Print this page


hardly worth mentioning
Crashes / Fires:
0 / 1
Injuries / Deaths:
0 / 0
Average Mileage:
74,000 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2004 Chevrolet Tahoe cooling system problems

cooling system problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2004 Chevrolet Tahoe:

Unsubscribe any time. We don't sell/share your email.

2004 Chevrolet Tahoe Owner Comments

problem #3

Jul 162011

Tahoe 4WD 8-cyl

  • 103,000 miles


Blower resistor caught fire inside of the vehicle on passenger side where it plugs into the front blower motor.

- West Henrietta, NY, USA

problem #2

Sep 022008


  • 79,000 miles
2004 Tahoe, 79,000 miles. Engine overheated which could have caused fire if I had not noticed and stopped. GM dealer says overheaing due to crack in cylinder head and confirmed tsb 06-06-01-019B (06/12/2007) applies to vehicle, which admits there is known manufacturing defect in certain cylinder heads which can cause engine coolant to leak internally causing overheating and potential engine failure. Dealer refuses to cover repair. I have pending complaint with GM customer service to pay for damage. I think this should be a recall as it can lead to overheating, engine failure and potential fire. There are multiple reports on internet of same problems by other owners.

- Little Rock , AR, USA

problem #1

Jul 102006

Tahoe 8-cyl

  • Automatic transmission
  • 40,000 miles
Electrical panel does not work properly. Have not had a correct reading in months.

- Round Rock, TX, USA

Search for these popular complaint phrases...

Not what you are looking for?