Power Door Locks Not Working

2005 Dodge Grand Caravan (Page 2 of 9)

This problem may be covered under warranty. Ask your Dodge dealer.

CarComplaints.com Seal Of This Might Hurt


fairly significant
Typical Repair Cost:
Average Mileage:
72,750 miles
Total Complaints:
164 complaints

Most Common Solutions:

  1. not sure (66 reports)
  2. remove & reinsert the 20 amp iod fuse (53 reports)
  3. disconnected battery for 1 minute (12 reports)
  4. remove and reinsert BCM #1 fuse (7 reports)
  5. update firmware in body control module (BCM) (7 reports)
  6. dealer charged me to reflash the computer (4 reports)
2005 Dodge Grand Caravan accessories - interior problems

accessories - interior problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2005 Dodge Grand Caravan:

Unsubscribe any time. We don't sell/share your email.

2005 Dodge Grand Caravan Owner Comments (Page 2 of 9)

« Read the previous 20 complaints

problem #144

Aug 012013

Grand Caravan SXT 3.8L

  • Automatic transmission
  • 132,000 miles


The door locks stopped working a couple of months ago. Nothing opens/closes them- door switch, key fob, driving over 20mph. Found the IOD fuse fix online, pulled it, locks worked for a month before they stopped again. Fixed again with IOD pull. Each time the locks have worked for shorter and shorter time periods and now they stop working as soon as the engine goes off. Already reported this issue to NHTSA.

- Lily F., Portland, OR, US

problem #143

Aug 022013

Grand Caravan

  • Automatic transmission
  • 80,778 miles

I had same problem power lock not working for 2 yrs now, just 2 months ago my husband connect extra cable from battery negative to body part of the van for better ground, and that fixed the problem since, i did post following message to other site for people to know how to fix it.

(To all of you who have problem on power lock not working issue on caravan, POWER LOCK CAN BE FIXED with simple, just connect extra cable from negative (-) battery to any body part ground of your van.)

- Imelda G., Brampton, ON, canada

problem #142

Jan 242013

Grand Caravan SXT 3.8L V6

  • Automatic transmission
  • 79,090 miles

I Can't beleive that Dodge hasn't done a recall on this if it's such a known problem. I love my Dodge, have had 3 of them. I have never had this problem with any of them except this one. It started when I replaced my battery. Thank God I married a Mechanic lol Hope Dodge does something about this. I am complaining to them and SafeCar.

- Carrie P., North Kingstown, RI, US

problem #141

Oct 102012

Grand Caravan Special Edition 3.8L V6

  • Automatic transmission
  • 60,000 miles


Doors won't lock with fob have to lock them each by hand also automatic locking of all doors at app. 20 miles an hour does not work either . I read about pulling 20 amp fuse out then putting it back in it worked . it lasted about 2 weeks then happened again, did the same thing with the fuse it worked again for about 3 weeks then stopped working again, pulled fuse and put back in it worked again for about 2 weeks . it quit working on dec.4 pulled fuse again and put it back in it worked but only one day this time. now it has happened on the 5th,6th,7th,and today the 8th of DEC.

- Glendon A., Madison Heights, MI, US

problem #140

Jul 012011

Grand Caravan V6

  • Automatic transmission
  • 80,000 miles

Car dome lights came on when I had stopped van. I checked all doors; none were left open. Doors would not lock inside or outside, with remote, manually or with key. I even tried to push down manual lock knob at the top near window. Good thing I left the window down because the key wouldn't work (manually or with remote). I would have been locked out of the van. I have never had vehicle whereby the key would not unlock the car manually either. This was really scary; now nothing is secure inside the van. Took to dealer and it stayed in shop for over 3 months, worked for 2 months, then remote locks and internal locks don't work again. Afraid to lock with key now because may not be able to unlock it. Also, have had continuous problems with brakes wearing a lot, transmission cooler leaked and had to be replaced, problems with sliding doors, etc., etc., etc. I like ease of getting in and out of van due to my knee problems and disabilities, but I can't afford to trade it or dump it and get something else like a Toyota Highlander!

- eglenn, Knoxville, TN, US

problem #139

Mar 152012

Grand Caravan XLT

  • Automatic transmission
  • 82,300 miles

Had the computer reset at Doge Dealer today. Wish I would have found this site first. 5 hours later the drivers side passenger door stopped locking and unlocking. Gonna call the dealer and raise heck tomorrow.

