This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
HVAC airflow gradually goes to zero when demanding air conditioning on days > 80F. Air conditioner lines will develop a thick layer of ice prior to experiencing no air flow. The remedy is to turn off the AC and keep fan on MAX. As the system warms airflow gradually returns. Ice buildup is the culprit as after performing the remedy a large amount of condensate is discharged underneath the vehicle.
While driving at approximately 45 mph my parking brake warning light and message on the instrument panel cluster came on, on several occasions. I also recently experienced an unintended activation of the electric parking brake while driving.
When I tried to start the truck, the dash showed messages saying -??stop safely now-?? and -?? full accessory mode-?? but would not start. Truck also enters deep sleep mode daily even with a long commute to charge battery. I got the truck started via the Ford Pass app.
Upon the first drive of a '23 Raptor, within 20 miles of driving the TPMS sensor warning lights up on the dash. This immediately caused a loss of data (no PSI data) on at least 2 tires shown on the truck's dash display. There is a loss of data on the FORD app also that corresponds with the dash display. This will only reset after the truck is off and parked for a reasonable amount of time. This occurs EVERY trip in excess of 20 miles. In the Ford Raptor Forums it appears this issue is persistent anywhere from 17-30 miles into a trip. This issue/error prevents the safe operation if it is unknown whether tire pressure is low, or there is another issue at hand. The truck has been at FORD at least 4 times in order to assess the problem. From "resetting" the system, replacing the ECU, replacing additional electrical components and still having the same issue. The issue has been replicated at the dealer level - hence the numerous attempts at a fix as mentioned above. Apparently a work-around is shielding the Pro-Power - the power chord is causing interference with the truck's electrical system. This problem is persistent with numerous 2023 F-150 Raptors, and it appears to correct itself TEMPORARILY if you turn off the Pro-Power...which of course turns off numerous electrical outlets in the truck. Again, this issue prevents the safe operation of the truck - the sensor is set off during every drive, and although its apparently caused by RF interference, we have no way of knowing if there is an actual anomaly in the TPMS system. Will it read correct if a tire is dangerously low - is unknown whether tire pressure is low, or there is another issue at hand. Is the Pro-power affecting RFI in other electrical/safety components"?"
- Bristow, VA, USA
Search CarComplaints.com for these popular complaint phrases...
Vehicle malfunctions at start-up. Will not turn on and displays "stop safely now" message. Has also thrown codes for low battery voltage that simply disappear. Vehicle malfunction at start-up does not throw code.
When starting truck so far 4 times in the first month of ownership it doesn-??t start. No codes but dash displays full accessory mode and stop safely now. Tons of these trucks have same issue. Ford has no clue why or how to fix. Very unreliable
Reporting this after the second time this incident has occurred. Shortly after starting the vehicle, there was an extremely loud electrical/static pop coming from the speakers, followed by extremely load static noise which went on for several seconds. The noise was so loud, that it caused ringing in ears. The noise was not related to the volume control of the speakers, as turning the dial all the way down to zero, or turning the volume off, had no effect on the noise. To stop the noise, I turned the vehicle off. This occurred while I was in a parking lot, and fortunately not driving, but would have been a dangerous and disruptive situation if it had occurred while driving. Reading into this online, it sounds like this is not an isolated occurrence, and others are experiencing an even worse version of the problem that will not stop until the battery is disconnected. Also reports this is happening in the middle of driving. I'm nervous to drive the vehicle now.
The 240V mobile charging cord that is sold with the vehicle repeatedly overheats and derates the charging speed once overheated. Problem has existed since the vehicle was brand new. Cord is used in a warm climate but not an abnormal temperature for a non-climate controlled garage. Overheating electrical equipment could result in a household electrical fire if the temperature sensors were to fail, which is a safety mechanism and shouldn-??t be triggered in normal everyday operation. An alternate brand charging cord with similar capabilities works fine on the same outlet in similar environmental conditions. This is a well known problem from other owners of F-150 Lightnings and Mustang Mach-Es. Therefore a warranty replacement with an identical unit does not appear to be a prudent resolution and would be preferable to be recalled and re-engineered.
The 240V mobile charging cord that is sold with the vehicle repeatedly overheats and derates the charging speed once overheated. Problem has existed since the vehicle was brand new. Cord is used in a warm climate but not an abnormal temperature for a non-climate controlled garage. Overheating electrical equipment could result in a household electrical fire if the temperature sensors were to fail, which is a safety mechanism and shouldn-??t be triggered in normal everyday operation. An alternate brand charging cord with similar capabilities works fine on the same outlet in similar environmental conditions. This is a well known problem from other owners of F-150 Lightnings and Mustang Mach-Es. Therefore a warranty replacement with an identical unit does not appear to be a prudent resolution and would be preferable to be recalled and re-engineered.
My truck features the B&O speakers and initially I heard a very loud pop on the passenger side of the vehicle. Radio and CarPlay was playing but no sound was coming from the speakers. Then an extremely loud static noise vibrated the entire truck through the speakers at full volume. I had family in the car and it scared everyone. Pulled over and shut the car off and the static persisted until the electronics fully shut off. Went back in the truck and turned it on and the static continued. On the 3rd try 5 minutes later the static finally stopped and everything worked -??normal-??.
Entered vehicle and started my truck, and Immediately after a stop safely now along with full accessory power flash continuously. Along with the warnings I was unable to move my shifter as it was stuck on park the whole time. I turned off and restarted the vehicle 8-10 times over the course of 10-15 minutes which in the last try the messages went away and was finally able to put into drive and drive to work. I researched this issue and see a ton of other owners are having similar issues from this model.
Battery is bad. Drove truck 4600 miles without issue, went to start truck and battery was dead. Needed to jump start truck, drove for 30 minutes, parked it and measured 12.2V. Charged truck overnight, measured 12.6V. Drove to work 30 minutes, parked 10 hours, drove home 30 minutes, measure battery at 11.08V. I could not start the vehicle and get out of the area I was in.
A D V E R T I S E M E N T S
- San Lorenzo, CA, USA