR LIGHTING CONDITIONS. *TW (NHTSA ID #39274, FEBRUARY 01 1995)

UNKNOWN OR OTHER

• TSB #000089008E -- SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND. THIS BULLETIN PROVIDES INFORMATION REGARDING RECREATIONAL (DINGHY) TOWING FOR CERTAIN VEHICLES INCLUDING 1988-2004 CHEVROLET AND GMC LI (NHTSA ID #10005527, OCTOBER 01 2005)
• TSB #000089008B -- SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND. THIS BULLETIN PROVIDES INFORMATION REGARDING RECREATIONAL (DINGHY) TOWING FOR CERTAIN VEHICLES INCLUDING 1988-2004 CHEVROLET AND GMC LI (NHTSA ID #10004278, SEPTEMBER 01 2003)
• TSB #000849003 -- EXPERIENCING A RATTLE / SQUEAK IN RIGHT SIDE OF INSTRUMENT PANEL OR RIGHT FRONT DOOR TRIM PANEL SCRATCHED OR RIGHT SIDE END OF INSTRUMENT PANEL CONTACTING DOOR TRIM PANEL. *TT (NHTSA ID #614376, JUNE 01 2000)
• TSB #99088 -- GENERAL MOTORS HAS DECIDED TO CONDUCT A VOLUNTARY EMISSION CAMPAIGN INVOLVING VEHICLES EXHIBITING SYMPTOMS RESULTING IN THE ILLUMINATION OF THE CHECK ENGINE LIGHT OR THE ENGINE RUNNING ROUGH. *TT (NHTSA ID #611973, MARCH 01 2000)
• TSB #98836539A -- SERVICE ENGINE NOW LIGHT ON OR A NO-START CONDITION. *YC (NHTSA ID #601122, APRIL 01 1998)