[ switch models ] 2004 GMC 2500 Sierra 2004 GMC 3500 Sierra 2004 GMC C4500 2004 GMC Envoy 2004 GMC Savana 2004 GMC Sierra 1500 2004 GMC Yukon [ switch years ] 2007 GMC Canyon 2005 GMC Canyon

2004 GMC Canyon

Technical Service Bulletins

There are also 1 GMC recalls » 2 defect investigations » 186 TSBs » for the GMC Canyon.

Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB number & contact your local dealer.

ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.

STEERING:COLUMN

• TSB #01852A -- SQUEAK NOISE FROM LOWER STEERING COLUMN WHEN TURNING. *NM (NHTSA ID #10007215, JANUARY 01 2004)
• TSB #01852 -- SQUEAK FROM LOWER STEERING COLUMN WHEN TURNING STEERING WHEEL. *MR (NHTSA ID #10006597, JANUARY 01 2004)

SUSPENSION

• TSB #040307004A -- PREMATURE FRONT TIRE WEAR. *TT (NHTSA ID #10014955, JULY 01 2005)
• TSB #050307003 -- REVISED WHEEL ALIGNMENT SPECIFICATIONS. *TT (NHTSA ID #10014977, MARCH 01 2005)
• TSB #03312004 -- CORRECTION TO A DEALER VME SENT OUT ON MARCH 23, 2004 WITH REGARD TO CUSTOMERS COMMENTS THAT THEY FEEL THEIR SUSPENSION RIDE IS TOO STIFF, TOO SOFT, TOO SHAKY OR INCONSISTENT. *TT (NHTSA ID #10009194, MARCH 31 2004)
• TSB #3107B -- VIBRATION AT HIGHWAY SPEEDS. *SC (NHTSA ID #10010028, JANUARY 01 2004)
• TSB #01963 -- Z71 4WD ONLY ROUGH STIFF BOUNCY RIDE. *MR (NHTSA ID #10006947, JANUARY 01 2004)
• TSB #3234 -- FRONT AXLE GROWL NOISE IN 2 WHEEL DRIVE MAY NOT OCCUR IN 4 WHEEL DRIVE. *EH (NHTSA ID #10011696, no date provided)
• TSB #1655777 -- VIBRATION HIGHWAY SPEED Z71 AND Z85 SUSPENSION. *SC (NHTSA ID #10016818, no date provided)

SUSPENSION:FRONT

• TSB #3175 -- SQUEAK OR CRUNCH NOISE FROM FRONT SUSPENSION OVER BUMPS. *TT (NHTSA ID #10010257, JANUARY 01 2004)

SUSPENSION:REAR

• TSB #PIP4054A -- EATON LOCKING DIFFERENTIAL CHATTER SHUDDER NOISE ON TURNS, EQUIPPED WITH A LOCKING REAR DIFFERENTIAL RPO G80. *NJ UPDATED 7/17/2008. *PE (NHTSA ID #10024345, FEBRUARY 01 2008)
• TSB #02150 -- RUB OR SCRAPE NOISE FROM REAR AXLE AREA ON TURNS. *MJ (NHTSA ID #10008887, JANUARY 01 2004)

SERVICE BRAKES, HYDRAULIC

• TSB #01934 -- FRONT BRAKES SEEM APPLIED. *MR (NHTSA ID #10006417, JANUARY 01 2004)
• TSB #030523005 -- NEW ESSENTIAL TOOL CH-47661 - ON-CAR BRAKE LATHE. *TT (NHTSA ID #10005556, NOVEMBER 01 2003)

SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

• TSB #01910 -- BRAKE PEDAL ARM MAY NOT STAY ENGAGED. *TT (NHTSA ID #10006816, JANUARY 01 2004)

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:SHOES/LININGS

• TSB #3567 -- ENGINEERING INVESTIGATION/PREMATURE REAR BRAKE SHOE WEAR. *TT PREMATURE REAR DRUM BRAKE WEAR. UPDATED ON 10/03/07. *NJ (NHTSA ID #10016521, no date provided)

SERVICE BRAKES, HYDRAULIC:ANTILOCK:ABS WARNING LIGHT

• TSB #3119 -- ABS BRAKE VALVE BLEED PROCEDURE CORRECTION. *SC (NHTSA ID #10010068, JANUARY 01 2004)
• TSB #3460D -- ANTI-LOCK BRAKING SYSTEM (ABS) LIGHT ON WITH EBCM DIAGNOSTIC TROUBLE CODES (DTCS) C0040, C0035, C0221 AND/OR C0220. *TT (NHTSA ID #10016563, no date provided)

SERVICE BRAKES, AIR

• TSB #4206 -- BRAKES SEEM TO GRAB ON FIRST FEW BRAKE APPLICATIONS. *KB (NHTSA ID #10020756, no date provided)

SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR

• TSB #3477 -- TECH 2 DISPLAYS ASTERISK FOR THE LEFT FRONT WHEEL SPEED SENSOR. *TT (NHTSA ID #10014875, no date provided)

SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT

• TSB #3460 -- ABS LIGHT ON WITH EBCM DTC'S C0035, C0040, C0220 AND/OR C0221. *KB UPDATED 1/30/08. *NJ (NHTSA ID #10021348, DECEMBER 01 2007)

