[ switch models ] 2002 Oldsmobile Aurora 2002 Oldsmobile Bravada 2002 Oldsmobile Cutlass 2002 Oldsmobile Intrigue [ switch years ] 2006 Oldsmobile Alero 2004 Oldsmobile Alero 2003 Oldsmobile Alero 2001 Oldsmobile Alero 2000 Oldsmobile Alero 1999 Oldsmobile Alero 1998 Oldsmobile Alero 1997 Oldsmobile Alero

2002 Oldsmobile Alero

2002 Oldsmobile Alero TSBs (Technical Service Bulletins)

There are also 1 Oldsmobile recalls » 2 defect investigations » 171 TSBs » for the Oldsmobile Alero.

Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB title & date, & either contact your local dealer or click on the links below.

ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use to track each bulletin -- yes, it's a very screwed up situation that's almost completely unhelpful to you as the consumer. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.

STEERING

• TSB #040232001 -- RELEASE OF STEERING GEAR STUB SHAFT BEARING KIT FOR SERVICE. *TT UPDATED 08-15-07. *KB UPDATED 10/09/07. *NJ (NHTSA ID #10012694, AUGUST 01 2007)
• TSB #060235010 -- CLUNK FELT/NOISE HEARD FROM STEERING COLUMN, STEERING GEAR AND/OR FRONT OF VEHICLE DURING MANEUVER AND/OR STEERING WHEEL ROTATION. (REPLACE INTERMEDIATE SHAFT). *KB (NHTSA ID #10020814, MAY 01 2006)
• TSB #030232001B -- MOMENTARY REDUCTION OF POWER STEERING PS ASSIST ON INITIAL START UP WITH LOW AMBIENT TEMPERATURES. THIS SERVICE BULLETIN REPLACES 030232001A. *EH (NHTSA ID #10012093, JULY 01 2004)
• TSB #030236002 -- REVISED STEERING WHEEL POSITION SENSOR OR STEERING SHAFT LOWER BEARING REPLACEMENT PROCEDURE AND STEERING WHEEL POSITION SENSOR CENTERING PROCEDURE. *EH (NHTSA ID #10012577, AUGUST 01 2003)

STEERING:COLUMN

• TSB #060235019 -- REVISED TILT STEERING WHEEL AND COLUMN FASTENER TIGHTENING SPECIFICATIONS. *KB (NHTSA ID #10020731, SEPTEMBER 01 2006)

STEERING:HYDRAULIC POWER ASSIST SYSTEM

• TSB #030232001A -- MOMENTARY REDUCTION ON POWER STEERING (P/S) ASSIST ON INITIAL START UP WITH LOW AMBIENT TEMPERATURES. *TT (NHTSA ID #10004762, OCTOBER 01 2003)
• TSB #022403 -- INTERMITTENT CONDITION OF A MOMENTARY REDUCTION IN POWER STEERING ASSIST AT STARTUP. *TT *JB (NHTSA ID #10001842, FEBRUARY 24 2003)

STEERING:LINKAGES:TIE ROD ASSEMBLY

• TSB #030232049 -- RELEASE OF NEW OUTER TIE ROD ENDS FOR SERVICE. *TT (NHTSA ID #10004765, NOVEMBER 01 2003)

SUSPENSION

• TSB #040308015A -- SQUEAKING NOISE IN FRONT END ON TURNS. *TT (NHTSA ID #10011062, MAY 01 2005)
• TSB #040308010 -- CHANGES TO LABOR TIME GUIDE RELATING TO FRONT SUSPENSION LABOR OPERATIONS COMPONENTS. *EH (NHTSA ID #10012182, JUNE 01 2004)
• TSB #020308008 -- RATTLE, CREAK, POPPING TYPE NOISE FROM FRONT OF VEHICLE WHEN TURNING. *TT (NHTSA ID #10000465, NOVEMBER 01 2002)
• TSB #020310003 -- CONCERNS WITH SCRAPING/SCRUNCHING NOISE FROM FRONT OF VEHICLE DURING LOW SPEED TURNING AND BRAKING. *TT (NHTSA ID #634881, JUNE 01 2002)
• TSB #051602 -- SOME CUSTOMERS MAY COMMENT ABOUT A METAL BUMPING OR BANGING TYPE NOISE OVER BUMPS UNDER THE FRONT SUSPENSION AREA OF THE VEHICLE. *TT (NHTSA ID #636684, MAY 16 2002)
• TSB #010308003A -- SOME CUSTOMERS MAY COMMENT ON A SQUAWK NOISE FROM THE FRONT AND/OR REAR SUSPENSION WHILE DRIVING. *TT (NHTSA ID #629407, FEBRUARY 01 2002)
• TSB #010308003 -- INFORMATION REGARDING SQUAWK NOISE FROM FRONT AND/OR REAR SUSPENSION. *YH (NHTSA ID #627662, OCTOBER 01 2001)
• TSB #050901 -- SOME CUSTOMERS MAY COMMENT OF A SQUAWK NOISE FROM THE FRONT OR REAR SUSPENSION AREA. *SLC (NHTSA ID #626054, SEPTEMBER 05 2001)
• TSB #3263 -- FRONT SUSPENSION NOISE ON TURNS. *EH (NHTSA ID #10011819, no date provided)

SUSPENSION:FRONT

• TSB #02139 -- SQUEAK OR RUB TYPE NOISE ON TURNS COMING FROM THE FRONT SUSPENSION AS IF IT IS COMING FROM THE SHOCK ABSORBER OR THE TOP MOUNT. *TT (NHTSA ID #10008871, JANUARY 01 2004)

