2020 Mitsubishi Outlander Sport
78 Technical Service Bulletins (TSBs)
TSB List for the 2020 Mitsubishi Outlander Sport
Technical Service Bulletins (TSBs) for the 2020 Outlander Sport are official communications between Mitsubishi & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
STEERING
-
TSB #TIN21-37-001REV3
This Revised Technical Information Notice provides dealers with the requirements needed to be entered into the Photo Required Condition & Pre-Approval Center (PRC) for a vehicle pulling/drifting and/or with steering wheel off-center ... Read More »
-
TSB #TIN-21-37-001REV
This is a Revised Technical Information Notice advising dealers of the instructions to follow when performing a wheel alignment check and adjustment on an affected vehicle with a customer concern of pulling/drifting and/or steering wheel ... Read More »
-
TSB #TIN-21-37-001REV
This Technical Information Notice was sent to dealers informing them of the photo requirement for claims when performing a wheel alignment check and adjustment on an affected vehicle with a customer concern of pulling/drifting and/or ... Read More »
SUSPENSION
-
TSB #TSB-23-33-001
This TSB provides corrections and additional information for the Front and Rear Suspension inspection procedures. (Service Manual Revision) Read More »
-
TSB #TSB-21-34-001
This Technical Service Bulletin was sent to dealers informing them a shock absorber oil leak may result in replacement of absorbers unnecessarily when trace amounts of oil are noted to have adhered to the shock absorber. Read More »
SUSPENSION:FRONT
-
TSB #TSB-23-33-001
This TSB provides corrections and additional information for the Front and Rear Suspension inspection procedures. (Service Manual Revision) Read More »
SUSPENSION:REAR
-
TSB #TSB-23-33-001
This TSB provides corrections and additional information for the Front and Rear Suspension inspection procedures. (Service Manual Revision) Read More »
BRAKES (PWS)
-
TSB #TSB-22-35-001
This is a Technical Service Bulletin sent to dealers informing them of updates to the Stoplight Switch Check section, in the Service Brakes portion of the affected Service Manuals. Read More »
ENGINE (PWS)
-
TSB #TSB-22-16-001
This Technical Service Bulletin was sent to dealers directing them upon customer complaint basis and after diagnosis, to replace the ignition coils of all cylinders with countermeasure parts when customers report a MIL illumination and a ... Read More »
ENGINE AND ENGINE COOLING
-
TSB #TSB-22-16-001REV
This Technical Service Bulletin supersedes TSB-22-16-001REV ("MIL illumination with DTC P030X and loss of power due to Fail Safe Mode") issued August 2023, to update the Affected Vehicle years and provide VIN cut-off information. Read More »
-
TSB #TSB-22-16-001REV
This Revised Technical Service Bulletin was sent to dealers directing them upon customer complaint basis and after diagnosis, to replace the ignition coils of all cylinders with countermeasure parts when customers report a MIL ... Read More »
-
TSB #TSB-23-13-004
This Technical Service Bulletin provides instructions to reprogram the ECU with the countermeasure software when the check engine light illuminates with DTC of P0401/ P0400. Read More »
-
TSB #TIN-23-66-001
This is a Technical Information Notice informing dealers and parts managers about possible causes after a customer complains that the engine will not start while using the remote start system. Read More »
-
TSB #TSB-11-66-001REV
This Technical Service Bulletin contains technical information and troubleshooting for the accessory Remote Engine Start system for affected vehicles. Read More »
-
TSB #TSB-22-16-001
This Technical Service Bulletin was sent to dealers directing them upon customer complaint basis and after diagnosis, to replace the ignition coils of all cylinders with countermeasure parts when customers report a MIL illumination and a ... Read More »
-
TSB #TIN-21-13-001
This Technical Information Notice provides additional instructions to dealers when replacing the Valve Cover Gasket due to a customer concern of oil leaking. Read More »
-
TSB #TSB-20-15-001
This Technical Service Bulletin was sent informing dealers a rattle noise may be heard from the Heat Protector of the Exhaust Manifold and instructs dealers to replace the Heat Protector Assembly with a new part. Read More »
-
TSB #TSB-20-14-002
This TSB instructs dealers a condition where the coolant temperature warning light illuminates and a coolant leak is found at the hose connection and to replace the old hose clamp with a countermeasure clamp and to replace the old water ... Read More »
-
TSB #TSB-20-14-002
This TSB instructs dealers a condition where the coolant temperature warning light illuminates and a coolant leak is found at the hose connection and to replace the old hose clamp with a countermeasure clamp and to replace the old water ... Read More »