ENGINE AND ENGINE COOLING

• TSB #050601026 -- INFORMATION ON USE OF BOLT EXTRACTOR TOOL KIT PART NUMBER EN-47702 FOR REMOVING BROKEN CYLINDER HEAD OR MAIN BEARING CAP BOLTS ON INLINE TRUCK ENGINES. *TT (NHTSA ID #10017818, SEPTEMBER 01 2005)
• TSB #03092005 -- SES LIGHT. *EH (NHTSA ID #10014842, MARCH 09 2005)
• TSB #09162004 -- EXHAUST BUZZ AT APPROXIMATELY 2100 RPM WIRH A POSSIBLE CAUSE OF THE HEAT SHIELD CONTACT WITH EXHAUST MANIFOLD. *EH (NHTSA ID #10011260, SEPTEMBER 16 2004)
• TSB #09072004 -- POSSIBLE LEAK IN THE AIR INDUCTION SYSTEM. *EH (NHTSA ID #10013193, SEPTEMBER 07 2004)
• TSB #08022004 -- RPM BEING TO LOW MAY CAUSE VIBRATION AT IDLE AND OR A ROUGH IDLE. *EH (NHTSA ID #10013329, AUGUST 02 2004)
• TSB #040605005 -- EXHAUST SYSTEM POPPING SNAPPING NOISE WHEN VEHICLE IS HOT AT IDLE OR IMMEDIATELY AFTER VEHICLE IS SHUT OFF. *EH (NHTSA ID #10012602, APRIL 01 2004)
• TSB #3039E -- MISFIRE AND POSSIBLE P0300-P0305 DIAGNOSTIC TROUBLE CODES. SERVICE ENGINE SOON LIGHT ON TOO. *SC (NHTSA ID #10010050, JANUARY 01 2004)
• TSB #3131 -- ENGINE VIBRATION/MOAN. *TC (NHTSA ID #10010015, JANUARY 01 2004)
• TSB #11052003 -- PCM CONTROL PLACEMENT. *EH (NHTSA ID #10013139, NOVEMBER 05 2003)
• TSB #3039 -- FLASHING SERVICE ENGINE SOON LIGHT WITH POSSIBLE MISFIRE AND P0300-P0304 DIAGNOSTIC TROUBLE CODE. *EH ENGINE EXCHANGE PROGRAM. *TT (NHTSA ID #10011688, no date provided)
• TSB #3262 -- TEMPERATURE COOLANT GAUGE LOW OR INOPERATIVE. *EH (NHTSA ID #10011632, no date provided)
• TSB #3008 -- ENGINE CONTROL CONCERNS DUE TO INTERMITTENT POWER CONTROL MODULE CONNECTION LOSS. *EH (NHTSA ID #10010876, no date provided)
• TSB #3221C -- SERVICE ENGINE SOON LIGHT DUE TO A P0171 DIAGNOSTIC TROUBLE CODE. *EH 3221A NOT YET RECEIVED. *TT UPDATE. *TT (NHTSA ID #10011666, no date provided)
• TSB #3614 -- P0300 DUE TO RANDOM MISFIRES NOT FELT - POSSIBLE ACCESSORY PULLEY. *TT (NHTSA ID #10018577, no date provided)
• TSB #3358 -- SERVICE ENGINE SOON (SES) LIGHT AND REDUCED ENGINE POWER DUE TO A P0507 DIAGNOSTIC TROUBLE CODE. *TT (NHTSA ID #10014876, no date provided)
• TSB #3150 -- CYLINDER LINER REPLACEMENT INFORMATION - INLINE TRUCK ENGINES. *EH (NHTSA ID #10010547, no date provided)