SUSPENSION:FRONT:WHEEL BEARING

• TSB #021303 -- FRONT WHEEL BEARING REPLACEMENT. *TT (NHTSA ID #10002550, FEBRUARY 13 2003)

SERVICE BRAKES, HYDRAULIC

• TSB #050523001 -- REVISED BRAKE SYSTEM SPECIFICATIONS. *TT (NHTSA ID #10014985, MARCH 01 2005)
• TSB #040523004 -- BRAKE NOISE/CREAK DURING SLOW SPEED BRAKING. ALSO INCLUDES 2004 CHEVROLET MALIBU CLASSIC. *TT (NHTSA ID #10011052, SEPTEMBER 01 2004)
• TSB #3003 -- BRAKE NOISE/CREAK DURING SLOW SPEED BRAKING. *MJ (NHTSA ID #10008862, JANUARY 01 2004)
• TSB #061303 -- A REVIEW OF WARRANTY DATA AND PARTS SENT BACK TO THE WARRANTY PARTS CENTER INDICATES THAT BRAKE ROTORS AND PADS ARE BEING REPLACED FOR PRESALE LOT ROT CORROSION ISSUES. *TT (NHTSA ID #10003704, JUNE 17 2003)
• TSB #000523002B -- FRONT DISC BRAKE PULSATION. *TT (NHTSA ID #10001251, MARCH 01 2003)

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

• TSB #210602 -- INFORMATION REGARDING THE BRAKE ALIGN KIT. *TT (NHTSA ID #637253, JUNE 21 2002)
• TSB #051502 -- ADDITIONAL INFORMATION ON REPEAT BRAKE PULSATION AFTER AN INITIAL BRAKE REPAIR. *TT (NHTSA ID #636679, MAY 15 2002)
• TSB #020522001 -- SERVICE MANUAL UPDATE REGARDING REVISED BRAKE SPECIFICATIONS. *TT (NHTSA ID #634845, APRIL 01 2002)

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

• TSB #021803 -- METAL RATTLE TYPE NOISE FROM THE REAR OF THE VEHICLE. CAUSED BY A LOOSE ATTACHMENT SPRING CLIP AT THE REAR BRAKE LINE HOSE BRACKET. THIS CLIP IS SECURED PROPERLY, BUT MAY NOT PROVIDE ENOUGH SPRING TENSION, WHICH ALLOWS IT TO RATTLE AGAI (NHTSA ID #10002556, FEBRUARY 18 2003)

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS

• TSB #022603 -- BRAKE PAD REPLACEMENT. *TT *JB (NHTSA ID #10001848, FEBRUARY 26 2003)

SERVICE BRAKES, HYDRAULIC:ANTILOCK

• TSB #280901 -- SOME CUSTOMERS MAY COMPLAIN OF AN ABS LIGHT BEING PRESENT. *JG (NHTSA ID #626552, SEPTEMBER 28 2001)

SERVICE BRAKES, HYDRAULIC:ANTILOCK:ABS WARNING LIGHT

• TSB #141101 -- CUSTOMERS MAY COMMENT THAT THE ANTI-LOCK BRAKE SYSTEM INDICATOR IS ILLUMINATED AND DIAGNOSTIC TROUBLE CODE 1236 STORED. *TT (NHTSA ID #628132, NOVEMBER 14 2001)
• TSB #3192 -- THE ANTI-LOCK BRAKE SYSTEM INDICATOR IS ILLUMINATED AND DIAGNOSTIC TROUBLE CODE C1236 IS STORED. *TT (NHTSA ID #10010632, no date provided)

SERVICE BRAKES, AIR

• TSB #070201 -- INCORRECT OUTER BACKING PLATE. OUTER BACKING PLATE HAS SHORT CENTRE PROTUSION. OUTER BACKING PLATE SHOULD HAVE TALL CENTER PROTRUSION. *KB (NHTSA ID #10021412, MARCH 01 2007)
• TSB #3169 -- BRAKES CALIPER NOISE ON APPLY. *EH (NHTSA ID #10010551, no date provided)
• TSB #4615 -- ABS PUMP RUNNING WHEN NOT NEEDED. *NJ (NHTSA ID #10023171, no date provided)

SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR

• TSB #04152004 -- VEHICLES MAY SET ANYONE OR A COMBINATION OF FRONT-WHEEL SPEED SENSOR ANTI-LOCK BRAKE SYSTEM CODES AS INTERMITTENT OR HARD FAILURES. GM VOICEMAIL EXPRESS. *TT (NHTSA ID #10009220, APRIL 15 2004)
• TSB #00966B -- ABS FRONT WHEEL SPEED CODES - JUMPER HARNESS. *TT (NHTSA ID #10007293, JANUARY 01 2004)
• TSB #00966 -- ANTI-LOCK BRAKING SYSTEM (ABS) FRONT WHEEL SPEED CODES - JUMPER HARNESS. *TT (NHTSA ID #10007816, JANUARY 01 2004)
• TSB #3477 -- TECH 2 DISPLAYS ASTERISK FOR THE LEFT FRONT WHEEL SPEED SENSOR. *TT (NHTSA ID #10014875, no date provided)

