This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
The contact owned a 1999 Ford Expedition. The contact stated that the vehicle was included in NHTSA campaign number: 05V388000 (vehicle speed control). The vehicle was repaired. After the repair, while the vehicle was parked, it caught fire underneath the hood. The fire department extinguished the fire and a police report was filed. There were no injuries. The VIN was unknown. The approximate failure mileage was 200,000.
The contact owns a 1999 Ford Expedition. After parking the vehicle near the contact's garage, a fire erupted under the hood. The contact was alerted to the failure due to the alarm sounding. The fire department extinguished the flames. The vehicle was not diagnosed and remained parked at the contact's residence. The VIN was not included in NHTSA campaign numbers: 06E056000 (fuel system, gasoline) and 98V312000 (fuel system, gasoline). The manufacturer was not notified. The VIN and failure mileage were not available.
The contact owned a 1999 Ford Expedition. The contact stated that the vehicle caught fire while parked in the driveway. The police believed that the fire originated on the driver side under the hood. A police and a fire report were filed. The contact was able to extinguish the fire with two fire extinguishers and a hose before the fire department arrived. A passenger who was seated in an unknown location sustained a fractured right knee, which required medical attention. The vehicle was destroyed. The manufacturer was not notified of the failure. The failure mileage was 199,000. The VIN was not available.
I was sitting at mc donalds getting food for my son, when a loud pop come from under my hood then my truck started to smell funny. Some cars were in front of me so they let me out. I pulled off to the side and called a few people that could tell me what was goin on. A man come and looked at it that worked on cars a crossed the street told me that it blowed a spark plug I never heard of anything like that. It had come completely out. There was oil on it. I had to have it redone so another spark plug could be put in there and now it has don it again. The same one number 2. spark plug. This is crazy I don't have the money to keep fixin this truck over and over. I had to have it towed to my house when it blew the spark plug and I dono want to go though this again. Yall know that this is a default in theses vehicles but ur not doing anything about it. I have to use my truck to go to the doctors. And I can't go if it stays broke down. Yall need to take care of this problem....
- Walker, LA, USA
Search CarComplaints.com for these popular complaint phrases...
I have had 2 different spark plugs ejected from the engine on 2 separate occasions. The first time I took it in and had a heli coil installed. I have not repaired the second instance yet. There was a 2 year time span between the events. The first time it happened I was at low speed going through town. The second time I was on the freeway.
A spark plug blow out of the engine. I purchased a dorman kit to repair and replace the spark plug. I am concerned about driving the vehicle far from home for concern that another spark plug may blow out of the engine. Ford Motor Company should have made the issue with the engine cylinder heads not having thick enough material to hold spark plugs in the threads a recall.
The spark plug blew out of the head while I has just pulled out accelerating up a small incline. I was going through a major intersection with my son. There was a stutter, then knocking sound, less power, and strange odor.
My Expedition started acting like it was starving for fuel misfiring loss of power and there's a ticking sound coning from under the dash board the door lock unlock the lights flicker and horn beeps by its self I parked it and a couple days later it wouldnt it trying to crank but its sound I dont believe battery is dead if it was then lights wouldn't come on now and again also when I use my key ring lock to lock the door there's a clunk cluck sound I've spent a lot of money trying to find out what's wrong with lamont that's my Expedition name and nobody knows last repair shop had it 9 days total on the 7th day I called them they said they had no idea and on the 9th I went in and they said I needed a new motor costing 2600 and charging me 220 to tell me that. The shop before that cost me 350 saying the truck itself were the plugs go in was stripped and they needed a special tool. Any how I believe it would be a matter of time before the vehicle will catch on fire. The vehicle is very unpredictable and you dont know what it will do next it also dies while driving it..