ENGINE AND ENGINE COOLING:ENGINE

• TSB #07123 -- SPECIAL COVERAGE ADJUSTMENT - ENGINE INTAKE VALVE SEAT MAY WEAR, SUCH THAT COMBUSTION LEAKAGE OCCURS. EQUIPPED WITH EITHER A 2.8L (RPO LK5) 4 CYLINDER OR 3.5L (RPO L52) 5 CYLINDER ENGINE. *NJ (NHTSA ID #10022722, AUGUST 01 2007)
• TSB #030604030 -- MULTIPLE DRIVEABILITY SYMPTOMS OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE DUE TO CLOGGED FUEL INJECTORS. *TT (NHTSA ID #10002166, MARCH 01 2007)
• TSB #040601022 -- NEW CYLINDER BORE LINER/PISTON SLEEVE REPLACEMENT PROCEDURE. *TT (NHTSA ID #10012109, JULY 01 2004)
• TSB #040601016 -- UNDERHOOD WHINE OR RATTLE TYPE NOISE. *TT (NHTSA ID #10008470, JUNE 01 2004)
• TSB #04192004 -- SERVICE ENGINE SOON LAMP BEING ILLUMINATED. WITH DIAGNOSTIC TROUBLE CODES P0507, P0621 OR P0622. GM VOICEMAIL EXPRESS. *TT (NHTSA ID #10009225, APRIL 19 2004)
• TSB #01553 -- WHINE TYPE NOISE FROM ENGINE. 3.5L L52. *TT (NHTSA ID #10005392, JANUARY 01 2004)
• TSB #3142 -- BROKEN HEAD BOLT REPAIR. *TC (NHTSA ID #10010194, JANUARY 01 2004)
• TSB #01851 -- CRANK NO START OR START STALL; MAY SET ONE OR MORE OF THE FOLLOWING CODES: B1373 B1442 B2957 B3031. *MR (NHTSA ID #10006590, JANUARY 01 2004)
• TSB #3112 -- VIBRATION AT IDLE AND/OR ROUGH IDLE. (EXTENDED CREW CABS ONLY). *JB (NHTSA ID #10010131, JANUARY 01 2004)
• TSB #3037 -- END OF ENGINE EXCHANGE PROGRAM FOR 3.5 L52 AND 2.8 LK5 ENGINES. *TT (NHTSA ID #10009646, JANUARY 01 2004)
• TSB #01939 -- 4.3 4.8 5.3 6.0 LR4 LU3 LM7 L59 LQ4 LQ9 ENGINES- EVAP CODE P0442. *MR (NHTSA ID #10006565, JANUARY 01 2004)
• TSB #01980 -- WHINE OR RATTLE NOISE FROM ENGINE. *MR (NHTSA ID #10006897, JANUARY 01 2004)
• TSB #01542 -- VACUUM TYPE HISSING NOISE FROM ENGINE. THIS NOISE IS MORE NOTICEABLE WHEN THE VEHICLE IS PARKED IN AN ENCLOSED AREA WITH THE HOOD UP. 3.5 L52 ENGINE. SIT BULLETIN 1409740. *TT (NHTSA ID #10005381, JANUARY 01 2004)
• TSB #3262 -- ENGINE VIBRATION AFTER ENGINE OR CRANKSHAFT REPLACEMENT. *SC (NHTSA ID #10017156, no date provided)
• TSB #3231 -- SUPPLEMENT TO 04-06-04-081 - PART NUMBER INFORMATION - 2004 AND 2005 3.5L L52 5 CYLINDER ENGINES. *TT (NHTSA ID #10011942, no date provided)
• TSB #3668 -- SERVICE ENGINE SOON LIGHT AFTER INTERNAL ENGINE REPAIRS DUE TO DIAGNOSTIC TROUBLE CODE P0017. *TT (NHTSA ID #10019180, no date provided)
• TSB #3694 -- A ROUGH IDLE / RUNNING CONCERN MAY BE ENCOUNTERED WITH A P0014 AND / OR P0017 DTC. *TT (NHTSA ID #10019455, no date provided)
• TSB #3694A -- ROUGH IDLE WITH DTC P0014 AND/OR P0017 - INSPECT CAM ACTUATOR SOLENOID SCREENS AND CRANKSHAFT END PLAY. *TT (NHTSA ID #10019427, no date provided)
• TSB #3145 -- SERVICE ENGINE SOON LIGHT DUE TO A P0171 DIAGNOSTIC TROUBLE CODE. *TT (NHTSA ID #10010251, no date provided)

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

• TSB #3338A -- DRIVE BELT NOISE - ADJUST OR REPLACE IDLER PULLEY BRACKET. *TT POTENTIAL ALIGNMENT AND BELT ISSUES. *TT (NHTSA ID #10017089, no date provided)

ENGINE AND ENGINE COOLING:COOLING SYSTEM

• TSB #01742 -- 2.8 LK5 3.5 L52 ENGINE - COOLANT TEMPERATURE GAUGE DROPS ON ACCELERATION. SIT BULLETIN 1460312. *TT (NHTSA ID #10006282, JANUARY 01 2004)
• TSB #01757 -- ENGINE COOLANT GAUGE DROP ON ACCELERATION. *MR (NHTSA ID #10006364, JANUARY 01 2004)
• TSB #01865 -- TEMPERATURE COOLANT GAUGE LOW OR INOPERATIVE. *MR (NHTSA ID #10006617, JANUARY 01 2004)

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

• TSB #02106 -- OIL CONSUMPTION AND/OR BLACK SMOKE FROM EXHAUST. *TT (NHTSA ID #10007732, JANUARY 01 2004)
• TSB #3147 -- EXHAUST BUZZ NOISE. *TT (NHTSA ID #10010271, JANUARY 01 2004)
• TSB #3131 -- EXHAUST MOAN AT 1,500 TO 1,800 RPM. *TT (NHTSA ID #10010277, JANUARY 01 2004)
• TSB #3311 -- 04-06-04-081A EXHAUST VALVE SEAL AND SPRING REPLACEMENT SUPPLEMENT. *TT (NHTSA ID #10017221, no date provided)

FUEL SYSTEM, OTHER

• TSB #07012 -- SPECIAL COVERAGE ADJUSTMENT - FUEL TANK CAPS MAY EXPERIENCE A CONDITION WHERE THE FUEL TANK CAP WON'T TIGHTEN PROPERLY, OR THE FUEL TANK CAP WON'T COME OFF, OR IS BROKEN. *NJ (NHTSA ID #10022723, AUGUST 01 2007)
• TSB #3078 -- SOME 2004 FULL SIZE TRUCKS AND UTILITIES MAY EXPERIENCE A DIAGNOSTIC TROUBLE CODE P0442. *TT (NHTSA ID #10010372, no date provided)

FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM

• TSB #3046A -- FUEL GAUGE FLUCTUATION IN PARK OR NEUTRAL. *TT (NHTSA ID #10009382, no date provided)

POWER TRAIN

• TSB #01599 -- 4L60E, 4L65E FORWARD AND LOW REVERSE WAVED STEEL CLUTCH PLATE APPEARANCE CHANGE. *TT (NHTSA ID #10007237, JANUARY 01 2004)
• TSB #3071 -- FLUID LEAK BETWEEN TRANSFER CASE AND TRANSMISSION ADAPTER. *TT (NHTSA ID #10009620, no date provided)