ENGINE AND ENGINE COOLING

• TSB #709 -- OIL LIFE SYSTEM RESET PROCEDURES - CARS. GM TECH LINK. *TT (NHTSA ID #10018126, SEPTEMBER 01 2005)
• TSB #050604002 -- WHISTLE NOISE ON LIGHT ACCELERATION. *EH (NHTSA ID #10013475, JANUARY 01 2005)
• TSB #610 -- ENGINE IDLE FLARE WHEN THE CLUTCH IS DEPRESSED. ALSO LOW SPEED ENGINE DECEL STALL WHEN COMING TO A STOP. GM TECH LINK. *TT (NHTSA ID #10015768, OCTOBER 01 2004)
• TSB #030601018 -- NEW CYLINDER BORE LINER REPLACEMENT PROCEDURE. THIS SERVICE BULLETIN REPLACES 030601018A. *EH (NHTSA ID #10012103, JULY 01 2004)
• TSB #040604024 -- POWERTRAIN CONTROL MODULE WILL NOT PROPERLY COMMUNICATE ON BOARD DIAGNOSTIC FREEZE FRAME INFORMATION TO NONTECH2 SERVICE OR TEST EQUIPMENT. *EH (NHTSA ID #10012634, APRIL 01 2004)
• TSB #3114 -- B1327 DIAGNOSTIC MISSING. *SC (NHTSA ID #10009973, JANUARY 01 2004)
• TSB #030601010 -- ENGINE OIL OR COOLANT LEAK. *TT (NHTSA ID #10001282, MARCH 01 2003)

ENGINE AND ENGINE COOLING:ENGINE

• TSB #03-06-01-010 -- ENGINE OIL OR COOLANT LEAK. *TT GM REMINDER. *TT INSTALL NEW LOWER INTAKE MANIFOLD GASKET. UPDATED 7/18/08 *PE (NHTSA ID #10004768, APRIL 01 2008)
• TSB #030604030 -- MULTIPLE DRIVEABILITY SYMPTOMS OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE DUE TO CLOGGED FUEL INJECTORS. *TT (NHTSA ID #10002166, MARCH 01 2007)
• TSB #050604026 -- VEHICLE HESITATES, NO START, LACK OF POWER, LOW FUEL PRESSURE. *TT (NHTSA ID #10017407, MAY 01 2005)
• TSB #0804 -- OIL LIFE SYSTEM RESET PROCEDURES - CARS. *NM (NHTSA ID #10014346, AUGUST 01 2004)
• TSB #00434 -- ENGINE WILL CRANK BUT NOT START, ALSO MAKES NOISE WHILE CRANKING. 2.2 L61 ENGINE. *TT (NHTSA ID #10007528, JANUARY 01 2004)
• TSB #030601022 -- GUIDELINES FOR CYLINDER BORE LINER/PISTON SLEEVE REPLACEMENT ON THE L4 ECOTEC ENGINE. *TT (NHTSA ID #10011117, JANUARY 01 2004)
• TSB #01556 -- ENGINE CRANKS BUT DOES NOT RUN. *TT (NHTSA ID #10005396, JANUARY 01 2004)
• TSB #01353 -- ENGINE MISFIRE DUE TO INJECTOR FRETTING CORROSION. *TT (NHTSA ID #10007937, JANUARY 01 2004)
• TSB #01995 -- REPLACING A 02 OR 03 2.2L L61 WITH A 04 2.2L L61 ENGINE REPLACEMENT.*MR (NHTSA ID #10007055, JANUARY 01 2004)
• TSB #01527 -- A WHISTLE TYPE NOISE COMING FROM THE ENGINE. SIT BULLETIN 1406534. *TT (NHTSA ID #10005464, JANUARY 01 2004)
• TSB #03064 -- ON-BOARD DIAGNOSTIC SYSTEM SOFTWARE UPGRADE - OBD SYSTEM IMPROVEMENTS. *TT (NHTSA ID #10005744, DECEMBER 01 2003)
• TSB #071103 -- THIS VME MESSAGE CONCERNS A CYLINDER BORELINER TOOL NOW AVAILABLE FOR THE L61 2.2 LITER ENGINE. THE TOOL IS REFERENCED IN SERVICE BULLETIN 030601018. THE PURPOSE OF THE TOOL IS TO EXTEND THE TOTAL SERVICE LIFE OF THE BLOCK. *TT (NHTSA ID #10003816, JULY 11 2003)
• TSB #030601018 -- NEW CYLINDER BORE LINER REPLACEMENT PROCEDURE. *TT (NHTSA ID #10002130, JUNE 01 2003)
• TSB #052203 -- COMPLAINTS OF INTERMITTENT VEHICLE SHUTTING OFF WHILE DRIVING WITH NO MULTIPLE CODES SET. THE VEHICLE WOULD IMMEDIATELY RESTART. THE ACTUAL CAUSE OF THIS CONDITION WAS THAT OVER BUMPS THE MASS AND WEIGHT OF THE CUSTOMER'S KEY RING FORCES (NHTSA ID #10003658, MAY 22 2003)
• TSB #09222002 -- NO START STARTER NOISE; NO START CONDITION. FEEDBACK FROM POWERTRAIN ENGINEERING. *TT (NHTSA ID #10009497, OCTOBER 22 2002)
• TSB #01130 -- SUBJECT REGARDING CUSTOMER SATISFACTION CAMPAIGN BULLETIN #01060 - VALVE SPRINGS REPLACEMENT. *TT (NHTSA ID #625447, AUGUST 31 2001)
• TSB #01060 -- SUBJECT REGARDING CUSTOMER SATISFACTION CAMPAIGN VALVE SPRING REPLACEMENT. *JG (NHTSA ID #625083, AUGUST 22 2001)
• TSB #01060 -- SUBJECT REGARDING REPLACEMENT VALVE SPRINGS. *JG (NHTSA ID #625021, JANUARY 01 2001)
• TSB #3709 -- SUPPLEMENT TO ENGINE REPLACEMENT INSTRUCTIONS FOR PART NUMBER 12607031. *TT (NHTSA ID #10019420, no date provided)
• TSB #3433 -- SERVICE ENGINE SOON (SES) LIGHT AND SEVERE ENGINE MISFIRE ON CYLINDERS 1 AND 4 OR CYLINDERS 2 AND 3. *TT UPDATED 08-15-07. *KB (NHTSA ID #10017032, no date provided)
• TSB #3859 -- LOW OIL PRESSURE - INSPECT OIL FILTER FOR DAMAGE. *KB UPDATED 10/18/07. *NJ (NHTSA ID #10020923, no date provided)

