Within the past year we have had multiple system failures with our 1999 Chevrolet Malibu with 47,000 miles. The intake manifold gasket has leaked, the brake pads, rotors, and wheel cylinders were repaired, the theft deterrent system and ABS warning lights come on repeatedly, and the alternator and water pump have failed. The passlock sensor and body control module have been replaced to address the theft system warning light and the harness and individual wheel speed sensors have been suggested for the ABS warning light. Chevrolet should be requred to recall the vehicle to address some or all of these problems.

- Herndon, VA, USA

I had frequent loss of coolant, and drips on my driveway surface. Upon taking to dealer I was informed that intake gasket leaking. Also I was told brakes were almost gone. At 53,000 miles this seemed excessive on both counts. The replacement of the intake gasket was about $700. Replacing the pads and turning rotors cost $250. This makes the 3rd set of pads, and resurfacing of the second set of rotors since I bought the car new. Shortly after the repairs the ABS light started coming on whenever making a turn. Brought the car into the dealer in may and was told that the front wheel bearing assy needed to be replaced. I was also told that this occurance had nothing to do with the recent brake job, even though there were no problems until I had the brake job done at their recommendation. The dealer, while acknowleding no blame paid 50% of the repair leaving me with a $200 bill. In little more that 30 days I have spent $1200 on critical part repairs for a well maintained car with only 53000 miles.

- South Portland, ME, USA

This 1999 Chevrolet Malibu was purchased in July 2001 in had a water leaking problem took 3 tries before they found it needed thermostat gasket didn't even have one in it they sold it to me.this way with a promise it had been fixed. Within the first year I had the car they had to replace both front wheel bearings & strut bushings. Then the alternator went out & it cause my battery to go bad overcharged it they replaced alternator but refused to re-emburse me for the battery. Then ignition switch caused problem with anti-theft system would not start. Had that replaced in March 2002. Then anti-lock brake system went out had to have it replaced window switch very slow had to be cleaned another one not working at all now, not covered under warranty, at this time also had to have anti theft system fixed again light on all the time another bad ignition switch. Also had blower motor & relay switch for heater to go out over the summer most of the interior lights have long ago burnt out & had to be replaced lock out for trunk lid also broke not covered on warranty. Hub caps have lug nuts made in them that screw onto your lug bolts stripped out when took for repairs by dealer refused to replace them because they cost $500 for a new set. So I purchased the lug nut part & repalced it myself at a dealership for $10 set of 5. November of 2002 brakes & rotors were replaced in Jan. 2003 brake pads replaced again in March 2003 pads replaced again in July 2003 pads replaced once again then in Sept. 2003 master cylinder replaced in Oct. 2003 master cylinder replaced again now it's Nov 2003 & master cylinder being replaced again tomorrow.these cars have a real brake problem that needs to be fixed it's costing a fortune.

- Junior, WV, USA