After picking up laundry, on my way to staples all of the sudden I heard a loud pop, then a strong smell of gas. I pulled over, turned off truck. Turned it back on then heard a loud popping sound. Got the truck home opened the hood and noticed spark plug out of engine attached to a damaged coil. I tried to put in new spark plug but it would not screw in, the threads in cylinder head were stripped. Found out it would cost a lot of money to get cylinder head rethreaded. Wrote to Ford corporate they asked me for VIN name and basic info. I found out that this is common in Triton engines. It is a designer flaw in Ford. Ford knew about it for years now. Spark plug blows out for no reason. After spark plug pops out a strong smell of gas comes out. This could cause engine to explode. This happens in Ford Triton engines. This is unsafe.
After picking up my laundry, I headed to staples while driving 45 mph I heard a loud boom and very strong smell of gas so I pulled over turned off truck. I started again and it was a loud popping sound. I got home checked truck engine. I noticed my coil pack out and spark plug attached to it. I tried to put spark plug but the threads were all striped. I checked the inside of cylinder head could not see tried to put in a new spark plug but I can turn and turn and the spark plug would not screw in. This is dangerous because when spark plug blows out you have all the odor of gas coming out and that one spark can cause engine to blow up. I contacted Ford all they took was my VIN number and name never heard from them again.
As I was on the highway, there was a loud blow out as I was going 60 miles per hour. This is the 4th time that I have had a problem with the coils in this truck and this time the actual spark plug blew out of the engine leaving a open hole that could ignite a fire. I have now spent over $3600 on repairs just to find out with doing some online research that Ford knew of this problem for years and has been blaming the consumer for tightening the spark plugs to tight and other bull that they come up with and not taking responsibility for the cheap aluminum plugs and plug wires in their vehicle. This effect cars and truck with this engine since 1999 and goes through vehicles of 2008. A 9 year problem and the Ford corporation did not do a recall. This will effect if I will be buying another Ford vehicle for sure.
I have had spark plugs blow twice in this engine while driving on the highway. The last time in January 2014 that I haven't had the money to fix this time. After researching on the internet, I have found that this is an extremely common problem with this particular vehicle and Ford has done nothing about it even though they know it is a common problem with their design. It is a wonder that more people haven't gotten hurt from this problem while driving on the highway.
Blew out 3 spark plugs already. Now I need to get the engine fixed and spend 50% of the trucks value, because Ford rolled out a faulty design and wont own up. I've never heard of this blow out until I purchased a Ford, and I've owned soo many other cars that never experienced this. This needs to be recalled by Ford!
The contact owns a 1999 Ford Expedition. The contact stated that while driving approximately 80 mph, the power steering assist failed. The contact also mentioned that the steering wheel became difficult to turn and the vehicle stalled without warning. The vehicle was restarted after multiple attempts. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 102,000. The VIN was unavailable.
The contact owns a 1999 Ford Expedition. The contact stated that a fire originated in the engine compartment, causing the vehicle to become engulfed in flames. The flames spread rapidly and burned a portion of the contact's home. The fire department was contacted and no injuries were reported. The vehicle was not taken to the dealer. The manufacturer was not made aware of the failure. The vehicle was destroyed. The failure and current mileage was 240,000.
Pulling out of a convenience store we heard a funny sound and made it to a parking lot of a restaurant. Had to call the insurance company to be towed home. Found out it was spark plug that had blown out. It stripped the threads and is now going to cost a lot to get it fixed, not to mention the towing.
Vehicle ran perfect during the day. Stopped for about 1 hour around 9 pm, went to restart the engine around 10 pm, heard a loud "pop" followed by very loud flapping noise from under the hood as the engine continued to run but very rough (sounded like "blap, blap, blap......"). on investigation, found #6 spark plug had been blown completely out laying on the top of the manifold and the coil broken off its mount. The spark plug was not broken, but the threads looked a little rounded, but otherwise ok. Tried to reinstall the plug, but it never would seat and when pulled out vertically it felt like the threads were stripped in the head. Had the vehicle towed to a local Ford dealership in wichita.
A D V E R T I S E M E N T S
- Mansfield, TX, USA