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

• TSB #020845002 -- INTERMITTENT STALL, SERVICE ENGINE SOON LIGHT ILLUMINATION AND LOOSE GROUND G103. *TT (NHTSA ID #634680, JULY 01 2005)
• TSB #020604045 -- SUBJECT REGARDING REVISED DTC P0327 - THIS BULLETIN IS BEING ISSUED TO REVISE STEP 3 OF DTC P0327 IN THE ENGINE CONTROLS. NLM (NHTSA ID #634249, AUGUST 01 2002)
• TSB #210602 -- SOME VEHICLES BUILT WITH THE 2.2 LITER OR 3.4 LITER ENGINE MAY HAVE A CUSTOMER COMPLAINT ABOUT INTERMITTENT DRIVABILITY ISSUES, WHICH MAY ALSO INCLUDE A SERVICE ENGINE SOON LIGHT AND OR MORE POWERTRAIN CONTROL MOUDLE DIAGNOSTIC TROUBLE CODE (NHTSA ID #637261, JUNE 21 2002)
• TSB #02020 -- CUSTOMER SATISFACTION PROGRAM - ENGINE CYLINDER BORE LINER. *TT (NHTSA ID #634191, MAY 24 2002)
• TSB #020601014 -- SUBJECT REGARDING REVISED LOWER INTAKE MANIFOLD INSTALLATION. *TT (NHTSA ID #634708, APRIL 01 2002)
• TSB #160102 -- CUSTOMERS MAY COMMENT THAT THE ENGINE LAGS POWER, STALLS, WON'T START OR IS HARD TO START. *TT (NHTSA ID #629703, JANUARY 16 2002)
• TSB #221001 -- SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODES SUCH AS ROUGH RUNNING, MISS FIRES OR A NO START CONDITION. *TT (NHTSA ID #628020, OCTOBER 22 2001)
• TSB #01060A -- INFORMATION REGARDING CUSTOMER SATISFACTION CAMPAIGN REPLACEMENT OF VALVE SPRINGS . *JG (NHTSA ID #624665, AUGUST 28 2001)

ENGINE AND ENGINE COOLING:COOLING SYSTEM

• TSB #071503 -- COOLANT LOSE, EVIDENCE FLUID ON THE GARAGE FLOOR, ETC., OR COOLANT WARNING LIGHT COMING ON. *TT (NHTSA ID #10003789, JULY 15 2003)
• TSB #071003 -- THIS VME MESSAGE IS A WATER PUMP REPLACEMENT DUE TO A KNOWN CAM DRIVELINE. SOME CUSTOMERS MAY QUESTION ABOUT WHINE NOISE COMING FROM THE FRONT ENGINE AREA. *TT (NHTSA ID #10003815, JULY 10 2003)

FUEL SYSTEM, GASOLINE

• TSB #031103 -- COMPLAINTS THAT ARE ROOT CAUSED TO THE FUEL MODULE AND COMPLAINTS OF GAUGE ACCURACY THAT ARE ROOT CAUSED TO THE FUEL LEVEL SENSOR. *TT *JB (NHTSA ID #10001904, MARCH 11 2003)

FUEL SYSTEM, OTHER

• TSB #010604008C -- SOME CUSTOMERS MAY COMMENT ABOUT INACCURATE OR ERRATIC FUEL GAUGE READINGS. *SLC (NHTSA ID #631306, MARCH 01 2002)
• TSB #180202 -- SUBJECT REGARDING PROPER REPAIR FOR FUEL GAUGE INACCURACY COMPLAINTS. *TT (NHTSA ID #629807, FEBRUARY 18 2002)

POWER TRAIN

• TSB #01604 -- 4T40E, 4T45E CHANGE IN APPEARANCE OF FORWARD, SECOND AND REVERSE CLUTCH WAVE PLATE. *TT (NHTSA ID #10007135, JANUARY 01 2004)
• TSB #030730021 -- NEUTRAL FLARE AND/OR RPM FLARE WHILE IN DRIVE, NO 1-2 UPSHIFT, SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODES (DTCS) P1810, DIAGNOSTIC TROUBLE CODE P1815 SET. *TT (NHTSA ID #10002392, MAY 01 2003)
• TSB #020730050 -- ENGINEERING CHANGES TO THE VALVE BODY, PRESSURE REGULATOR VALVE, 2-3 ACCUMULATOR VALVE AND BORE FOR 2002-2003 MODEL YEAR 4T45E TRANSAXLES AND SUBSEQUENT OVERHAUL PROCEDURES WHICH AFFECT 1995-2001 MODEL YEAR TRANSAXLES. *TT (NHTSA ID #10000759, DECEMBER 01 2002)
• TSB #3447 -- 4T40E OR 4T45E WILL NOT SHIFT NO DIAGNOSTIC TROUBLE CODES. *TT (NHTSA ID #10017086, no date provided)

POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/LINKAGE

• TSB #3915 -- CLUTCH PEDAL STAYS TO FLOOR. *TT (NHTSA ID #10019423, no date provided)

POWER TRAIN:MANUAL TRANSMISSION

• TSB #020729001 -- SOME CUSTOMERS MAY COMPLAIN ON A GRINDING OR RATTLE TYPE NOISE COMING FROM THE TRANSMISSION. *SLC (NHTSA ID #631218, FEBRUARY 01 2002)
• TSB #290801 -- INFORMATION ON VEHICLES EXHIBITING MANUAL TRANSMISSION GEAR NOISE. *TT (NHTSA ID #620843, AUGUST 29 2001)

