This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
The contact owns a 2018 Ford Edge. The contact stated while driving at an undisclosed speed, the vehicle was erratically shaking, and the check engine warning light was illuminated. The vehicle was driven to the shoulder of the roadway. The contact checked the coolant level, and the coolant lever was low. The coolant reservoir was refilled. The vehicle was driven to the dealer where it was diagnosed with a coolant leak and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact was informed that the repair was not covered under warranty. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 59,000.
2018 Ford Edge 2.0 Ecoboost engine misfire in cylinder 2 (code P-0302 and Smoke from tailpipe. After replacing coil assembly and then spark plugs engine still runs rough. Looking in internet I discovered a Ford TSB 22-2229. Which clearly admits Ford knowledge of said -??design flaw-?? which can cease the engine. Ford should be held liable and fix ALL vehicles effected. My car has 55,700 miles on it. Ford is covering engine block cost and charging me the labor costs in excess of $4,200..
The check engine light came on. Took the car for service. The mechanic did many diagnostic tests and discovered coolant leaking into the cylinder. Advised this caused engine failure and is unsafe. The engine must be replaced. The manufacturer is aware of this problem and the unsafe driving conditions it causes. They have issued a technical service bulletin but not a recall.
Check engine light displayed despite the fact that the car seemed to be running fine. I took the car to a repair shop and then to Ford Service who documented the diagnostic code P0302 Misfire4 on Cylinder #2. They did a pressure test. and found coolantintrusion on cylinder #2. The recommended repair was to replace the engine at a cost of $8700. My Ford EDGE has only 61,000 miles on it. I have found the following information on this car's engine indicating this was a known problem. I purchased this car < 2 yrs ago. Prior owner was not aware of any notification from Ford. The 2018 Ford Edge, particularly those with the 2.0 EcoBoost engine, are known for a design flaw that can cause coolant intrusion into the engine cylinders. This issue can lead to significant engine damage and potentially require a full engine replacement. Ford has addressed this with a recall and customer satisfaction program. Here's a more detailed explanation: Design Flaw: A design flaw in the 2.0 EcoBoost engine can cause coolant to leak into the engine's cylinders. Consequences: This coolant intrusion can lead to overheating, engine damage, and potentially requires a full engine replacement. Ford's Response: Ford has issued a recall (21N12 customer satisfaction program) and a TSB (Technical Service Bulletin) to address this issue, offering a one-time free fix. Symptoms: Signs of coolant intrusion can include low coolant levels, overheating, rough idle, white exhaust, and possibly a "milkshake" appearance on the underside of the oil cap. Diagnosis: Ford has a specific diagnostic procedure for identifying coolant intrusion, involving pressure testing and inspecting the cylinders. Repair: The primary fix is a long block replacement, which includes replacing the engine.
The contact owns a 2018 Ford Edge. The contact stated while driving at an undisclosed speed, the vehicle unexpectedly jerked with the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that there were metal shavings inside the torque converter, which caused the transmission to fail. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 79,000.
- Topeka, KS, USA
Search CarComplaints.com for these popular complaint phrases...
My vehicle has 47K miles on it as the vehicle sat in the garage for 2 years ( 2019/2020) during COVID, it was never used. Recently as of Jan, Feb 2025, Slowly the car started to vibrate when starting the engine and the check engine came on. Every start in the morning or between trips, the engine would vibrate significantly, having the passengers inside (including kids) get worried about what is going on!. Also, an odd smell of burning in the exhaust, as though something other than fuel was being burnt. Took it to the dealership and they confirmed, an coolant intrusion. I checked online, to my surprise, I found everywhere that a lot of customers are having this coolant intrusion into the engine on the Ecoboost Engine and there has also been several class action lawsuit against this coolant intrusion into the engine. The Ford dealership mentioned, it would cost 10K to replace an engine and that is the only solution. With the powertrain warranty being within 60K miles, I am not qualified for the warranty as it is more than 5 years old as per Ford dealership. I am worried, that it could be very dangerous, as the engine could catch fire, if left untreated and I hope Ford acknowledge this known issue and not have their customers drive this faulty engine to end up into any disastrous issue with engine fires!!.