POWER TRAIN:MANUAL TRANSMISSION

• TSB #611 -- MANUAL TRANSMISSION SHIFTING-SOME OWNERS MAY COMMENT ON DIFFICULTY SHIFTING INTO REVERSE. *SC (NHTSA ID #10016263, NOVEMBER 01 2004)
• TSB #01974 -- MANUAL TRANSMISSION STUCK IN 3RD GEAR. *MR (NHTSA ID #10006949, JANUARY 01 2004)
• TSB #3264 -- GM POWERTRAIN WOULD LIKE TO RECEIVE PRODUCT FEEDBACK ON VEHICLES WITH THE MA5 5-SPEED MANUAL TRANSMISSION, FOR ANY LEAK OR NOISE CONDITION, PRIOR TO ANY REPAIR ATTEMPTS. *TT (NHTSA ID #10017166, no date provided)
• TSB #3136 -- SLIP CONDITION IN 2ND, 3RD, OR 4TH. DAMAGED 2-4 OR 3-4 CLUTCH. *KB UPDATED 10/31/07. *NJ (NHTSA ID #10021019, no date provided)

POWER TRAIN:AUTOMATIC TRANSMISSION

• TSB #040421002 -- NOISE AND BUMP CLUNK FELT WHEN TRANSFER CASE SHIFTED INTO FOUR LOW. *EH (NHTSA ID #10012181, JANUARY 01 2006)
• TSB #010730038B -- THE SERVICE ENGINE SOON LAMP IS ILLUMINATED, NO 3RD AND 4TH GEAR, THE TRANSMISSION DOES NOT SHIFT CORRECTLY, THE TRANSMISSION FEELS LIKE IT SHIFTS TO NEUTRAL OR A LOSS OF DRIVE OCCURS. *TT (NHTSA ID #10005162, OCTOBER 01 2005)
• TSB #07092004 -- PROGRAMMING THE PCM. *EH (NHTSA ID #10013186, JULY 09 2004)
• TSB #00702 -- SLIP CONDITION IN 2ND, 3RD OR 4TH DAMAGED 2-4 BAND 3-4 CLUTCH ON THE 4L60E/4L65E AUTOMATIC TRANSMISSION. *TT *MJ (NHTSA ID #10005476, JANUARY 01 2004)
• TSB #11182003 -- FOUR WHEEL DRIVE SYSTEM OPERATION. *EH (NHTSA ID #10013259, NOVEMBER 18 2003)
• TSB #030730056 -- 4L60-E AUTOMATIC TRANSMISSION OIL PUMP FIRST AND SECOND DESIGN IDENTIFICATION. *TT (NHTSA ID #10005566, NOVEMBER 01 2003)
• TSB #3170 -- HARSH 1-2 SHIFT. *EH (NHTSA ID #10010577, no date provided)
• TSB #3136 -- THE 4L60E/4L65E AUTOMATIC TRANSMISSION SLIP CONDITION IN 2ND, 3RD, OR 4TH GEAR. ALSO TO INCLUDE THE PONTIAC GTO 2005. *TC (NHTSA ID #10010080, no date provided)
• TSB #3182 -- 3-2 AND 4-2 WOT DOWN SHIFT INORMATION. *EH (NHTSA ID #10010605, no date provided)

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

• TSB #01509 -- POWER TRAIN CONTROL MODULE P12 REPLACEMENT. SIT BULLETIN 1406647. *TT (NHTSA ID #10005490, JANUARY 01 2004)
• TSB #3082 -- PCM PROGRAMMING CONCERNS. GMT355. *TT (NHTSA ID #10010362, no date provided)

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

• TSB #020730024A -- DIAGNOSIS OF CRACKED OR BROKEN TRANSMISSION CASE. *TT 2006 AND PRIOR CARS AND LIGHT DUTY TRUCKS. *TT (NHTSA ID #634999, AUGUST 01 2005)

POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

• TSB #3424 -- ELECTRONIC TRANSFER CASE UNABLE TO COMPLETE SHIFT. *TT (NHTSA ID #10017299, no date provided)
• TSB #3308A -- POSSIBLE NO 4WD SHIFT CONCERN DIAGNOSTIC TROUBLE CODE C0327. *TT (NHTSA ID #10017189, no date provided)

POWER TRAIN:DRIVELINE

• TSB #030421007 -- DRIVELINE CHARACTERISTICS FOR FOUR-WHEEL DRIVE (4WD) SYSTEM. *TT (NHTSA ID #10004720, OCTOBER 01 2003)

POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

• TSB #3332 -- RIGHT REAR WHEEL APPEARS TO EXTEND OUT FURTHER THAN THE LEFT SIDE. *SC (NHTSA ID #10017170, OCTOBER 20 2006)

POWER TRAIN:AXLE ASSEMBLY

• TSB #03032005 -- AXLE GRINDING OR SIMILAR CONCERN AFTER USING SPARE TIRE. *EH (NHTSA ID #10014872, MARCH 03 2005)
• TSB #01735B -- FRONT AXLE GROWL NOISE IN 2WD MAY NOT OCCUR IN 4WD. *TT (NHTSA ID #10007290, JANUARY 01 2004)
• TSB #01735 -- FRONT AXLE GROWL NOISE IN 2WD MAY NOT OCCUR IN 4WD. SIT BULLETIN 1459942. *TT (NHTSA ID #10006352, JANUARY 01 2004)
• TSB #3224 -- RUB OR SCRAPE NOISE FROM REAR AXLE AREA ON TURNS. *EH (NHTSA ID #10010642, no date provided)