- herd0ne, St Marys, WV, US

problem #138

Apr 242012

Grand Caravan

  • Automatic transmission
  • 131,000 miles


I had the same problem as everyone else, and sure enough, it turned out to be fixed by reprogramming the BCM as per TSB 08-040-04. My beef is that this is a DEFECT in the original programming, and that Dodge recognizes the defect since they came up with the solution in the TSB (which is a fix, not an upgrade.) Since it is a safety issue for doors not to lock while driving, it should be a recall and I should not have to pay the $137 to fix it.

I agree with those who say that if many people complain to Dodge and to NHTSA, they may listen and still make it a recall. I did call the NHTSA (1-888-327-4236) and they seem to be taking it seriously.

- Virginia J., Harleysville, PA, US

problem #137

Sep 102011

Grand Caravan V6

  • Automatic transmission
  • 67,000 miles

I bought this van 3 months before the locks decided to stop working. Worst part of the whole thing is the horn would go off every time I got into the van. The doors would not lock while traveling down the road. There is only 1 door that you can lock / unlock with a key. Took van to a neighborhood repair shop. We were told this vehicle is noted for this problem. Van was "fixed" by re-programing. Only lasted 5 months and it has happened again. See next complaint.

- Donna M., Elma, NY, US

problem #136

Aug 012012

Grand Caravan SXT 3.8L V6

  • Automatic transmission
  • 83,000 miles

Same old same old with the power door locks which is widespread. This was the first of about 3 times, but I'm not going to report the other 2. Internet research said to pull the IOD fuse for a few seconds and replace. It works, but it also wipes out the radio programming each time. Maybe it won't do it again. Yeah, right.

Update from Apr 29, 2015: At 98K now, and only one other failure I can remember. Now will probably do it again tomorrow.

Update from Jun 11, 2015: Around May 28 15 locks quit again. Pulled the IOD, reset the radio programming again.

- Raymond L., Columbia, SC, US

problem #135

Feb 212012

Grand Caravan V6

  • Automatic transmission
  • 74,000 miles

It seems to be a repeat of the problem that was "fixed" 5 months ago. Is this a problem we will continue to have every few months re-programing the unit, or is there a permanent fix? We have an appointment for Saturday am. I am not happy !

- Donna M., Elma, NY, US

problem #134

Jun 082011

Grand Caravan SXT 3.3L V6

  • Automatic transmission
  • 95,000 miles


x@#$%^&*@#$%#@$ Dodge anyway!!!!! Locks quit working electrically. First the dealer said it was a switch on the drivers side, but that proved to be wrong. I told them that I removed the iod module and it worked for a while and then quit again. They checked all wiring and now say that I may need to change the BCM, which is very expensive. I am out of warranty. This should have been a recall and Dodge should do the right thing by their customers.

- beavefrmn, Longview, WA, US

problem #133

Dec 312011

Grand Caravan SXT Limited Edition 3.8L V6

  • Automatic transmission
  • 83,411 miles

Just bought this vehicle but noticed an issue with the sliding door while we were looking at it. We told the dealer that we wanted it fixed before purchasing. They removed the IOD fuse and replaced it...and it appeared to solve the issue. That is, until we got home! As soon as we got home, the power door locks failed. I found this website and used the IOD fuse trick again. Just had the local Dodge dealer update the firmware to see if the problem goes away permanently. Will report back!

Update from Mar 22, 2012: Updating the firmware has resolved this issue completely for us. It cost us $100, but have not had a single failure since.

- Jason F., Broken Arrow, OK, US

problem #132

Aug 232011

Grand Caravan 3.3L V6

  • Automatic transmission
  • 168,000 miles

I bought a 1993 plain jane caravan 10 years ago, it had no bells and whistles to go wrong but I had to repair the transmission 3 times and replaced the a/c pump once. I foolishly bought a 2000 caravan with a few options; pdl, pw. True to the nature of Dodge both stopped working so I got rid of it. Third time fool, bought a 2005 caravan, rear door lock quit working and have to use the key to open the hatch (not really handy in the winter when the keyhole is covered in snow), passenger side window won,t work most of the time and heater fan motor works most of the time but not all of the time. I work at a Diamler chrysler industrial dealership now and realize it is not a Dodge problem as much as it is a Diamler problem as I am learning that almost all divisions of Diamler products have the same pathetic wiring and electrical problems. I say almost all divisions not because they don't ALL have the same problems but because I only have had first hand experience with three divisions; all suck. What are the chances that the only three I've had experience with are the only three with these problems. I have been a Mechanic for 24 years now, when I first started this trade the last problem that was suspect was the control modules or the computer. Most of the current troubleshooting now starts with replace module with known good one (like everyone has a spare of everything laying around) and retest. Second step is check or replace wiring harness and third is contact your dealer who is as much in the dark as you. The only reason I bought a Dodge three times is because they were the least expensive, turns out they were the most cheaply build too.

