Took Toyota Tacoma, 4X4 to team Toyota in langhorne, pa. For annual state & emissions inspections. Failed state inspection due to hole in chassis frame due to corrosive rust. Had dealer call Toyota with no results. I called from the parking lot & received a case #. nothing else has been accomplished. Called a few days later & spoke to a corporate person. "Toyota can do nothing at this point, because a recall has not been issued for my vehicle's VIN#. my truck's chassis has been compromised & yet they won't repair it yet! this is the second time this has happened to me. The first time was a 1998 Tacoma which they bought back for the same reason--a rusted chassis frame. Think they would have corrected the problem by now! my sticker runs out at the end of November. What do I do after that? I need help to convince them to fix my truck!please!

- Yardley, PA, USA

I took the truck in for it's yearly inspection and was informed that the frame will not pass inspection next year. It was suggested that I check if this truck frame was under a recall. I spoke with my Toyota dealer and was told that this truck does not fall under current criteria. I have called Toyota experience to lodge my complaint that this is unacceptable that a truck with 51335 miles frame has rusted so badly that it will not pass inspection. I am waiting for Toyota to follow up with a broadened criteria that will repair my truck frame.

- Honesdale, PA, USA

My 2007 Tacoma double cab sport 4X4 has rust on the entire frame. My concern is that the structural stability of the frame may become compromised due to rusting on the inside of the frame as well. I am located in chesapeake, Virginia which of course receives snow maybe twice a year. Please Toyota resolve this problem.

- Chesapeake, VA, USA

Frame perforated due to rust and corrosion primarily areas adjacent to catalytic converter. Frame has approximately 2 inch perforation and is getting worse.

- Philadelphia, PA, USA

My 2007 Tacoma has serious frame rust. I have read about earlier Tacoma's with frame rust, one would of thought Toyota would have fixed this problem. I would like to see Toyota step up and admit they have a serious problem with their truck frames.

- Brimfield , IL, USA

First trip to dealership to have them inspect excessive rust on frame was 09/01/10 with 38707 miles on the odometer Toyota world of newton stated that the surface rust was consistent with northeast driving second trip to Toyota world of newton to inspect frame separating on 11/01/13 with 74942 miles on the odometer. Toyota inspected and confirmed perforations in right side frame rail and no programs or campaigns on this model year truck was purchased new from Toyota world of newton 2/20/07 I do not believe there should be perforations in a frame of a truck that is 6 years old.....

- Columbia, NJ, USA

The contact owns a 2007 Toyota Tacoma. The contact stated that there was excessive corrosion on the frame where the wiring of the vehicle was located. Additionally, the headlights flickered while driving at different speeds. The manufacturer was made aware of the failure. The vehicle was not repaired. The approximate failure mileage was 8,000.

- Kegley, WV, USA

The clear coat on the front bumper of the car is peeling off. It is not localized to one area it spans about 75% of the front bumper like a scar of peeled clear coat.

- Washington, DC, USA

The contact owns a 2007 Toyota Tacoma. The contact stated that the rear bumper reinforcement bar that was attached to the frame became corroded. The manufacturer was not made aware of the failure. The vehicle was not repaired. The approximate failure mileage was 61,000.

- Kingsville, OH, USA

The contact owns a 2007 Toyota Tacoma. The contact stated that the frame snapped while driving 30 mph, causing the vehicle to become difficult to stop when braking. The contact also stated that the vehicle accelerated without warning. The contact called the manufacturer regarding any recalls for the vehicle. The manufacturer advised the contact that the VIN was included in every recall listed for the year, make and model including NHTSA campaign id number: 09V388000 (vehicle speed control). The manufacturer informed the contact to set up an appointment with an authorized dealer to have the recall service performed on the vehicle. The failure mileage was 135,553.

- El Paso, TX, USA

The contact owns a 2007 Toyota Tacoma. The contact stated that the vehicle was taken for routine service when the mechanic advised that the frame was rusted. The manufacturer was contacted and advised the contact that there were no recalls for the failure. The failure and the current mileage was 63,400.

- Savannah , GA, USA

Truck was in a parking slot when it suddenly accelerated and jumped the concrete barrier and hit the building (deli) broke the glass and damaged building. Airbag did not deploy. Damage to truck was $6533.97. This is second time truck has accelerated unexpectedly. Toyota inspected it on 6/25/2012 and determined it was not a manufacture design or defect. I believe there is some kind of malfunction. They checked the operation of the accelerator pedal and they claim all throttle tests were safe as they were designed.

- Stockton, CA, USA

2007 Toyota Tacoma...bumper is rusting through metal. Manufacturer Toyota will not honor body rust warranty. Have noticed other owners complaining of shoddy materials being used in the manufacture of chrome bumpers.

- Winchester, MA, USA