ELECTRICAL SYSTEM

• TSB #040849013 -- BATTERY MESSAGE DISPLAYED IN DRIVERS INFORMATION CENTER. *EH (NHTSA ID #10012622, APRIL 01 2004)
• TSB #01772A -- DIAGNOSTIC TROUBLE CODE (DTC) P0351 - P0358 MISLABELED DTCS. DTC DISPLAYED ON TECH 2 MAY NOT REFLECT ACTUAL IC CIRCUIT OR COIL/MODULE OR WHERE PROBLEM IS DETECTED. *TT (NHTSA ID #10007969, JANUARY 01 2004)
• TSB #01802A -- APP SENSOR 2 AND/OR TP SENSOR 2 SIGNAL CIRCUIT VOLTAGES DROP. *TT (NHTSA ID #10007965, JANUARY 01 2004)
• TSB #01787 -- BATTERY LIGHT AND OR MESSAGE ON DIC WITH OR WITHOUT P0621, P0622. *MR (NHTSA ID #10006710, JANUARY 01 2004)
• TSB #02034 -- PCM (POWERTRAIN CONTROL MODULE) PIN FIT CAUSING VARIOUS DRIVEABILITY, A/C, IPC (INSTRUMENT PANEL CLUSTER), ENGINE CONTROL, TRANS, EVAP CONCERNS. *TT (NHTSA ID #10007258, JANUARY 01 2004)
• TSB #3174 -- PASSENGER HEATED SEAT AND/OR LUMBAR INOPERATIVE FUSE 18 OPEN. *TT (NHTSA ID #10010256, JANUARY 01 2004)
• TSB #01878 -- DIAGNOSTIC TROUBLE CODE P0315, OIL LIFE MONITOR RESET AND/OR RADIO LOCK OUT AFTER SWAPPING BODY CONTROL MODULE (BCM). *TT (NHTSA ID #10006475, JANUARY 01 2004)
• TSB #01576A -- WILL NOT TURN ON ANY WARNING LIGHTS-BODY CONTROL MODULE. *MN (NHTSA ID #10005432, JANUARY 01 2004)
• TSB #01902 -- BATTERY MESSAGE DISPLAYED AND DIC COLD START. NO CODES SET. *TT (NHTSA ID #10006806, JANUARY 01 2004)
• TSB #01529 -- BODY CONTROL MODULE (BCM) REPLACEMENT, ODOMETER PROGRAMMING. SIT BULLETIN 1408724. *TT (NHTSA ID #10005446, JANUARY 01 2004)
• TSB #3008 -- VARIOUS DRIVEABILITY, AIR CONDITIONER, INSTRUMENT PANEL CLUSTER, ENGINE CONTROL, TRANSMISSION, EVAP CONCERNS. *TT (NHTSA ID #10008788, JANUARY 01 2004)
• TSB #01830 -- DOME LIGHT ON DOOR AJAR MESSAGE. *MR (NHTSA ID #10006748, JANUARY 01 2004)
• TSB #3162 -- ADDITIONAL DIAGNOSTICS FOR ABS DTC'S. *TC (NHTSA ID #10010047, JANUARY 01 2004)
• TSB #01868 -- UNWANTED HAZARD LIGHTS ON , IPC INOPERATIVE., DOOR LOCKS INOPERATIVE. NO START, BATTERY DEAD. *MR (NHTSA ID #10006651, JANUARY 01 2004)
• TSB #01859 -- DIAGNOSING ABS C0035 C0040 C0221 C0220. *MR (NHTSA ID #10006613, JANUARY 01 2004)
• TSB #02021 -- ENGINE- DIAGNOSTIC TROUBLE CODE P0507. *MR (NHTSA ID #10006963, JANUARY 01 2004)
• TSB #02065 -- DIAGNOSTIC TROUBLE CODE (DTC) P0621 AND/OR P0622. BATTERY CHARGE INDICATOR ILLUMINATED ON INSTRUMENT PANEL CLUSTER (IPC). *TT (NHTSA ID #10007762, JANUARY 01 2004)
• TSB #3529 -- UNWANTED HAZARD LIGHTS ON , IPC INOPERATIVE., DOOR LOCKS INOPERATIVE. NO START, BATTERY DEAD. *TT (NHTSA ID #10017250, JANUARY 01 1900)
• TSB #3342 -- CRUISE CONTROL AND/OR SUNVISOR VANITY LIGHT INOPERATIVE FUSE OPEN. *TT (NHTSA ID #10017257, no date provided)
• TSB #3338 -- MULTIPLE ELECTRICAL CONCERNS INSTRUMENT PANEL CLUSTER INDICATORS ILLUMINATE POSSIBLE NO START. *SC (NHTSA ID #10017183, no date provided)
• TSB #3048 -- DOME LIGHT STAYS ON OR THE DOOR AJAR MESSAGE IS ILLUMINATED. *TT (NHTSA ID #10013506, no date provided)

