Unable to open rear left sliding door, lock actuator is failed. Burning smell from left sliding door 1 year ago. Right sliding door make buzzing noice from the lock actuator area, sometimes unable to open sliding door.

- Southampton, PA, USA

Both sliding door actuators are malfunctioning. The door locks have to be manually locked and unlock. Searching the internet, I found that if the door is not lock, the door can disengage and fly open. This has not occurred and we keep the doors locked. I was told by the dealership that because my 2017 Dodge Grand Caravan was manufactured in Canada that the RT warranty does not pertain to my vehicle. This is a very expensive repair. Since both of my doors are affected, it could cost around $1,300 to repair both. If this was an isolated incident, I could understand having to pay for the repair. However, it seems to be a common problem. The part is defective and the cost should not be bared by the consumer.

- Greensboro, NC, USA

Car randomly stalled out without warning or signs of issues. We just purchased this used from Automax Hyundai. It has happened a total of 4 times this week.

- Edmond, OK, USA

door lock actuator failed - driver side sliding door - door stuck closed will not open

- Portage, MI, USA

2017 Dodge Grand Caravan. Check engine light reading code P0302 (cylinder 2 misfire). Mechanic replaced spark plugs and coils, but car is still throwing same code. This is appears to also be an issue with a recall on other year models of Dodge Grand Caravans. Mechanics unsure what to do as components have already been replaced and engine light comes back on after clearing code repeatedly.

- Fenton, MO, USA

When locking and unlocking the doors or using the automatic lock when the car is in drive, the driver side sliding door either will not unlock at all (even manually) or when it automatically locks and unlocks it makes an aggressive vibration sound and does not work. I have to go through the passenger side sliding door to take the car seat out of the van. If it were an emergency and I needed to open the rear door it would cause a serious safety issue

- Citrus Springs, FL, USA

The left (driver's side) passenger sliding door will not open. The lock actuator seems to be frozen. It is available for inspection as needed. Safety concern is the limited egress from the vehicle. The problem has been confirmed by a dealer and is persistent. No warnings of any kind were present prior to the failure. The failure appeared in August of 2023. An appeal to MOPAR for a repair has been denied, in spite of the fact that other vehicles have had similar problems.

- Burnside, IL, USA

Transmission Went out Last year I just found out I could report it this seems to be a common issue with these Vans and would be nice to get some help with repair costs as I was told around 6k to repair. Also the flywheel has a crack in it I ordered a new oem replacement hoping the transmission shop can replace that while they do the repairs.

- South Bend, IN, USA

The passenger's side sliding door lock switch is stuck in the locked position, so I can't open that door. There is a huge safety issue because the passengers can't open that door to exit, in case of an emergency. The car manufacturer issued a recall (Mopar X98) for this very same issue but it didn't include my car serial number, because my car is newer by about a month. So, they don't want to honor the recall on my car.

- Spanish Fork, UT, USA

On 7/2/2023 at approximately 12:04pm my family and I were driving home from church. My husband was driving and the driver's side head rest exploded, punching him in the back of the head while driving. We were very fortunate and no vehicle accident occurred. We were on the on ramp of Judge Tanner Blvd. in Covington, LA traveling to get onto Hwy 190 going north. First thing Monday morning on 7/3/2023, I called Dodge Corporation to report the incident and was given a case number (Case #86604720) and was told there was no recall on the head rest but to go to the dealership immediately. I brought my van to Rainbow Chrysler Dodge Jeep at 301 River Highland Blvd, Covington, LA 70433. At the dealership I was told this is a "common occurrence" and was covered under the extended warranty. I asked since it is a "common occurrence" why was it not recalled. I was told it is not deemed a safety hazard by Dodge. Seriously" Being punched in the back of the head while driving is not a safety concern by Dodge" My husband did have a headache for the rest of the day but his situation could have been much worse plus we could have been in an accident endangering our entire family (myself and 3 kids). I asked if I could get the passenger seat head rest replaced too and was told it's not covered unless it explodes. A recall needs to be made on these headrest before a fatal accident occurs.

- Covington, LA, USA

Sliding door lock actuator failed to open door. I noticed a buzzing sound when opening recently and now it is shut down, it cannot open. I provided these two reports for your reference, and I need you to help me for Dodge to repair my vehicle. I filed complaint with the Texas Office of the Attorney General.