POWER TRAIN
-
TSB #TSB-24-23-001
Service Manual Revision - This Technical Service Bulletin provides the procedure for diagnostic trouble code and on-vehicle service for belt & pulley assembly on certain CVT models. Read More »
-
TSB #TSB-23-23-004
This Technical Service Bulletin provides service manual corrections to the CVT maintenance procedure. Read More »
-
TSB #TSB-23-23-001
This TSB provides the addition of Diagnostic Procedure for CVT Belt Check for vehicles equipped with CVT type F1CJC and W1CJC. (Service Manual Revision) Read More »
-
TSB #TSB-22-23-001REV
This Technical Service Bulletin was sent to dealers directing them to diagnose and test drive customer vehicles with F1CJC/W1CJC (CVT-8) transmissions that may exhibit a shudder or surge condition possibly caused by a poor reaction of the ... Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION
-
TSB #TSB-20-23-001REV
This Technical Service Bulletin supersedes TSB-20-23-001, issued April, 2020, to update the Control Valve part number and MY 2020-2018 Outlander Sports with 2.4L engines. Read More »
-
TSB #TSB-20-23-001
Certain vehicles with F1CJC/W1CJC (CVT-8) transmissions may exhibit a shudder or surge condition possibly caused by poor reaction of the hydraulic pressure circuit. Read More »
ELECTRICAL SYSTEM
-
TSB #TIN-23-66-001
This is a Technical Information Notice informing dealers and parts managers about possible causes after a customer complains that the engine will not start while using the remote start system. Read More »
-
TSB #TSB-11-66-001REV
This Technical Service Bulletin contains technical information and troubleshooting for the accessory Remote Engine Start system for affected vehicles. Read More »
-
TSB #TSB-22-51-003
This is a Technical Service Bulletin sent to dealers informing them of updates to the Troubleshooting Procedure for the Windshield Wiper in the Exterior portion of the affected Service Manuals. Read More »
-
TSB #TSB-22-54-006
This is a Technical Service Bulletin sent to dealers informing them of the instructions to reprogram the ETACS-ECU with the latest software, correcting an auto power off malfunction for the ignition swtich assembly (ACC) position. Read More »
-
TSB #TSB-22-16-001
This Technical Service Bulletin was sent to dealers directing them upon customer complaint basis and after diagnosis, to replace the ignition coils of all cylinders with countermeasure parts when customers report a MIL illumination and a ... Read More »
-
TSB #TIN-21-00-004
This Technical Information Notice was sent to dealers informing them Owner Manuals (OM) are now available electronically beginning with Model Year 2015. Read More »
-
TSB #TSB 21 54A 002
This Technical Service Bulletin was sent to all dealers informing them of a software update for the Smartphone Link Display Audio system. Read More »
-
TSB #TSB-21-54A-001
This Technical Service Bulletin was sent to dealers providing instructions for repairs to perform to correct a communication error that may occur between the One-Touch Start System (OSS) and Engine Control Unit (ECU) or the Keyless ... Read More »
-
TSB #TIN-20-52A-002
Technical Information Notice sent to dealerships that additional circuit codes for the Driver's Seat Slide Sensor Circuits may appear and dealers should check for damage to the drivera??s seat slide position sensor harness. Read More »
-
TSB #TSB-20-54A-001
TSB updates the affected Service Manual Data List Reference tables within the Chassis Electrical section. These changes are being made to correct the Left, Right, and Center Reflection Amplitudes within the table. Read More »
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
-
TSB #TT-20-00-002
Tech Talk is a service newsletter that was sent out to dealers. It covers various topics and reviews the previous months publications. Read More »
ELECTRICAL SYSTEM:IGNITION:COIL
-
TSB #TSB-22-16-001
This Technical Service Bulletin was sent to dealers directing them upon customer complaint basis and after diagnosis, to replace the ignition coils of all cylinders with countermeasure parts when customers report a MIL illumination and a ... Read More »
EXTERIOR LIGHTING
-
TSB #TIN-23-54A-001
This is a Technical Information Notice requesting dealers to report headlight inoperative issues. Read More »
-
TSB #TSB-22-35-001
This is a Technical Service Bulletin sent to dealers informing them of updates to the Stoplight Switch Check section, in the Service Brakes portion of the affected Service Manuals. Read More »
-
TSB #TSB-22-54-003
This Technical Service Bulletin was sent to dealers to explain the difference between normal dew condensation, which is a natural phenomenon, and water penetration caused by improper sealing or a defective/broken part. Read More »
