This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
Drivers side door inner shell became unwelded. Ford released a TSB technical service bulletin about it, but refuses to call it a recall. Out of pocket $1500
Problems with the driver side door. Purchased car brand new. Currently has 25k miles (roughly). My 3-36k mile warranty ended 10/23. My door is making creaking snapping popping noises and the window Won't go down. I'm concerned the door won't open or worse snap and fall off while driving. I feel I have to hold the door while driving which is not safe.. I have to drive this car for work, I work in the field and need the car to go from location to location throughout the day.. I took it to the dealer garage. The conversation went along the lines, the door arm welds are bad and the garage mentioned they had 5 cars recently with the same problem. They said it was covered and then the door would have to be replaced. They (service dept) sent it over to the body shop stating it was too long of a job for service dept to do. I waited 2 weeks and went down to check on status. The body shop said it wasn't covered and it would be $2400 to replace the door. Contacted Ford about the letter that's supposedly to come out to owners with this problem 2020 escape and they know nothing about it. I reached out to another dealer in the area and they are very aware of problem with the escape door but they know nothing about Fords customer satisfaction program regarding the door. Very concerned the car door is unsafe.
Opening/closing driver door is very difficult must do slowly. Window does not go down. I can see three holes where the spot weld holding the hinge is gone.
The driver door welds have broken. The door has been investigated by Courtesy Ford, Hattiesburg, MS. They stated the door would have to be replaced at a cost of $2600. No warning lamps were indicated. Also, the breaks squeal when in reverse.
My driver door began clicking and popping and I was unable to open my door to exit the vehicle. My driver window would not roll down. The following day the metal door arm had popped loose. And where the hinge was welded to the door. 3 holes were found and the metal hinge in the door started moving freely. I am a home care nurse and depend on my vehicle. It feels like the door is going to fall off. This scares me, because I am not sure if I will be unable to open my door or window to exit in case of an emergency. I am also fearful the door will fall off. I called ford and was told no recalls were reregistering for my vin number. I was told my warranty ran out and any repair will have to be paid fully by me. Ford refuses to put customer safety first in this situation. Please advise. Thank you.
The driver side door began making a terrible noise upon opening and closing. It would not close. The door eventually closed and the door weld for the hinge failed. The door does not operate properly and now the driver side window does not go down because the door hinge components are broken off inside the door and blocking the window from going down at all. Ford was contacted multiple times about the manufacturer failure and there is still NO Recall on the 2020 Escape AWD. They advised to wait for a letter from Ford allowing the fix. Ford has no information for when they will send letters to customers or dealers to fix the failed manufacturer weld component on the drivers side door.
The passenger door hinge made a large noise and was unable to close without extreme force. It was a safety issue as the car function and hinge mechanism failed. The dealer turned me away as they do not "weld" and referred me to a body shop. Yes, my independent auto service stated that the Door Stay and Mounting Bracket three small welds broke off. They were unable to re attach door properly as they do not weld. They noted the drivers side door is also starting to loosen. This is another safety concern.
On February 23,2024 the driver door started making very loud scraping and popping noises with physical resistance to opening or closing. The drivers power window started working very slowly like it was being dragged on, and then wouldn't go back up. Pushing on exposed window edge got it finally to go up and close. Over the next several days the noise and resistance has gotten worse. Found out NTSB has opened an investigation into this issue, and Ford has a service memo SSM 50150 as the cause is faulty spot welds on interior door anchors which can lead to door failure and unexpected opening. SO far Ford has not offered any help to repair this issue. I have filed a claim without result yet.
Drivers door spot welds that hold the reinforcing angle for the door check have broken loose allowing the door check angle to move inside of door, this makes it difficult to close the door all the way because the angle is hitting something inside of the door. Looking online this appears to be a common problem, Ford issued a service bulletin for this issue, (SSM 50150), we called the local Ford dealership and was told that since the vehicle is out of warranty there is nothing they can do. Vehicle has about 14,000 miles on it but is about 8 months out of warranty, it was used very little for the first 2 years due to Covid 19 pandemic shutting down the University that is the owner. The passenger door spot welds are also beginning to break loose.
Drivers side door started to make a loud popping sound and the window stopped rolling down. Every time the drivers side door opens it flings wide open because there-??s nothing to keep it in place. Took the car to the dealership it was purchased at and was told that the ford escape has that issue with a faulty weld on the check arm causing it to break completely off with no way to repair it.
Approximately a week ago we noticed a popping sound in our driver side door. You can see where the rivets have popped free from the sheet metal. This car is over its 3 year warranty by about one week. Yet, the dealer and Ford motor company do not want to do anything to replace our door. This is an issue that ford acknowledged as a problem on this specific car. But, no TSB or recall has been issued yet. Hopefully by leaving this message, the NHTSA will look into this concern. I don't need my wife driving this car with a door that is not safe. Thank you!
The driver door popped open at 70 MPH on the interstate. Pulled over and the door was jammed open about 12 inches. We could not get the door to close or get the window to go down. We had to get out the passenger side. We finally forced the door closed with two of us pushing on it. Now it won't open all the way and the window is stuck about 6 inches from closing. Extremely dangerous situation. The vehicle has 56.000 miles and we purchased it new. Now my wife refuses to ride in it. We are both [XXX]. It's unbelievable that the Ford Motor Company has not addressed this! My dealer is stating the repair could cost us as much as $2000 out of pocket, The NHTSA is our only hope.. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Last week, I heard a popping noise when opening my driver side front door of my 2020 Ford Escape. I had the issue diagnosed by my local Ford dealership as broken spot welds on my door. Since then, the issue has progressed and my door no longer closes properly. It is a safety issue because my door is not closing properly and continuing to get worse. I do not feel comfortable driving until it is fixed. I was referred to a body shop by my local dealership for the issue and will have it repaired this week. The body shop confirmed the broken spot welds on my driver side front door.
A D V E R T I S E M E N T S
- Savannah, TN, USA