TSB List for the 2002 Volkswagen Passat
The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB title & date, & either contact your local dealer or click on the links below.
STEERING:HYDRAULIC POWER ASSIST:PUMP
-
TSB #092603
NHTSA ID #10006830
Summary: ZF VH RECALL OF THE ZF STEERING PUMP, SUPPLIED TO WD'S FOR REPLACEMENT OF THE AUDI A4 PASSAT P/N 8D0 145 156FX INSTEAD OF THE CORRECT ZF P/N 7691 955 276ZW. 2004 AUDI A4 ALSO INCLUDED. *TT
SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
-
TSB #P 9-66C8
NHTSA ID #10025923
Summary: VOLKSWAGEN: 2001-2005 MODELS: SERVICE AIR PLENUM AREA TO IMPROVE DRAINAGE AND INSTALL IMPROVED POLLEN FILTER SEAL. WATER COULD LEAK INTO THE PASSENGER COMPARTMENT. 2002 MODELS COULD HAVE LEAKS INTO THE BRAKE BOOSTER. *PE
SERVICE BRAKES, HYDRAULIC:ANTILOCK
-
TSB #0206
NHTSA ID #10000560
Summary: DIAGNOSTIC TROUBLE CODES 00778 AND 01044 STORED IN BRAKE ELECTRONICS DIAGNOSTIC TROUBLE CODE MEMORY. *TT
SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE
-
TSB #0517
NHTSA ID #10016037
Summary: ANTI-LOCK BRAKE SYSTEM (ABS) CONTROL MODULE WARRANTY REPAIR PROCESS. *TT
ENGINE AND ENGINE COOLING
-
TSB #004
NHTSA ID #10011567
Summary: ENGINE COOLANT TEMPERATURE (ECT) SENSOR. *TC
ENGINE AND ENGINE COOLING:ENGINE
-
TSB #ESA-10C5(NS)
NHTSA ID #10041251
Summary: VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. 2002 PASSAT. THE MALFUNCTION LIGHT MAY BE ON. THERE MAY BE OIL LEAKAGE OR ENGINE STARTING PROBLEMS DUE TO A CRACKED OR BROKEN CRANKCASE BREATHER HOSE. *RM
-
TSB #SAC-28F3/P1-REV
NHTSA ID #10036496
Summary: VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. MODELS PASSAT AND WAGON; GOLF; GTI; JETTA A
-
TSB #SB-28F3
NHTSA ID #10033207
Summary: VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PER
-
TSB #TB-07-09-06
NHTSA ID #10030369
Summary: VOLKSWAGEN: ENGINE OIL PRESSURE TOO LOW, LIGHT IS ON, ENGINE FLUSH. THE LOW ENGINE OIL PRESSURE CONDITION MAY BE CAUSED BY A RESTRICTION OF THE OIL PUMP SUCTION LINE STRAINER. *PE
-
TSB #2013233
NHTSA ID #10021437
Summary: ENGINE OIL PRESSURE TOO LOW, LIGHT IS ON, ENGINE FLUSH. *KB
-
TSB #0401
NHTSA ID #10009887
Summary: ENGINE OIL SPECIFICATIONS, OIL CAPACITY, OIL FILTER. *TT
-
TSB #0403
NHTSA ID #10010539
Summary: VALVE COVER, DIAGNOSING OIL LEAKAGE FROM GASKETS. *TT
-
TSB #0402
NHTSA ID #10009888
Summary: LOW ENGINE OIL PRESSURE LIGHT IS ON. *TT
-
TSB #0421
NHTSA ID #10009874
Summary: OIL SLUDGE - WARRANTY EXTENSION FOR 1998-2004 MODEL YEAR VOLKSWAGEN PASSAT WITH 1.8L TURBO ENGINE US AND CANADIAN DEALERS. SERVICE CIRCULAR. *TT
-
TSB #0421
NHTSA ID #10009873
Summary: WARRANTY EXTENSION COVERING CERTAIN OIL SLUDGE RELATED REPAIRS. *TT
-
TSB #0403
NHTSA ID #10008913
Summary: ENGINE, FLUCTUATING IDLE OR IDLE SPEED TOO LOW. *MJ
-
TSB #0409
NHTSA ID #10007711
Summary: EVALUATING FUEL MIXTURE DIAGNOSTIC TROUBLE CODES- HOW TO PERFORM EFFECTIVE DIAGNOSIS RELATED TO FUEL SYSTEM ADAPTATION - SYSTEM TOO RICH/TOO LEAN. VOLKSWAGEN. *MJ
-
TSB #0303
NHTSA ID #10001568