The contact owns a 2018 Ford Edge. The contact stated while driving 55 MPH, the vehicle failed to respond as needed. The check engine warning light was illuminated. The contact stated that coolant was leaking into the cylinder and head gasket. The contact was informed that the engine needed to be replaced. The vehicle was then taken to a dealer and was diagnosed with engine failure. The vehicle was then taken to an independent mechanic to be diagnosed, and the contact was informed that the engine needed to be replaced. The vehicle was only able to be driven for short distances. The vehicle was driven to the dealer and the independent mechanic who were nearby. The vehicle was repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 70,000.
The contact owns a 2018 Ford Edge. The contact stated that while driving approximately 65 MPH, the blinking check engine warning light activated along with the message "Engine Coolant Temperature High". The contact stated that after parking the vehicle, the vehicle was towed to the local mechanic and was later towed to the local dealer, who diagnosed the vehicle and determined that the coolant had mixed with the engine oil, causing severe damages to the engine. The contact was advised that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure and informed that the vehicle was not covered under the Extended Warranty coverage for the failure. The failure mileage was 81,000.
The contact owns a 2018 Ford Edge. The contact stated that while driving at approximately 35 MPH, the check engine warning light illuminated. The vehicle was taken back to the residence. The vehicle was not diagnosed or repaired. The contact contacted an independent mechanic and was informed that, based on the symptoms, the vehicle might have a blown head gasket. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 87,000.
The contact owns a 2018 Ford Edge. The contact stated that while driving on several occasions at various speeds, the check engine warning light intermittently illuminated. The contact stated that on one occasion the warning light illuminated and remained illuminated. Additionally, the contact stated that on several occasions, the temperature gauge warning light illuminated. The vehicle was taken to a dealer where it was diagnosed that there was a crack in the engine block and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 125,000.
Check engine light came on. Took to the Ford dealer workshop, they checked and found nothing wrong with the engine. Check engine light came on again and this time the car jerks when it tries to accelerate. Could not go more 40mh due to the jerky motion. Took it back to the shop, they said coolant intrusion. They said it is going to need new engine because there is water/coolant intrusion. New engine estimate approximately $9000. Same dealership that we have been going to for maintenance, not sure why they did not see this from previous visits. I have seen complaints for same issue on this 2018 Edge, Ford needs to acknowledge that this is an issue.
At approximately 80K miles started to smell the odor of burning antifreeze. Was told new engine was needed due to water intrusion into engine. $5,000 later and a new engine, Ford would not acknowledge that this is a known ongoing problem with the Ecoboost engine.
Warning lamp went on. Took immediately to Ford, with only 28K miles on my 6-year-old vehicle. They diagnosed a coolant intrusion. Was told this is a "known problem" with the Ford Edge 2.0L Ecoboost engine, due to a "manufacturing defect". Had to do a "Long Block" replacement, costing me thousands of dollars.
Driving to work & the vehicle started to behave like it was running out of gas, kind of a jerky motion. I was able to get an appointment @ the local dealership, they diagnosed it as having a cracked block by cylinder #3 causing coolant to enter the cylinder. This vehicle just turned 80k miles and was service for the same thing 6 months prior, same cylinder. There was no mention of a common problem with Ecoboost design flaws until the Service Advisor shared the info with me. A new engine had to be replaced @ a cost of almost $8000. A 2018 vehicle with a perfect maintenance record and only 80k miles should be needing a total engine replacement. Ford should back their products. I essentially bought a used Edge according to Blue Book and in reality bought my car twice.
The contact owns a 2018 Ford Edge. The contact stated that while the vehicle was parked, the vehicle was started, and the check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with coolant intrusion and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 105,000.
The issue is Coolant intrusion in the #2 cylinder. Rough idle when starting and white smoke. Ford bulletin 22-2229 The issue was confirmed by the dealer Capital Ford of Wilmington Dec of 2024. Yes, the problem stated prior to engine light coming on. It starting getting worse.
A D V E R T I S E M E N T S
- Mesa, WA, USA