POWER TRAIN:AUTOMATIC TRANSMISSION

• TSB #070730025 -- INFORMATION ON 4T40-E (MN4) AND 4T45-E (MN5) FRONT WHEEL DRIVE AUTOMATIC TRANSMISSION VALVE BODY RECONDITIONING, DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, HARSH SHIFTS, SLIPS, NO DRIVE, NO REVERSE. *NJ (NHTSA ID #10023942, OCTOBER 01 2007)
• TSB #030730012A -- TRANSAXLE OR TRANSMISSION SLIPS, WON'T SHIFT, NO REVERSE, 2ND, 3RD OR OVERDRIVE, ERRATIC SHIFTS. *TT (NHTSA ID #10004722, AUGUST 01 2005)
• TSB #030730021A -- NEUTRAL FLARE AND/OR RPM FLARE WHILE IN DRIVE, NO 1-2 UPSHIFT, SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODES (DTCS) P1810, DIAGNOSTIC TROUBLE CODE P1815 SET. *TT (NHTSA ID #10005579, NOVEMBER 01 2003)
• TSB #01432 -- AUTOMATIC TRANSMISSION POOR ACCELERATION, PERFORMANCE. *TT (NHTSA ID #10004412, JANUARY 01 2003)
• TSB #261001 -- SUBJECT REGARDING HIGHLINE PRESSURE AFTER AN OVERHAUL OF THE TRANSAXLE WHEN USING OVERHAUL KITS. *TT (NHTSA ID #628029, OCTOBER 26 2001)
• TSB #100730024 -- CERTAIN VEHICLES, WITH EITHER THE LN2 OR L61 ENGINES, HAVE SOFTWARE THAT DOES NOT ALLOW THE TECH 2 TO DISPLAY OR CLEAR SHIFT ADAPTS. *TT (NHTSA ID #620833, JULY 01 2001)
• TSB #3669 -- M86/M94 TRANSMISSION INFORMATION TO DISASSEMBLE THIRD FOURTH AND FIFTH GEAR. *AK (NHTSA ID #10019228, no date provided)
• TSB #3253 -- VEHICLE WILL NOT MOVE IN EITHER DIRECTION. TRANSMISSION MAY SHOW OVER FULL. P90 4T40E 4T45E NO MOVEMENT DRIVE OR REVERSE. CONVERTER MAY BE EMPTY OF FLUID. *TT (NHTSA ID #10017096, no date provided)

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

• TSB #022003 -- REPEAT CONDITION OF THE POWERTRAIN CONTROL MODULE (PCM), DIAGNOSTIC TROUBLE CODE (DTC) P0130, WHICH IS PCM DETECTED TO LOOP STATUS WAS OPEN TOO LONG. ENGINEERING WOULD LIKE TO INSPECT ANY VEHICLE BEFORE THE ACTUAL REPAIR HAS BEEN PERFORME (NHTSA ID #10002566, FEBRUARY 20 2003)

POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

• TSB #040202 -- SOME DEALERS MAY NOTICE TRANSMISSION FLUID WEEP OR LEAK FROM THE TRANSMISSION COOLER LINE FITTINGS DURING PREDELIVERY INSPECTION. *TT (NHTSA ID #629747, FEBRUARY 04 2002)

POWER TRAIN:AXLE ASSEMBLY

• TSB #010303 -- INFORMATION USED WHEN SERVICING THE DRIVE AXLE NUT. *TT (NHTSA ID #10002587, JANUARY 03 2003)
• TSB #020730048 -- PRESSURE CONTROL SOLENOID REPLACEMENT FOR 4T65-E, 4T40-E, AND 4T45-E TRANSAXLE/TRANSMISSION.*MR (NHTSA ID #10006166, NOVEMBER 02 2002)

ELECTRICAL SYSTEM

• TSB #3070 -- SERVICE ENGINE SOON LIGHT WITH DIAGNOSTIC TROUBLE CODE P0130, P0134 AND/OR P0135. *TT (NHTSA ID #10009605, JANUARY 01 2004)
• TSB #01758 -- CODE B1327 DIAGNOSTICS MISSING. *MR (NHTSA ID #10006382, JANUARY 01 2004)
• TSB #010845006A -- SUBJECT REGARDING AVAILABILITY OF NEW MICRO 64 ELECTRICAL TERMINALS FOR WIRING REPAIRS. *TT (NHTSA ID #632312, FEBRUARY 01 2002)

ELECTRICAL SYSTEM:WIRING

• TSB #01740 -- CROSS INJECTOR WIRES CAUSING MISFIRE AT STEADY STATE SPEED AND RPM, MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED, AND A P0300 SET. SIT BULLETIN 1460291. *TT (NHTSA ID #10006270, JANUARY 01 2004)

ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD

• TSB #3648 -- HESITATION ON ACCELERATION AFTER INTERNAL ENGINE REPAIRS - CHECK INJECTOR HARNESS ORIENTATION. *TT (NHTSA ID #10018915, no date provided)

ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS

• TSB #3082 -- BLOWN HTR A/C FUSE 10 AMP WITHOUT U2K. *SC (NHTSA ID #10010221, JANUARY 01 2004)

ELECTRICAL SYSTEM:IGNITION

• TSB #010849020 -- SUBJECT REGARDING REVISED IGNITION LOCK CYLINDER OR IGNITION SWITCH ASSEMBLY REPLACEMENT. *SLC (NHTSA ID #631899, DECEMBER 01 2001)

