Print this page


hardly worth mentioning
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
153,600 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2002 Chevrolet Silverado 1500 fuel system problems

fuel system problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2002 Chevrolet Silverado 1500:

Unsubscribe any time. We don't sell/share your email.

2002 Chevrolet Silverado 1500 Owner Comments

problem #5

Sep 242013

Silverado 1500 8-cyl

  • 108,000 miles


Hi this is the second set of the fuel injector on this diesel engine, I talk to the different mechanic on dealers an privet shops and ask what is this problem and say is because the fuel, the used, how you drive, etc but no body say what is the reason, my problem is this injector set is not like replace like a set the spark plugs on gas engine is much money $5600, and I not the only person, I check online many trucks of this get this problems, please help as, the company make this truck whit this problems and people like me used for work and is not fear.

- Bergenfield, NJ, USA

problem #4

Feb 152010

Silverado 1500

  • 170,000 miles
The contact owns a 2002 Chevrolet Silverado. While driving at 65 mph, the contact noticed that the vehicle would not accelerate forward. The vehicle was taken to the dealership where the contact was informed that the fuel injectors needed to be replaced. Five years prior to this failure, the contact had the fuel injectors replaced. The failure mileage was approximately 170,000. The current mileage was approximately 173,000.

- Macomb, MI, USA

problem #3

Mar 022006

Silverado 1500 8-cyl

  • Automatic transmission
  • 125,000 miles
: the contact stated while driving at no particular speed, the engine ran rough. The vehicle was taken to an independent repair shop for inspection and the mechanic determined the fuel injectors were blocked. The injectors were changed; however, the problem persisted. The vehicle was taken back to the repair shop where the injectors were cleaned. Again, the problem was apparent and the vehicle was taken back to the mechanic. During the last inspection, the mechanic determined the fuel lines were corroded due to road salt corrosion. The fuel lines were replaced and the problem was corrected.

- Princess Anne, MD, USA

problem #2

Dec 102004

Silverado 1500 4WD 8-cyl Diesel

  • Automatic transmission
  • miles
When taken for inspection, the dealer informed the consumer that the vehicle needed new brakes and rotors. The rotors were slightly pulling away from the wheel. Consumer never had any signs of a safety defect prior to this. The cause was undetermined. The consumer stated when he placed the vehicle in park and turned off the engine, the automatic doors locks failed. When the consumer attempted to gain speed, the vehicle stalled, the dealer stated the injector was bad.

- Birch Run, MI, USA

problem #1

May 232003

(reported on)

Silverado 1500

  • 365,000 miles
While driving on two separate occasions the vehicles fuel injectors failed and caused a drastic loss of power. The first failure was at 36,500 miles and the second failure was at 39,700 miles.

- Lorton, VA, USA

Not what you are looking for?