CarComplaints.com Notes: The 2002 Ford Explorer is hands-down our worst vehicle on record. "Avoid like the plague" is putting it lightly.

The 2002-2005 Explorer has a very well-established record of expensive transmission failure at under 100k miles. The Explorer has an enclosed transmission which is typically replaced with a rebuilt transmission at a cost of almost $3,000.

Another common problem for the 2002-2003 Explorer is wheel bearing failure at around 90k miles, with a typical repair bill of $500 to $1000 depending on how many wheel bearings failed.

Adding insult to injury, the 2002-2005 Explorer also has a massive problem with the rear panel cracking. While it's a minor annoyance compared to transmission failure, ironically the crack usually goes right through the Ford logo.

6.0

fairly significant
Typical Repair Cost:
$250.00
Average Mileage:
88,000 miles
Total Complaints:
1 complaints

Most Common Solutions:

  1. new harness installed (1 reports)
2002 Ford Explorer seat belts / air bags problems

seat belts / air bags problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2002 Ford Explorer:

Unsubscribe any time. We don't sell/share your email.

2002 Ford Explorer Owner Comments

problem #1

Sep 042012

Explorer XLT V6

  • Automatic transmission
  • 88,000 miles

A D V E R T I S E M E N T S

just another of the 20 major problems with this car.

- , Saginaw, MI, USA

Not what you are looking for?