ELECTRICAL SYSTEM:IGNITION:MODULE

• TSB #0208116001 -- SUBJECT REGARDING INTERMITTENT COMMUNICATION OR SERIAL DATA DIAGNOSTIC TROUBLE CODES STORED IN HISTORY. *SLC (NHTSA ID #631229, JANUARY 01 2002)
• TSB #111201 -- SUBJECT REGARDING VEHICLES WITH AUTOMATIC TRANSMISSIONS SETTING DIAGNOSTIC TROUBLE CODE P0716, 717, INPUT SPEED SENSOR CODES. *TT (NHTSA ID #629615, DECEMBER 11 2001)

EXTERIOR LIGHTING

• TSB #04098 -- UPCOMING SPECIAL POLICY ADJUSTMENT PROGRAM 04098. TURN SIGNALS/HAZARD WARNING FLASHERS. *TT (NHTSA ID #10012087, JANUARY 01 2006)

VISIBILITY:WINDSHIELD

• TSB #020864014 -- SOME CUSTOMERS MAY COMMENT THAT THE OUTER SURFACE GLASS ON ONE OR MORE OF THE VEHICLE'S DOOR IS SCRATCHED. *TT (NHTSA ID #634559, MAY 01 2002)
• TSB #010864012B -- SOME CUSTOMERS MAY COMMENT THAT THE DOOR GLASS IS OUT OF CHANNEL. *TT (NHTSA ID #634827, APRIL 01 2002)
• TSB #010864018A -- SOME CUSTOMERS MAY COMMENT THAT THE FRONT DOOR WINDOW GLASS WON'T ROLL UP OR IS OUT OF THE CHANNEL. *TT (NHTSA ID #628824, JANUARY 01 2002)
• TSB #010864018 -- INFORMATION REGARDING FRONT DOOR WINDOW GLASS WON'T ROLL UP OR OUT OF CHANNEL. *YH (NHTSA ID #627482, NOVEMBER 01 2001)
• TSB #280901 -- SUBJECT REGARDING WATER LEAKING INTO THE PASSENGER SIDE FOOT WELL AREA FOROM THE HVAC INTAKE. *JG (NHTSA ID #626557, OCTOBER 28 2001)

VISIBILITY:GLASS, SIDE/REAR

• TSB #010864012D -- DOOR GLASS SASH OUT OF RUN CHANNEL. *TT UPDATE. *TT (NHTSA ID #10004355, MARCH 01 2005)
• TSB #010864018D -- FRONT DOOR WINDOW GLASS WON'T ROLL UP OR OUT OF CHANNEL. *TT (NHTSA ID #10004753, OCTOBER 01 2003)
• TSB #010864018B -- FRONT DOOR WINDOW GLASS WON'T ROLL UP OR OUT OF CHANNEL. *TT (NHTSA ID #10001133, FEBRUARY 01 2003)
• TSB #010864012C -- DOOR GLASS SASH OUT OF RUN CHANNEL. *TT (NHTSA ID #10001131, FEBRUARY 01 2003)
• TSB #11082002 -- THE DOOR WINDOW GLASS WILL NOT ROLL UP OR IT IS OUT OF THE CHANNEL. *TT (NHTSA ID #10008618, NOVEMBER 08 2002)
• TSB #050602 -- CUSTOMERS MAY COMMENT THAT ONE OR MORE DOOR GLASSES ARE SCRATCHED. *TT (NHTSA ID #637197, JUNE 05 2002)

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

• TSB #040864020 -- FRONT DOOR POWER WINDOW INOPERATIVE. *TT (NHTSA ID #10012744, OCTOBER 01 2004)
• TSB #020864023A -- POWER WINDOW INOPERATIVE. *TT (NHTSA ID #10004359, AUGUST 01 2003)
• TSB #030803 -- UNNECESSARY REPLACEMENT OF DOOR WINDOW REGULATORS. *TT *JB (NHTSA ID #10001887, MARCH 08 2003)
• TSB #020864023 -- POWER WINDOW INOPERATIVE. *TT (NHTSA ID #10000756, DECEMBER 01 2002)

VISIBILITY:SUN ROOF ASSEMBLY

• TSB #030867009 -- SUNROOF WILL NOT OPEN OR CLOSE COMPLETELY DUE TO THE SUNROOF MOTOR. *TT (NHTSA ID #10005595, MARCH 01 2004)
• TSB #02042 -- SUNROOF NOT OPERATING PROPERLY. *MR (NHTSA ID #10006913, JANUARY 01 2004)
• TSB #100903 -- JAMMED SUNROOF THAT WILL NOT OPEN OR CLOSE COMPLETELY REVISITED. GM VOICEMAIL LOG. *TT (NHTSA ID #10004987, OCTOBER 09 2003)
• TSB #030867004 -- PARTS AVAILABILITY FOR SUNROOF REPAIRS. *TT (NHTSA ID #10002878, JUNE 01 2003)

VISIBILITY:DEFROSTER/DEFOGGER SYSTEM

• TSB #020139004 -- INFORMATION REGARDING NEW PAG OIL RELEASED FOR CERTAIN VEHICLES INCLUDING ALL 2003 PASSENGER CARS AND TRUCKS. *TT (NHTSA ID #634884, AUGUST 01 2002)

VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:BLOWER

• TSB #01262004 -- THIS IS A PRODUCT SERVICE MESSAGE REGARDING THE NEW PART NUMBER FOR THE HEATER BLOWER RESISTOR FOR CUSTOMER CONCERN OF THE HEATER MOTOR NOT BLOWING ON ONE UP TO ALL SPEEDS. *TT (NHTSA ID #10012980, JANUARY 26 2004)

VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:CONTROLS/WIRING

• TSB #030603 -- LIGHT ON THE RECIRCULATION BUTTON GOES OFF INTERMITTENTLY OR THE LIGHT ON THE REAR WINDOW DEFROSTER BUTTON GOES OFF. *TT *JB (NHTSA ID #10001884, MARCH 06 2003)

SEAT BELTS

• TSB #040850011 -- REPAIRING NAPPED SEAT FABRIC. *EH (NHTSA ID #10012127, JULY 01 2004)

STRUCTURE:BODY

• TSB #030867005 -- WATER ON FRONT FLOOR. *TT (NHTSA ID #10012580, JULY 01 2003)
• TSB #030866002 -- WIND NOISE HEARD FROM REAR OF VEHICLE. *TT (NHTSA ID #10000945, JANUARY 01 2003)
• TSB #020866005 -- SOME OWNERS MAY COMMENT THAT THE MOLDING ALONG THE REAR (TRUNK) COMPARTMENT OPENING AT THE STRIKER IS LOOSE OR BROKEN. *TT (NHTSA ID #634661, MAY 01 2002)
• TSB #171201 -- WATER LEAK ISSUES. *TT (NHTSA ID #629631, DECEMBER 17 2001)

STRUCTURE:BODY:DOOR

• TSB #010864020C -- A CREAK OR SQUEAK NOISE WHEN OPENING OR CLOSING ONE OF MORE DOORS. *TT THIS BULLETIN REPLACES PREVIOUS BULLETIN 01-08-64-020 DATED 12/01/2001. *TT THIS BULLETIN REPLACES 01-08-64-020B. *TT (NHTSA ID #628894, OCTOBER 01 2004)
• TSB #250702 -- SOME CUSTOMERS MAY COMMENT THAT THE EXTERIOR DOOR HANDLE IS INOPERATIVE ON CERTAIN VEHICLES. *TT (NHTSA ID #637316, JULY 25 2002)
• TSB #071101 -- SOME CUSTOMERS MAY COMMENT OF A CREAK OR SQUEAK NOISE WHEN OPENING OR CLOSING ONE OR MORE OF THE DOORS ON THEIR VEHICLE. *TT (NHTSA ID #628100, NOVEMBER 07 2001)

STRUCTURE:BODY:TRUNK LID

• TSB #020866005A -- SOME ONWERS MAY COMMENT THAT THE MOLDING ALONG THE REAR (TRUNK) COMPARTMENT OPENING AT THE STRIKER IS LOOSE OR BROKEN. *TT (NHTSA ID #634317, AUGUST 01 2002)
• TSB #170602 -- SOME CUSTOMERS MAY COMMENT THAT THE MOLDING ALONG THE REAR TRUNK COMPARTMENT OPENING AT THE STRIKER IS LOOSE AND / OR BROKEN. *TT (NHTSA ID #637229, JUNE 17 2002)
• TSB #020858004 -- SOME CUSTOMERS MAY COMMENTON AN AIR RUSH / MOAN TYPE NOISE FROM THE REAR COMPARTMENT LID AREA OF THE VEHICLE. *TT (NHTSA ID #634508, JUNE 01 2002)
• TSB #051702 -- SOME CUSTOMERS MAY COMMENT THAT THE REAR DECK LID WILL NOT STAY OPEN. *TT (NHTSA ID #636694, MAY 17 2002)

STRUCTURE:BODY:ROOF AND PILLARS

• TSB #052303 -- AFTER A HEAVY RAIN MOISTURE IS PRESENT AROUND THE A PILLAR FRONT COWL OR FRONT FLOOR AREA ON VEHICLES BUILT WITH A SUNROOF. *TT (NHTSA ID #10003663, MAY 23 2003)

VEHICLE SPEED CONTROL

• TSB #3115 -- HIGH IDLE WHEN CLUTCH IS DEPRESSED. *SC (NHTSA ID #10010198, JANUARY 01 2004)

EQUIPMENT

• TSB #052903 -- CLARIFICATION OF SERVICE BULLETIN 02-08-44-012. CERTAIN STEPS IN THE SERVICE BULLETIN TO DISABLE OR ENABLE THE REMOTE KEYLESS ENTRY RADIO PERSONALIZATION FEATURE HAS BEEN DELETED IN THE TECH 2 SOFTWARE. CONCERN WILL BE UPDATED IN JULY REL (NHTSA ID #10003676, MAY 29 2003)
• TSB #09272002 -- INFORMATION ON THE ONSTAR SYSTEM FOR TECHNICIANS. *MJ (NHTSA ID #10008631, SEPTEMBER 27 2002)
• TSB #020864015 -- INFORMATION ON NEW STYLE WATER DEFLECTOR. *TT (NHTSA ID #634676, JUNE 01 2002)

EQUIPMENT:ELECTRICAL

• TSB #010849016 -- VEHICLES MAY EXPERIENCE AN INOPERATIVE CIGARETTE LIGHTER. *SLC (NHTSA ID #631820, NOVEMBER 01 2001)

EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

• TSB #020844001 -- SOME CUSTOMERS MAY COMMENT ON POOR RADIO RECEPTION. *TT (NHTSA ID #634332, JULY 01 2002)
• TSB #051402 -- CUSTOMERS MAY COMMENT ABOUT POOR RADIO RECEPTION. *TT (NHTSA ID #636675, MAY 14 2002)
• TSB #042202 -- CUSTOMERS MAY COMMENT THAT THE RADIO COMES ON WITH THE IGNITION SWITCH OFF AFTER INSTALLATION OF AN ELECTRONIC AFTER FLOW FAN MODULE. *TT (NHTSA ID #636570, APRIL 22 2002)

