Print this page


really awful
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
383 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2004 Ford F-150 windows / windshield problems

windows / windshield problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2004 Ford F-150:

Unsubscribe any time. We don't sell/share your email.

2004 Ford F-150 Owner Comments

problem #3

Apr 252004

F-150 4WD

  • 100 miles


Purchased new Ford F-150 truck from dealership in April 2004. Wavy distortions in the windshield were evident. Reported defective windshield to dealership, which was then replaced in June 2004 (an approximate three week wait was required, because dealer reported that new windshields were not available.) second windshield was also distorted, and dealer in another state said that windshield should be replaced by dealer that had installed second windshield. Third windshield replaced in January 2005, after six weeks of negotiations with Ford. This third windshield also has the wavy defect.

- Hopland, CA, USA

problem #2

Jun 252004

F-150 4WD

  • Automatic transmission
  • 1,000 miles
Consumer indicated that windshield had a wave in it which distorted the vision while driving. Consumer took the vehicle to the dealer on three occasions, and had it replaced. However, the problem recurred.

- Winter Springs, FL, USA

problem #1

Jun 252004

F-150 8-cyl

  • Automatic transmission
  • 50 miles
Consumer noticed that after the windshield wipers went off the front windshield became blurry. This caused poor visibility to the driver. Vehicle was taken to the dealer for inspection, and mechanic replaced the windshield three times. However, the problem recurred. Consumer also had concern with vibration under the vehicle. Dealer found that the vibration is coming from the drivershaft, which was replaced by the dealer.

- Keithville, LA, USA

Not what you are looking for?