- Converse, TX, USA

The rear driver side sliding door locks seized and the door can not be unlocked via the power locks nor can it be unlocked manually. The door is stuck shut. This issue occured under 60k miles and the door is no longer functional at all. The same issue occured 3 years prior on the passenger side and it was repaired under warranty. The vehicle is no longer under warranty for the second failure. I owned a 2012 Dodge caravan previously and the exact same issue occured on both sliding door locks about a year apart from each other. The repair bill for each was 1,000 dollars to replace a defective actuator. The door locks actuators on the dodge Grand caravan are defective and present a risk of siezing at any time, trapping rear passengers in the vehicle. There is no known way to unlock the doors either manually or electronically outside of a 1,000 dollar repair once the issue occurs. There was no audible or visual warning prior to the occurance in all four cases. The locks just suddenly seized. Google search reveals the issue happens at a high frequency with the dodge Grand caravan. Age of vehicle does not seem to be a determing factor.

- Marlton, NJ, USA

The rear drivers sliding door would not unlock or open, both manually, or with the electronics. If I were carrying passengers, they would have not been able to exit the vehicle through that door (except the window). The actuator was bad, and I ended up having to take it to the dealer to have it repaired. This is a known issue with the 2017 Dodge Grand Caravan RT. I have a 2017 Dodge Grand Caravan XLT (better trim package/enhancements) and yet, this was not covered under the NHTSA "Extended Warranty" for this van. My van has less than 70 miles on it, and is in great condition with no accidents. The door on the van had the "chattering" noise described, and occassionally not close. This is similar to other Dodge owner experiences. I find it hard to believe that my Van isn't covered under this warranty, and so it cost me over $1100 for the repair. I would like to be reimbursed for this issue and am attaching my invoice from the dealer as proof.

- Woodbridge, VA, USA

My rear sliding back van door stopped working on 4/18/2023. It switched to the locked position and cannot be opened manual or by any of the buttons on the van. There was a recall for this but for some reason my van was not included. The dealer said to have the recall attached to my vin so the issue can be fixed. It is a safety problem because I have 4 young kids in car seats that ride in the back and if there-??s an emergency it is not easy to get to them or get them out.

- Thomasville, NC, USA

Driver's side door is stuck and locked shut. This puts my precious cargo, my children, at risk of having to exit the vehicle on a potentially more dangerous side with traffic. In the event of an accident this door locked shut can't be used to escape the vehicle if need be. No warning lights. Online this appears to be a very common issue in Chrysler/Dodge vans.

- Perham, MN, USA

About 7 months ago the drivers side rear door would not open, after about 2 months I took my Van to Bryden's dealer in Beloit WI. The people in the repair area, said it would cost $800 or more to repair. I could not afford that. So the door still won't open, Family came to town and wanted me to drive them around, which I refused saying with the sliding door not working, that could be dangerous. Well today the passengers rear sliding door quit opening, so now anybody in the back would be in real danger if the Van got in an accident. I guess I will take the van back to the dealer and ask them to please fix it free of charge because of the danger it causes, I could use some help from you, to see that this van doors get repaired, thank you.Mike

- Rockton, IL, USA

Buzzing sound when passenger side sliding door should unlock after removing key from dash (actuator failed/failing), door stays locked. The vehicle was not taken to a dealer to be inspected. The manufacturer was not informed of this common failure.

- Grand Rapids, MI, USA

Sliding door power lock actuator failure. A buzzing sound is heard when locking and unlocking the doors of the vehicle. The locking mechanism of the vehicle is failing to properly lock and unlock the rear sliding doors. A nhtsa bulletin (attached) has already been issued for this issue covering certian 2015 to 2017 Dodge Grand Caravans. My vehicle is a 2017 model with the affected door lock actuators. Upon contacting FCA I was informed my vehicle does not show this extended warranty covering this defect.

- Grand Ledge, MI, USA

Driver side back sliding door stuck in lock position, does not open automatically or manually

- Omro, WI, USA

The passenger side sliding door lock is stuck in the unlock position, so I can't lock the door. The driver side sliding door lock is stuck in the locked position, so I cannot open that door. Both locks cannot be changed manually. In case of emergency a passenger would be locked in the car. Especially a child in a car seat. With the door that is stuck in the unlock position, this invites theft. I am seeing hundreds of complaints online with owners of Chrysler and Dodge Van's 2013 through 2018 experiencing the same issues. Why hasn't there been a recall on this safety issue?

- Dyer, IN, USA