hardly worth mentioning
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
98,250 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2004 Dodge Grand Caravan fuel system problems

fuel system problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2004 Dodge Grand Caravan:

Unsubscribe any time. We don't sell/share your email.

2004 Dodge Grand Caravan Owner Comments (Page 2 of 2)

« Read the previous 20 complaints

problem #4

Dec 182011

Grand Caravan

  • 87,000 miles


The contact owns a 2004 Dodge Grand Caravan. The contact stated that when the vehicle was being refueled to capacity, the fuel level indicator would not register the amount of fuel in the vehicle. The vehicle was taken to the dealer, who stated that they would have to replace the fuel tank. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 87,000.

- Middletown, IL, USA

problem #3

Nov 082012

Grand Caravan

  • 47,000 miles
The contact owns a 2004 Dodge Grand Caravan. The contact stated that fuel fumes were emitted into the vehicle. The contact exited the vehicle and noticed a small leakage. The vehicle was taken to an independent mechanic for inspection who stated that the fuel injector rail needed to be replaced. The vehicle was not repaired. The manufacturer was notified and they stated that there was no recall on the vehicle. The failure mileage was 47,000.

- Wilmington, NC, USA

problem #2

Sep 212012

Grand Caravan 6-cyl

  • 88,000 miles
Fuel leak from fuel tank at the fuel pump very close to the exhaust!!!!

- Springfield, VA, USA

problem #1

Jun 012011

Grand Caravan 6-cyl

  • 75,000 miles
For a year or so my wife and I could smell gasoline fumes in the garage at night. I checked engine gas filler under car, but was unable to identify source of gasoline fumes. Finally about w week ago the smell of fumes was stronger. I looked under the car and noticed a wet spot on garage floor. I put the car on jacks crawled under the car and could see fuel oozing from a fitting on fuel line that was connected to the top of the tank. This fitting is some sort of quick disconnect in which you can turn easily on the white plastic fitting on top of the tank. We are now parking auto outside fearing the fumes could ignite in the garage from hot water heater. Is there a possible recall on this problem?

- Texas City, TX, USA

Not what you are looking for?