Print this page


pretty bad
Typical Repair Cost:
Average Mileage:
88,667 miles
Total Complaints:
3 complaints

Most Common Solutions:

  1. not sure (1 reports)
  2. replace fuel pump (1 reports)
  3. we must repair the thing to measure the fuel pressure (1 reports)
1999 Chevrolet Express fuel system problems

fuel system problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 1999 Chevrolet Express:

Unsubscribe any time. We don't sell/share your email.

1999 Chevrolet Express Owner Comments

problem #3

May 042009

Express Express 3500 V8

  • Automatic transmission
  • 100,000 miles


we bought a Van Chevrolet 1999 V8 express in Belgium and the fuel pump was broke.the garage put another fuel pump in it and after that, we had a lot of black smoke coming out the exhaust.the car went back to another garage and they said it was a wrong fuel pump they put inside because the fuel pump give double more pressure than it is admit.they said also that the object who measure the fuel pressure was broke because of the wrong fuel pump.first they said to put the wright fuel pump and then the problem of the smoke will be they said that we must arrange first the object that measure the fuel pressure and then the fuel Belgium they sell VAN'S but when there is a problem nobody knows anything we went to 3 garages and nobody can help us.i will also ask if the right fuel pump is inside, the object to measure the fuel pressure will not arrange himself or is it necessary to repair both. i hope you can help us my excuses for my bad English i will thank you already. my e-mail address is

- , Antwerp, Antwerp, Belgium

problem #2

Mar 152007

(reported on)

Express 3.5L V8

  • Automatic transmission
  • 92,000 miles

As an addendum to the last post, I forgot that I also had to replace the fuel pump for $400.00

- , Toledo, OH, USA

problem #1

Feb 262007

(reported on)

Express 1500 350

  • Automatic transmission
  • 74,000 miles

the fuel pump went out in march 2006 and i replaced it. it went out again in September 2006. it went out in feb. 2007 and i also replaced the fuel pump relay and now three weeks later it's out again. It has gone out 4 times in less than a year! What could be causing the fuel pump to keep going out??

- , Dallas, TX, Pacific Islands (US)

Search for these popular complaint phrases...

Not what you are looking for?