This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
Issues with Ford Sync Infotainment system have been occurring for over a year now, with the latest being on May 25th. Backup camera stays on when in drive, and then turns to a blue or black screen that says contact dealer. GPS will fail randomly and will show my vehicle driving off roads and not following the route I am driving. A/C will randomly stop working and show a Fan Speed of 0 no matter how many times you try to increase the fan speed, then once you are able to adjust the fan speed after restarting the car it will only blow very hot air at any temperature setting except in Max A/C. Which even in Max A/C the air coming out is not very cold. The backup camera staying on is dangerous you are not able to control any other functions of your vehicle because the vehicle believes its still in reverse, and at night when the screen is bright blue it impairs visibility. The GPS failure does not allow for proper navigation when traveling. The A/C issue is dangerous during the summer time when you are unable to cool your vehicle with passengers, especially young children from the over 100F temperatures you can experience during the summer. The dealership has seen the A/C issue, and I have videos of the backup camera and GPS issues. Dealership has inspected the vehicle and has been unable to diagnose the issue. They have reset and updated the software, but issues are still intermittent. Multiple calls with Ford and they are unable to provide additional assistance without there being any fault codes or the issue being present. When the A/C issue was present at the dealership, they were unable to diagnose the issue and Ford did not respond back to customer service inquiries to know who at Ford to contact for additional support. No warning signs about the issues. Will just happen randomly at times with no advance warning of anything happening. Most of the time the issues happen after starting the vehicle, but A/C and GPS issues have occurred during middle of a drive.
According to dealership, the 12-volt, 7 year battery passes all testing and has a "Good" (best) rating (battery is only 3 years old). Diagnostics reveal batter at 80%. When battery falls below 85% (such as frequently happens in cold weather), the computer program shuts down several features including remote car starting. Electrical programming must be changed to when a battery falls below 50%...when a car battery should be changed out. Please recall these vehicles and require Ford Motor Company to reprogram the electronic system. Thank you.
If the car is parked in directly sunlight and I start the car a "Front camera temporarily unavailable" message will appear. It happens more when the outside temperature is warmer.
Water is leaking into the trunk of our vehicle through the tail light assembly and soaking all the electrical wiring in the base of the trunk. The wheel well is becoming flooded with water. All the wiring going in and out of the trunk is soaking wet. If you Google this issue. Other Ford Fusion owners with older model vehicles and the same tail light assembly are having the exact same issue where water is coming into the trunk from the tail light assembly. This is clearly a design flaw and with water coming inside and covering the electrical system I want to believe this is major safety concern.
The contact owns a 2020 Ford Fusion. The contact stated that while driving and attempting to make a right turn, the parking brake activated causing the vehicle to abruptly stop. The contact was turned off and then restarted the vehicle. Approximately 3 miles later while driving, the failure reoccurred. The odometer lights began flickering, the gear shift indicator (PRNDL) light started to change, the location of the gear shifter started to switch gears, and the radio malfunctioned. The shift sensor malfunction and fault warning lights were illuminated. The failure occurred a total of 5 times. The contact took the vehicle to a certified mechanic who reset the vehicle to remove of all the codes however, the failure reoccurred. The contact scheduled an appointment with the dealer however, the vehicle had not yet been diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The approximate failure mileage was 38,750.
- Graysville, TN, USA
Search CarComplaints.com for these popular complaint phrases...
Dead battery again; this is a major concern on this particular fleet car that we have. Dealer had car towed in. I told them to check the connections. This seems to be a concern of other 2020 Ford Fusion owners as well, after researching. We need this vehicle in our fleet and we cannot have this keep happening. No dealer paperwork yet as the problem has not yet been resolved; car still at the dealer.
(same fleet vehicle from before) Electrical system concern again; battery issue. Battery was already replaced on 2/02/21. Dealer had to replace battery again.
Battery drains very quickly and needs to be jump-started repeatedly, which has risks to safety and equipment. A new battery was installed earlier this month and it has already drained also. This is a fleet vehicle.
The touchscreen display is not working. It turned completely black. I cannot change the radio station. I shut off my car and turned it back on and it is still not working had to hard reset the system car also shifts hard in and out of park and reverse, makes a clunking sound and shifts hard in first and second
The touchscreen display is not working. It turned completely black. I can change the volume using the dials, but I cannot change the radio station. It also will not show my back up camera. I shut off my car and turned it back on and it is still not working
The contact owns a 2020 Ford Fusion. The contact stated that the backup camera remained on while driving at an unknown speed. The vehicle was taken to the royal oak Ford dealer, located at: 27550 woodward ave, royal oak, mi 48067, where the sensor was replaced. The contact stated that while driving home, the vehicle hit a pot hole, the front passenger's tire went flat. There was not spare tire. The contact's husband purchased a new tire, jacked the vehicle up to replace the tire. While on the jack, the vehicle went in reverse, rolled back and fell off the jack. The vehicle was taken to the same dealer who stated that the vehicle was not equipped with a spare tire. The manufacturer was made aware of the failures and referred the contact to the dealer. The contact was told to take the vehicle to a body shop to replace an mud guard that detached. The part was not replaced. The failure mileage was 4,051.
A D V E R T I S E M E N T S
- Edgewood, KY, USA