ELECTRICAL SYSTEM:BATTERY

• TSB #08-06-04-014 -- MIL/SES, DTC'S P060E, P1516, P2135 AND/OR P2138 WITH REDUCED ENGINE POWER (TEST AND CHARGE BATTERY) - WITH 2.8L, 2.9L, 3.5L OR 3.7L ENGINE (VIN'S 6, 8, 9, E - RPO'S L52, LK5, LLV, LLR). *NJ (NHTSA ID #10024784, MARCH 01 2008)
• TSB #709 -- BATTERY DRAW. GM. TECH LINK. *TT (NHTSA ID #10018132, SEPTEMBER 01 2005)
• TSB #01787A -- BATTERY MESSAGE DISPLAYED ON DIC AFTER A COLD START. NO CODES SET. *TT (NHTSA ID #10007533, JANUARY 01 2004)

ELECTRICAL SYSTEM:BATTERY:CABLES

• TSB #3201 -- POSITIVE BATTERY CABLE PROTECTIVE COVER MISSING OR BROKEN. *EH (NHTSA ID #10010592, no date provided)

ELECTRICAL SYSTEM:STARTER ASSEMBLY

• TSB #01718 -- STARTER CLICKS - NO CRANK CONDITION. *TT (NHTSA ID #10007932, JANUARY 01 2004)

ELECTRICAL SYSTEM:STARTER ASSEMBLY:SOLENOID

• TSB #3090 -- PRESSURE CONTROL SOLENOID OUTPUT FUNCTION INOPERATIVE ON TECH 2. *SC (NHTSA ID #10010235, JANUARY 01 2004)

ELECTRICAL SYSTEM:WIRING

• TSB #773 -- NEW VEHICLE AND SNOWPLOW MODEL APPLICATION INFORMATION. TWO NEW PLUG-IN HARNESS KITS. WESTERN PRODUCTS SERVICE BULLETIN. *TT (NHTSA ID #10008402, JUNE 07 2004)
• TSB #01858 -- NO CRANK, NO START, FUSE 23 OPEN. *MR (NHTSA ID #10006659, JANUARY 01 2004)

ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS

• TSB #3924 -- SES LIGHT DUE TO A P060E DTC INSPECT APP AND TP CIRCUITS. *KB (NHTSA ID #10020492, SEPTEMBER 27 2006)
• TSB #3113 -- NO CRANK, NO START IGN FUSE #23 IN THE UBEC MAY BE OPEN. *SC (NHTSA ID #10010074, JANUARY 01 2004)
• TSB #3164 -- FUSE 42 OPENS WHEN USING THE POWER WINDOW OR SPORADIC DOOR LOCKS. *TC (NHTSA ID #10010099, JANUARY 01 2004)
• TSB #3615 -- 20A STOP FUSE OPENS AT TIMES. *TT (NHTSA ID #10017275, no date provided)

ELECTRICAL SYSTEM:IGNITION

• TSB #3867 -- SERVICING THE IGNITION SWITCH AND/OR PASSLOCK SENSOR. *TT (NHTSA ID #10019457, no date provided)

EXTERIOR LIGHTING

• TSB #0405 -- LIGHTING APPLICATIONS FOR VEHICLES WHERE SNOWPLOW DAYTIME RUNNING LIGHTS (DRL'S) ARE/ ARE NOT REQUIRED. FISHER. *TT (NHTSA ID #10008456, MAY 28 2004)

VISIBILITY:WINDSHIELD

• TSB #01949 -- WIND NOISE AT WINDSHIELD. *MR (NHTSA ID #10006940, JANUARY 01 2004)

VISIBILITY:GLASS, SIDE/REAR

• TSB #3184 -- DOOR GLASS BECOMES LOOSE FROM THE REGULATOR. *TT (NHTSA ID #10010282, no date provided)

VISIBILITY:REARVIEW MIRRORS/DEVICES

• TSB #3268 -- VIEW MIRROR OPERATION OPTION DF8 AND DC4. *EH (NHTSA ID #10011651, no date provided)

VISIBILITY:REARVIEW MIRRORS/DEVICES:INTERIOR

• TSB #01590 -- THE OWNERS MANUAL AND SI ARE INCORRECT IN DESCRIPTION OF OPERATION FOR THE AUTOMATIC DIMMING MIRROR WITH COMPASS, TEMPERATURE DISPLAY AND MAP LIGHTS. SIT BULLETIN 1414380. *TT (NHTSA ID #10005429, JANUARY 01 2004)

VISIBILITY:WINDSHIELD WIPER/WASHER

• TSB #3827 -- WIPERS CYCLE SEVERAL TIMES, THEN PARK IN THE MIDDLE OF THE WINDSHIELD. *AK (NHTSA ID #10019181, no date provided)

VISIBILITY:DEFROSTER/DEFOGGER SYSTEM

• TSB #01589 -- AIRFLOW FROM LEFT SIDE DEFROST VENT LESS THAN RIGHT SIDE. SIT BULLETIN 1414379. *TT (NHTSA ID #10005428, JANUARY 01 2004)

VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:BLOWER

• TSB #3019 -- FLUTTERING TYPE NOISE WITH THE HVAC BLOWER MOTOR ON. *TT (NHTSA ID #10008785, JANUARY 01 2004)
• TSB #3040A -- BLOWER MOTOR MAY STAY ON ALL THE TIME OR HAVE ERRATIC BLOWER MOTOR OPERATION. *TT (NHTSA ID #10009386, JANUARY 01 2004)
• TSB #3688A -- BLOWER MOTOR INOPERATIVE IN ANY ONE OR MORE BLOWER SPEED. *TT (NHTSA ID #10019187, no date provided)

VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:HEATER CORE

• TSB #3108 -- DTC P0128 AND/OR NO HEAT FROM HEATER. *SC (NHTSA ID #10009977, JANUARY 01 2004)
• TSB #3197 -- VIBRATION AT ALL SPEEDS DAMAGED TRANSMISSION TAILSHAFT BUSHING CRACKED EXHAUST AT CATALYTIC CONVERTER. *EH (NHTSA ID #10010648, no date provided)

AIR BAGS

• TSB #050941005 -- AIR BAG READINESS LIGHT/SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) LIGHT ON, DIAGNOSTIC TROUBLE CODE(S) (DTC) B0057, B0058, B0059, B0064, B0065, B0066. *TT (NHTSA ID #10015039, MAY 01 2005)

STRUCTURE

• TSB #01914 -- ROOF WELD JOINT REVEAL MOLDING REPLACEMENT (DITCH MOLDING). *TT (NHTSA ID #10006818, JANUARY 01 2004)
• TSB #01833 -- INTENTIONAL LACK OF SEALANT AT HEADBOARD OF PICKUP BOX. *MR (NHTSA ID #10006666, JANUARY 01 2004)
• TSB #01943 -- WATER LEAK LEFT RIGHT FLOOR. *MR (NHTSA ID #10006492, JANUARY 01 2004)
• TSB #3112 -- ROOF DITCH MOLDING MAY LOOSE. *SC (NHTSA ID #10010073, JANUARY 01 2004)
• TSB #3043D -- WATER LEAK ON DRIVERS FLOOR. *TC (NHTSA ID #10009981, no date provided)

STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS

• TSB #01942 -- RATTLE NOISE REAR OF EXTENDED CAB. *MR (NHTSA ID #10006494, JANUARY 01 2004)

STRUCTURE:BODY

• TSB #040857004 -- WATER ON DRIVER'S FLOOR. *EH (NHTSA ID #10011234, SEPTEMBER 01 2006)
• TSB #02242004 -- LACK OF SEAM SEALER AT THE HEADBOARD OF THE PICK-UP BOX ON REGULAR AND EXTENDED CABS. *TT (NHTSA ID #10013002, FEBRUARY 24 2004)
• TSB #040851001 -- REPAIR PROCEDURE FOR PAINT CONCERN. *EH (NHTSA ID #10012684, FEBRUARY 01 2004)
• TSB #01292004 -- ORANGE PEEL PAINT CONDITION. *TT (NHTSA ID #10013034, JANUARY 29 2004)
• TSB #01537 -- REGULAR PRODUCTION ACCESSORY INSTALLATION INFORMATION. DEALERSHIPS SHOULD REFRAIN FROM INSTALLING BED EXTENDERS. THE CURRENT BUILD OF CERTAIN VEHICLES PREVENTS THE TAILGATE FROM BEING CLOSED WHEN THE BED EXTENDER BRACKETS ARE PROPERLY INS (NHTSA ID #10005477, JANUARY 01 2004)
• TSB #3043A -- WATER LEAK ON DRIVERS FLOOR. *TT (NHTSA ID #10009381, JANUARY 01 2004)
• TSB #01612 -- PAINT ORANGE PEEL CONDITION. *TT (NHTSA ID #10007141, JANUARY 01 2004)
• TSB #3105 -- BODY SIDE MOLDINGS BECOME LOOSE/RPO B84. *SC (NHTSA ID #10010224, JANUARY 01 2004)

STRUCTURE:BODY:BUMPERS

• TSB #09142004 -- BUMPER BOLT BREAKAGE DURING REMOVAL PRIOR TO INSTALLING TRAILER HITCHES. *EH (NHTSA ID #10011258, SEPTEMBER 14 2004)
• TSB #3053A -- WHEN REMOVING THE REAR BUMPER TO INSTALL A TRAILER HITCH, THE RIGHT BOLT MAY BREAK OR THE SPOT WELD HOLDING THE NUT IN PLACE BREAKS LOOSE. *TT (NHTSA ID #10009676, JANUARY 01 2004)
• TSB #3053 -- BUMPER BOLT AND OR NUT BREAKS WHEN ATTEMPTING REMOVAL. *TT (NHTSA ID #10010368, no date provided)

STRUCTURE:BODY:DOOR

• TSB #03102005 -- REMOVAL OF DOOR TRIM. *EH (NHTSA ID #10014849, MARCH 10 2005)
• TSB #3200 -- DRIVERS OR PASSENGERS DOOR SWITCH BEZEL. *EH (NHTSA ID #10010591, no date provided)

STRUCTURE:BODY:TAILGATE

• TSB #3575 -- REAR TAILGATE HARD TO OPEN. *TT (NHTSA ID #10017301, no date provided)

LATCHES/LOCKS/LINKAGES

• TSB #01652 -- REMOTE KEYLESS ENTRY FEEDBACK/DOOR LOCK AND LANGUAGE PERSONALIZATION.*MR (NHTSA ID #10007221, JANUARY 01 2004)

VEHICLE SPEED CONTROL:LINKAGES

• TSB #3126 -- MA5 5 SPEED NORMAL REVERSE GEAR OPERATION. *TC UPDATE. *TT (NHTSA ID #10009955, AUGUST 24 2004)