EQUIPMENT:ELECTRICAL:AIR CONDITIONER

• TSB #040602 -- SOME CUSTOMERS MAY COMMENT THAT THE BLOWER MOTOR IS INOPERATIVE. *TT (NHTSA ID #637181, JUNE 04 2002)

UNKNOWN OR OTHER

• TSB #000089008E -- SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND. THIS BULLETIN PROVIDES INFORMATION REGARDING RECREATIONAL (DINGHY) TOWING FOR CERTAIN VEHICLES INCLUDING 1988-2004 CHEVROLET AND GMC LI (NHTSA ID #10005527, OCTOBER 01 2005)
• TSB #020730022B -- SERVICE ENGINE SOON LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0716 AND / OR P0717, P0730, P0753, P0758, P1860, P1887 OR OTHER MISCELLANEOUS TRANSMISSION TROUBLE CODES SET. *TT (NHTSA ID #10004755, OCTOBER 01 2003)
• TSB #000089008B -- SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND. THIS BULLETIN PROVIDES INFORMATION REGARDING RECREATIONAL (DINGHY) TOWING FOR CERTAIN VEHICLES INCLUDING 1988-2004 CHEVROLET AND GMC LI (NHTSA ID #10004278, SEPTEMBER 01 2003)
• TSB #020844012A -- ENABLE OR DISABLE REMOTE KEYLESS ENTRY (RKE) RADIO PERSONALIZATION FEATURE. *TT (NHTSA ID #10002841, JUNE 01 2003)
• TSB #020730022A -- SERVICE ENGINE SOON LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0716 AND / OR P0717, P0730, P0753, P0758, P1860, P1887 OR OTHER MISCELLANEOUS TRANSMISSION TROUBLE CODES SET. *TT (NHTSA ID #634931, SEPTEMBER 01 2002)
• TSB #020604042 -- SUBJECT REGARDING SERVICE ENGINE SOON (SES) LAMP ILLUMINATED, DTC P0440 SET (REPLACE EVAP PURGE LINE AND ROTATE BRAKE BOOSTER VACUUM HOSE CLAMP). NLM (NHTSA ID #634279, AUGUST 01 2002)
• TSB #020844012 -- REMOTE KEYLESS ENTRY KEY FOB RADIO PERSONALIZATION FEATURE ENABLED (TURNED ON) OR DISABLED (TURNED OFF). *TT (NHTSA ID #634310, AUGUST 01 2002)
• TSB #100602 -- INFORMATION REGARDING THE JUNE EDITION OF EMERGING ISSUES FOR VARIOUS MODELS. *TT (NHTSA ID #637216, JUNE 10 2002)
• TSB #020603005 -- SOME CUSTOMERS MAY COMMENT THAT THE SERVICE ENGINE SOON LIGHT IS ON. WITH STORED CODES P0112, P0113, P1111 OR P1112. *TT (NHTSA ID #634780, JUNE 01 2002)
• TSB #051402 -- SOME CUSTOMERS MAY COMMENT ABOUT A SERVICE ENGINE SOON LIGHT. *TT (NHTSA ID #636677, MAY 14 2002)
• TSB #020849002 -- SOME CUSTOMERS MAY COMMENT ON A DASH RATTLE / ITCHING TYPE NOISE FROM THE INSTRUMENT PANEL / GLOVE BOX AREA WHILE DRIVING. *TT (NHTSA ID #634653, MAY 01 2002)
• TSB #020730002 -- SOME CUSTOMERS MAY COMMENT THAT THE SERVICE ENGINE SOON (SES) INDICATOR IS ILLUMINATED AND THAT WHILE THE LIGHT IS ILLUMINATED, TRANSMISSION SHIFTS ARE EXTREMELY HARSH. *TT (NHTSA ID #635008, MAY 01 2002)
• TSB #280202 -- SOME CUSTOMERS MAY COMMENT THAT THEY WOULD LIKE THE RADIO KEY FOB PERSONALIZATION TURNED ON OR OFF. *TT (NHTSA ID #629851, FEBRUARY 28 2002)
• TSB #270202 -- SOME CUSTOMERS MAY COMMENT OF A MALFUNCTION INDICATOR LIGHT ILLUMINATED WITH STORED DIAGNOSTIC TROUBLE CODES P0112, P0113, P1111 OR P1112. *TT (NHTSA ID #629836, FEBRUARY 27 2002)
• TSB #040202 -- SOME CUSTOMERS MAY COMMENT ABOUT AN INTERMITTENT SERVICE VEHICLE SOON LIGHT AND/OR AN ELECTRONIC TRACTION CONTROL LIGHT OFF WHICH MAY ILLUMINATE AFTER STARTING THE VEHICLE WITH THE ENGINE RUNNING. *TT (NHTSA ID #629749, FEBRUARY 04 2002)
• TSB #000604037A -- SOME CUSTOMERS MAY COMPLAIN THAT THE SERVICE ENGINE SOON (SES) INDICATOR IS ILLUMINATED WITH HARSH TRANSMISSION SHIFTS. *TT (NHTSA ID #628862, NOVEMBER 01 2001)
• TSB #000089008A -- SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND. THIS BULLETIN PROVIDES INFORMATION REGARDING RECREATIONAL (DINGHY) TOWING FOR CERTAIN VEHICLES INCLUDING THE 1996 THROUGH 2000 TOYOTA C (NHTSA ID #622945, MAY 01 2001)
• TSB #4014 -- PARTS UPDATE - TIMING CHAIN TENSIONER DESIGN CHANGE. *KB (NHTSA ID #10021074, no date provided)