Summary: UPDATE PROGRAMMING (FLASHING) ENGINE CONTROL MODULE (ECM) AND TRANSMISSION CONTROL MODULE (TCM). *TT
-
TSB #0301
NHTSA ID #10000917
Summary: UPDATE PROGRAMMING (FLASHING) ENGINE CONTROL MODULE (ECM) TO CORRECT COLD START MISFIRE. *TT
-
TSB #0208
NHTSA ID #10000814
Summary: UPDATE PROGRAMMING (FLASHING) ELECTRONIC CONTROL MODULE (ECM) TO CORRECT COLD START MISFIRE. *TT
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
-
TSB #SA-28F3
NHTSA ID #10033216
Summary: VOLKSWAGEN: (REVISED) VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT VEHICLE MAY EXPERIENCE SOME DETERIORATION
ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSE
-
TSB #010702
NHTSA ID #10021315
Summary: DTC'S P1297 (17705) OR P1557 (17965) STORED IN DTC MEMORY. THIS MAY BE CAUSED BY INTAKE HOSES LEAKING (DURING BOOST CONDITIONS) DUE TO INCORRECT TORQUE ON CLAMPS OR IMPROPER PLACEMENT, WORN OR TORN INTAKE HOSES. *KB
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
-
TSB #2015831
NHTSA ID #10026848
Summary: VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
-
TSB #SAC-28F3/P1-REV
NHTSA ID #10036496
Summary: VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. MODELS PASSAT AND WAGON; GOLF; GTI; JETTA A
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
-
TSB #ESA-10C5(NS)
NHTSA ID #10041251
Summary: VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. 2002 PASSAT. THE MALFUNCTION LIGHT MAY BE ON. THERE MAY BE OIL LEAKAGE OR ENGINE STARTING PROBLEMS DUE TO A CRACKED OR BROKEN CRANKCASE BREATHER HOSE. *RM
ELECTRICAL SYSTEM
-
TSB #0502
NHTSA ID #10012457
Summary: DIAGNOSTIC TROUBLE CODE (DTC) P1603 (18011) STORED IN DTC MEMORY. *TT
ELECTRICAL SYSTEM:IGNITION
-
TSB #SAC-28F3/P1-REV
NHTSA ID #10036496
Summary: VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. MODELS PASSAT AND WAGON; GOLF; GTI; JETTA A
-
TSB #SA-28F3
NHTSA ID #10033216
Summary: VOLKSWAGEN: (REVISED) VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT VEHICLE MAY EXPERIENCE SOME DETERIORATION
-
TSB #SB-28F3
NHTSA ID #10033207
Summary: VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PER
-
TSB #WG
NHTSA ID #10005665
Summary: REPLACEMENT OF THE IGNITION COILS. IT IS POSSIBLE THAT IF ONE OF THE VEHICLE'S IGNITION COIL FAILS, ROUGH IDLING OR REDUCED DRIVING POWER COULD OCCUR IN ADDITION TO ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP LIGHT. *TT *MJ
-
TSB #013103
NHTSA ID #10000868
Summary: IGNITION COIL MALFUNCTION. *TT
-
TSB #013003
NHTSA ID #10000559
Summary: IGNITION COIL FAILURE. *TT
VISIBILITY:WINDSHIELD WIPER/WASHER
-
TSB #2002419
NHTSA ID #10021958
Summary: INTERMITTENT WINDSHIELD WIPER, WIPES ACROSS WINDSHIELD ONCE THEN STOPS. *KB
STRUCTURE
-
TSB #P-9-99C8
NHTSA ID #10026068
Summary: VOLKSWAGEN: SERVICE AIR PLENUM AREA TO IMPROVE DRAINAGE AND INSTALL IMPROVED POLLEN FILTER SEAL. *PE
STRUCTURE:FRAME AND MEMBERS
-
TSB #P-9-99C8
NHTSA ID #10026068
Summary: VOLKSWAGEN: SERVICE AIR PLENUM AREA TO IMPROVE DRAINAGE AND INSTALL IMPROVED POLLEN FILTER SEAL. *PE