VISIBILITY
-
TSB #TSB-22-51-003
This is a Technical Service Bulletin sent to dealers informing them of updates to the Troubleshooting Procedure for the Windshield Wiper in the Exterior portion of the affected Service Manuals. Read More »
VISIBILITY:WINDSHIELD
-
TSB #TSB-20-42A-002
This TSB updates the Body section of the affected Service Manuals to add information (including a Caution) to the windshield Removal and Installation procedure for vehicles equipped with Forward Collision Mitigation System (FCM), Lane ... Read More »
SEAT BELTS
-
TSB #TIN-20-52A-001
This Technical Information Notice serves as a reminder that if a vehicle arrives with a complaint related to a seat belt tongue not staying in place or that slides down to the floor, always default to searching for applicable TSBs, Tech ... Read More »
SEAT BELTS:FRONT
-
TSB #TIN-20-52A-001
This Technical Information Notice serves as a reminder that if a vehicle arrives with a complaint related to a seat belt tongue not staying in place or that slides down to the floor, always default to searching for applicable TSBs, Tech ... Read More »
SEAT BELTS:FRONT:ANCHORAGE
-
TSB #TIN-20-52A-001
This Technical Information Notice serves as a reminder that if a vehicle arrives with a complaint related to a seat belt tongue not staying in place or that slides down to the floor, always default to searching for applicable TSBs, Tech ... Read More »
STRUCTURE
-
TSB #TSB-23-00-004
This Technical Service Bulletin provides instructions and material safety data sheets for removal of rap-film adhesive residue. Read More »
-
TSB #TSB-21-51-001
This is a Technical Service Bulletin sent to dealers instructing them to replace both sides of the wheel arch molding when customers report a condition in vehicles equipped with a front wheel arch molding displays a gap between the front ... Read More »
WHEELS
-
TSB #TIN-21-37-001REV
This is a Revised Technical Information Notice advising dealers of the instructions to follow when performing a wheel alignment check and adjustment on an affected vehicle with a customer concern of pulling/drifting and/or steering wheel ... Read More »
-
TSB #TSB-21-51-001
This is a Technical Service Bulletin sent to dealers instructing them to replace both sides of the wheel arch molding when customers report a condition in vehicles equipped with a front wheel arch molding displays a gap between the front ... Read More »
SEATS
-
TSB #TSB-21-52A-002RE
This Technical Service Bulletin instructs dealers to replace the seat adjuster assembly and power seat harness in affected vehicles with improved countermeasure parts. Read More »
-
TSB #TSB-22-52A-001RE
This Technical Service Bulletin instructs dealers to apply Nonwoven Fabric Tape between the Seat Back and Urethane Pad when customers report a condition where an abnormal rubbing noise is heard from the Seat Back when a driver and/or ... Read More »
-
TSB #TIN-20-52A-002
Technical Information Notice sent to dealerships that additional circuit codes for the Driver's Seat Slide Sensor Circuits may appear and dealers should check for damage to the drivera??s seat slide position sensor harness. Read More »
FORWARD COLLISION AVOIDANCE
-
TSB #TSB-20-42A-002
This TSB updates the Body section of the affected Service Manuals to add information (including a Caution) to the windshield Removal and Installation procedure for vehicles equipped with Forward Collision Mitigation System (FCM), Lane ... Read More »
LANE DEPARTURE
-
TSB #TSB-20-42A-002
This TSB updates the Body section of the affected Service Manuals to add information (including a Caution) to the windshield Removal and Installation procedure for vehicles equipped with Forward Collision Mitigation System (FCM), Lane ... Read More »
EQUIPMENT
-
TSB #TSB-22-54-002
This Technical Service Bulletin was sent to dealers informing them a software update is now available for the Smartphone Link Display Audio (SDA) and provides instructions on how to update the SDA in the affected vehicles. Read More »
-
TSB #TSB-22-52A-001RE
This Technical Service Bulletin instructs dealers to apply Nonwoven Fabric Tape between the Seat Back and Urethane Pad when customers report a condition where an abnormal rubbing noise is heard from the Seat Back when a driver and/or ... Read More »
-
TSB #TSB-21-54A-002
This Technical Service Bulletin was sent to dealers informing them a software update is now available for the Smartphone Link Display Audio (SDA) which resolves several issues that may occur in various models equipped with SDA. Read More »
-
TSB #TSB 21 54A 002
This Technical Service Bulletin was sent to all dealers informing them of a software update for the Smartphone Link Display Audio system. Read More »
-
TSB #TSB-20-15-001
