pretty bad
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
5,854 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2015 Toyota Highlander suspension problems

suspension problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2015 Toyota Highlander:

Unsubscribe any time. We don't sell/share your email.

2015 Toyota Highlander Owner Comments

problem #3

Dec 292015


  • 11,562 miles


The contact owns a 2015 Toyota Highlander. While driving approximately 65 mph, the subframe fractured due to the rear bolts on the frame being too tight. The vehicle was towed to a dealer where it was diagnosed that the rear bolts were not properly installed from the factory associated with the torque. The dealer inspected the subframe and stated that it did not need to be replaced. The dealer replaced the rear hybrid drive motor, rear differential, the entire exhaust system from the motor to the muffler, and the driver side suspension control arm. The contact stated that the subframe needed to be further inspected and replaced. The contact also waited longer than two weeks for the parts to receive the repairs due to the failure. The vehicle was repaired and the contact took the vehicle to another dealer who inspected the frame. The second dealer, a manufacturer's technician, further inspected the vehicle and stated that the subframe was cracked. The technician stated that the contact had the option of receiving a repair of the frame being welded or various parts would need to be removed to replace the subframe, which was an extensive repair. The contact was uncertain of the best course of action to permanently repair the condition. The VIN was not available. The approximate failure mileage was 11,562. Updated 06/14/16

- Boise, ID, USA

problem #2

Aug 042015


  • 2,500 miles
Popping sound coming from right front side when breaking to a stop at all speeds. The problem was first noticed at around 2500 miles and the car was taken to the dealer at around 2900 miles. Dealer inspected it and couldn't find what the problem was. Then as instructed by Toyota replaced the right front strut assembly but that didn't fix the problem. The car was returned to me and I was told there were no safety concerns and that Toyota was sending one of their techs to troubleshoot, but that may take a couple of weeks. In the mean time the problem seems to be getting worse.

- Clemmons, NC, USA

problem #1

May 012015


  • 3,500 miles
Clunking noise from rear end of vehicle when braking, dealer was authorized to change rear away bars and shocks, no fix, now Toyota Corp., says this is normal characteristic of vehicle ? I don't feel safe driving vehicle with noise, and as brakes feel soft also.

- Anchorage, AK, USA

Search CarComplaints.com for these popular complaint phrases...

Not what you are looking for?