-
TSB #P 9-66C8
NHTSA ID #10025923
Summary: VOLKSWAGEN: 2001-2005 MODELS: SERVICE AIR PLENUM AREA TO IMPROVE DRAINAGE AND INSTALL IMPROVED POLLEN FILTER SEAL. WATER COULD LEAK INTO THE PASSENGER COMPARTMENT. 2002 MODELS COULD HAVE LEAKS INTO THE BRAKE BOOSTER. *PE
STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
-
TSB #2015831
NHTSA ID #10026848
Summary: VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE
STRUCTURE:BODY
-
TSB #P-9-99C8
NHTSA ID #10026068
Summary: VOLKSWAGEN: SERVICE AIR PLENUM AREA TO IMPROVE DRAINAGE AND INSTALL IMPROVED POLLEN FILTER SEAL. *PE
-
TSB #0201
NHTSA ID #10000543
Summary: RADIATOR GRILLE RUNNING CHANGE. *TT
SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
-
TSB #060910
NHTSA ID #10031384
Summary: VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. REVISED EXPIRATION DATES FOR SEAT HEATER CUSTOMER SATISFACTION CAMPAIGNS. AFFECTED VEHICLES MAY HAVE A SEAT HEATER ELEMENT THAN CAN MALFUNCTION WHEN THE IGNITION SW
-
TSB #M3M300
NHTSA ID #10025969
Summary: VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INSTALL NEW PASSENGER SIDE SEAT HEATER SWITCH. *PE CSC LETTER WAS ADDED TO BULLETIN. 10/20/08. *PE UPDATED 3/30/09. *PE _x000D_ UPDATED 3/17/10. *
-
TSB #M2M200
NHTSA ID #10025968
Summary: VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INSTALL DRIVER'S SIDE SEAT HEATER REPAIR KIT. CAMPAIGN EXPIRATION DATE IS EXTENDED TO 6/30/09. *PE CSC LETTER WAS ADDED TO BULLETIN. 10/20/08. *PE UP
-
TSB #2
NHTSA ID #10019324
Summary: HEATED SEATS MAY HAVE A SEAT HEATER ELEMENT THAT CAN MALFUNCTION WHEN THE IGNITION SWITCH IS ON AND THE SEAT HEATER SWITCH IS ON. INSTALL DRIVER'S SIDE SEAT HEATER REPAIR KIT. *TT UPDATED 2/20/08. *NJ
-
TSB #M3
NHTSA ID #10018809
Summary: CUSTOMER SATISFACTION CAMPAIGN CIRCULAR - SEAT HEATER ELEMENT CAN MALFUNCTION WHEN THE IGNITION SWITCH IS ON AND THE SEAT HEATER SWITCH IS ON. THE SEAT HEATER MAT MAY TEMPORARILY OVERHEAT AND BECOME INOPERATIVE. INSTALL NEW PASSENGER SIDE
-
TSB #720702
NHTSA ID #10021951
Summary: SEAT HEATER IS INOPERATIVE. *KB
-
TSB #0601
NHTSA ID #10020719
Summary: HEATED SEAT BOTTOM COVER REPLACEMENT. *KB
EQUIPMENT:OTHER:LABELS
-
TSB #VC
NHTSA ID #10015584
Summary: INSTALL MERCURY LABEL ON VEHICLES REGISTERED IN THE STATES OF VERMONT, MAINE AND CONNECTICUT - ENVIRONMENTAL COMPLIANCE ACTION CIRCULAR. *TT
CHILD SEAT:LATCH CONNECTOR
-
TSB #TB-00-10-06
NHTSA ID #10036493
Summary: VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE
CHILD SEAT:VEHICLE LATCH ANCHOR
-
TSB #TB-00-10-06
NHTSA ID #10036493
Summary: VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE
UNKNOWN OR OTHER
-
TSB #9
NHTSA ID #10023693
Summary: 2002 MODEL YEAR PASSAT AND PASSAT WAGON - SERVICE THE AIR PLENUM AREA TO IMPROVE DRAINAGE AND INSTALL IMPROVED POLLEN FILTER SEAL. *NJ
Browse Other Passat Years
- 2012 Volkswagen Passat
- 2011 Volkswagen Passat
- 2010 Volkswagen Passat
- 2009 Volkswagen Passat
- 2008 Volkswagen Passat
- 2007 Volkswagen Passat
- 2006 Volkswagen Passat