This Technical Service Bulletin was sent informing dealers a rattle noise may be heard from the Heat Protector of the Exhaust Manifold and instructs dealers to replace the Heat Protector Assembly with a new part. Read More »
-
TSB #TSB-20-54A-001
This TSB updates the affected Service Manual Data List Reference tables within the Chassis Electrical section. These changes are being made to correct the Left, Right, and Center Reflection Amplitudes within the table. Read More »
-
TSB #TSB-20-14-002
This TSB instructs dealers a condition where the coolant temperature warning light illuminates and a coolant leak is found at the hose connection and to replace the old hose clamp with a countermeasure clamp and to replace the old water ... Read More »
-
TSB #TSB-20-23-001
Certain vehicles with F1CJC/W1CJC (CVT-8) transmissions may exhibit a shudder or surge condition possibly caused by poor reaction of the hydraulic pressure circuit. Read More »
-
TSB #TSB-19-00-011
This is a Technical Service Bulletin, containing the vehicle's Technical Specifications, that was sent to dealers. Read More »
EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE
-
TSB #TSB-22-54-002
This Technical Service Bulletin was sent to dealers informing them a software update is now available for the Smartphone Link Display Audio (SDA) and provides instructions on how to update the SDA in the affected vehicles. Read More »
EQUIPMENT:ELECTRICAL:AUX AUDIO JACK/PLUG
-
TSB #TSB-22-54-002
This Technical Service Bulletin was sent to dealers informing them a software update is now available for the Smartphone Link Display Audio (SDA) and provides instructions on how to update the SDA in the affected vehicles. Read More »
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
-
TSB #DEALER LETTER
This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 3rd quarterly technician quiz for 2023. Read More »
-
TSB #TSB-23-00-001
This Technical Service Bulletin reviews the regulations that require a label showing the reduction in load carrying capacity be affixed to vehicles when the total net weight of accessories is more than 1. Read More »
-
TSB #DEALER LETTER
This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 2nd quarterly technician quiz for 2023. Read More »
-
TSB #TSB-23-33-001
This TSB provides corrections and additional information for the Front and Rear Suspension inspection procedures. (Service Manual Revision) Read More »
-
TSB #TIN-22008
This Technical Information Notice was sent to dealers to inform them Audio Manuals are now available electronically on MDL beginning with Model Year 2020. As new Model Year manuals become available, they too will be added. Read More »
-
TSB #TIN-21-00-004
This Technical Information Notice was sent to dealers informing them Owner Manuals (OM) are now available electronically beginning with Model Year 2015. Read More »
-
TSB #TSB-20-42A-002
This TSB updates the Body section of the affected Service Manuals to add information (including a Caution) to the windshield Removal and Installation procedure for vehicles equipped with Forward Collision Mitigation System (FCM), Lane ... Read More »
-
TSB #TSB-19-00-012
This is a Technical Service Bulletin, containing the vehicle's new model features & service information, that was sent to dealers. Read More »
EQUIPMENT ADAPTIVE/MOBILITY
-
TSB #TSB-22-52A-001RE
This Technical Service Bulletin instructs dealers to apply Nonwoven Fabric Tape between the Seat Back and Urethane Pad when customers report a condition where an abnormal rubbing noise is heard from the Seat Back when a driver and/or ... Read More »
-
TSB #TSB-20-14-002
This TSB instructs dealers a condition where the coolant temperature warning light illuminates and a coolant leak is found at the hose connection and to replace the old hose clamp with a countermeasure clamp and to replace the old water ... Read More »
-
TSB #TSB-20-23-001
Certain vehicles with F1CJC/W1CJC (CVT-8) transmissions may exhibit a shudder or surge condition possibly caused by poor reaction of the hydraulic pressure circuit. Read More »
UNKNOWN OR OTHER
-
TSB #TIN-22008
This Technical Information Notice was sent to dealers to inform them Audio Manuals are now available electronically on MDL beginning with Model Year 2020. As new Model Year manuals become available, they too will be added. Read More »
-
TSB #TSB-22-54-003
This Technical Service Bulletin was sent to dealers to explain the difference between normal dew condensation, which is a natural phenomenon, and water penetration caused by improper sealing or a defective/broken part. Read More »
Browse Other Outlander Sport Years
- 2023 Mitsubishi Outlander Sport
- 2022 Mitsubishi Outlander Sport
- 2021 Mitsubishi Outlander Sport
- 2020 Mitsubishi Outlander Sport
- 2019 Mitsubishi Outlander Sport