TIRES

• TSB #03292004 -- VIBRATION AT HIGHWAY SPEEDS CAUSED BY THE TIRES FLAT SPOTTING AS A RESULT OF THE TIRES REACHING HIGH TEMPERATURES AND THEN COOLING WHILE PARKED. ENGINEERING IS CURRENTLY TESTING A REDESIGN OF THE TIRE. *TT (NHTSA ID #10009192, MARCH 29 2004)
• TSB #01959 -- P265/75R15 TIRE VIBRATION AT HIGHWAY SPEED. *TT (NHTSA ID #10007607, JANUARY 01 2004)
• TSB #01644 -- CHANGING TIRE SIZE.*MR (NHTSA ID #10007156, JANUARY 01 2004)
• TSB #3107 -- VIBRATION HIGHWAY SPEED. SUSPENSION PACKAGE MAY EXPERIENCE A VIBRATION AT HIGHWAY SPEEDS. *EH (NHTSA ID #10011601, no date provided)

TIRES:TREAD/BELT

• TSB #3198 -- EXCESSIVE INSIDE TIRE WEAR. *EH (NHTSA ID #10010620, no date provided)

TIRES:TEMPORARY/EMERGENCY SPARE TIRE

• TSB #3085 -- THE SPARE TIRE IS A DIFFERENT SIZE COMPARED TO THE REST OF THE TIRES. THE Z71 OPTION COMES WITH P265/75R15 TIRES, AND THE SPARE TIRE IS A P235/75R15. *TT (NHTSA ID #10009508, no date provided)

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

• TSB #3174A -- HVAC, PASSENGER LUMBAR AND/OR PASSENGER HEATED SEAT INOPERATIVE. *TT (NHTSA ID #10017147, no date provided)

EQUIPMENT

• TSB #050846006A -- INFORMATION ON UPGRADING CERTAIN ONSTAR GENERATION 5 ANALOG/DIGITAL-READY SYSTEMS TO ONSTAR GENERATION 6 DUAL-MODE (ANALOG/DIGITAL). *TT (NHTSA ID #10015018, SEPTEMBER 01 2005)

EQUIPMENT:ELECTRICAL

• TSB #03042005 -- BUTTONS ARE NOT LABELED. *EH (NHTSA ID #10014873, MARCH 04 2005)
• TSB #3134 -- BUZZ OR CRACKLE NOISE FROM THE AUDIO SPEAKERS. *SC (NHTSA ID #10009969, JANUARY 01 2004)
• TSB #3165 -- TWO TYPES OF AUDIBLE WARNINGS LOCATIONS AND SOUNDS. *TC (NHTSA ID #10010117, JANUARY 01 2004)
• TSB #3088A -- ODOMETER READS 0 MILES AFTER REPLACING THE INSTRUMENT PANEL CLUSTER (IPC). *TT (NHTSA ID #10009515, no date provided)

EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

• TSB #02074 -- ALARM SOUNDS WHEN UNLOCKING DOORS WITH A KEY. *TT (NHTSA ID #10007771, JANUARY 01 2004)

EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

• TSB #01958 -- PRODUCT INFORMATION REGARDING RADIO PERSONALIZATION. *MR (NHTSA ID #10006948, JANUARY 01 2004)
• TSB #01662 -- XM ERROR ON A RADIO DISPLAY. *TT (NHTSA ID #10007248, JANUARY 01 2004)
• TSB #01759 -- XM RAPID ACTIVATION UTILIZATION. *MR (NHTSA ID #10006302, JANUARY 01 2004)
• TSB #02060 -- NO AUDIO AND RADIO DISPLAY INOPERATIVE OR CLOCK RESETS. *TT (NHTSA ID #10007760, JANUARY 01 2004)

EQUIPMENT:ELECTRICAL:AIR CONDITIONER

• TSB #040138012 -- WHISTLE HISS HUM NOISE HEARD WHEN AC IS ON. *EH UPDATED *EH (NHTSA ID #10012724, NOVEMBER 01 2004)
• TSB #3407 -- ENGINEERING INVESTIGATION OF THE HVAC BLOWER RESISTOR AND MOTOR. *TT UPDATE. TT (NHTSA ID #10013546, no date provided)

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

• TSB #07012004 -- OIL LIFE SYSTEM RESET PROCEDURES-TRUCKS. BUICK TERAZZA 2005, GMC SIERRA DENALI 2002-2003, GMC B7 CHASSIS MEDIUM DUTY 2003-2005 AND GMC 560 C-SERIES 2003-2005 *SC (NHTSA ID #10014251, JULY 01 2004)
• TSB #01617 -- DINGHY AND OR/ DOLLY TOWING - OWNERS MANUAL INFORMATION.*MR (NHTSA ID #10007182, JANUARY 01 2004)
• TSB #3429 -- OWNERS MANUAL INFORMATION INCORRECT. THE OWNERS MANUAL INDICATES FOR 4WD VEHICLES, IF THE VEHICLE IS TO BE DINGHY OR DOLLY TOWED WITH THE KEY IN THE LOCK POSITION, THE CLSTR AND RDO BATT FUSES SHOULD BE PULLED FROM THE INSTRUMENT PANEL FUS (NHTSA ID #10017200, no date provided)

UNKNOWN OR OTHER

• TSB #092203 -- GM SERVICE TECHNICAL COLLEGE WITH A MESSAGE REGARDING GM SERVICE KNOW-HOW SEMINARS. GM VOICEMAIL LOG. *TT (NHTSA ID #10005044, SEPTEMBER 22 2003)
• TSB #01444 -- XM DEALER ASSISTANCE LINE INFORMATION. *TT (NHTSA ID #10004411, JANUARY 01 2003)