- R H., Grande Prairie, AB, Canada

problem #131

Aug 092011

Grand Caravan ES V6

  • Automatic transmission
  • 105,000 miles

I am so glad I found this information. I have also had many issues with my van, not as many as some I have read about. My power lock just stopped working one day. I purchased a new battery as it was time for a new one. My locks worked for 2 days, then they didn't again. It is very frustrating having to manually open all the doors. Here is one suggestion. I did not lose all function, the back hatch never had an issue, just the side doors and the power buttons on the inside doors not working. 1 Tip I found out. if you do not click the lock button on the key, your back hatch although it sounds like it is locking , does not. you need to push the key to lock the back hatch. Pretty scary when I discovered this after holiday shopping. I did not know about the IOD fuse. I just went and tried it and my locks are working again. Lets see for how long.... You would think with the number of complaints a recall would have been issued long ago.. I will keep my post updated as to how long the IOD fuse take out and put back lasts.

- Marcella M., Brandon, FL, US

problem #130

Dec 012011

Grand Caravan v6

  • Automatic transmission
  • 131,100 miles

Power lock's not working , the interior lock button's will not work, and the button on the key will not work?

Update from Oct 7, 2012: The rear passeger side door will not open. i checked all the fuse's , when i press the key fob it sounds like it's opnin , but it's not.

- gina1974, Redford, MI, US

problem #129

Oct 192011

Grand Caravan SXT 3.9L V6

  • Automatic transmission
  • 75,000 miles

Same issues as everyone else. My gripe is when side rear doors are locked its hard from a wheelchair to reach interior door lock to unlock.

- 1971wheels, Reynoldsburg, OH, US

problem #128

Sep 192009

Grand Caravan

  • Automatic transmission
  • 40,000 miles

2-3 times a week, my auto locks stop working. Have to lock and unlock all the doors manually and there is only a keyhole for the doors on the drivers side. Not helpful for a family vehicle

- cwhitey, West Jordan, UT, US

problem #127

Oct 112010

Grand Caravan SE 3.3L

  • Automatic transmission
  • 36,040 miles

Power door locks fail to operate from the key remote, or the door switch. have tried removing & replacing the fuse, diconnecting the battery. both have worked for a short period, but the problem comes back. Dodge has toquit hiding from this issue & do something about this problem.

- Matt B., Summerland, BC, canada

problem #126

Aug 012010

Grand Caravan SXT 3.8L V6

  • Automatic transmission
  • 98,000 miles

Have been very satisfied with our 2005 Grand Caravan. It now has 115000 miles on it, have changed tranny oil every 50000 miles, engine oil every 3-5000 miles. I would pull the fuse and re-set the lock problem which would last weeks into months. Recently it would trip within the day on a regular basis, so I took it to local dealer, cost to upgrade software in body control module was $21 plus tax, small price to pay in my book. Another common problem with this vintage of Dodge/Chrysler was replacing the tie-rod ends which I had to do at 90,000 miles, but replaced with lifetime warrantied ones at an independent repair shop, so they shouldn't be a problem anymore. Driver's side sliding door wire loom has been replaced twice, but with 4 kids using that door over and over again, it doesn't surprise me. I replaced the front and rear brake pads myself at 90,000 and 108,000 respectively. It gets excellent mileage on the open road, 25 mpg typically, depending how you drive. Piddling around town or poor driving habits will affect mpg like any other vehicle. When we are ready to sell or trade, we will buy another Dodge/Chrysler van. Is developing rust on bottom in front of rear wheels and on bottom behind front wheels right where the body begins to flatten out, so check this out if you live in wintery area..

- Tim M., Nashua, IA, US

problem #125

Aug 102011

Grand Caravan SXT 3.2L V6

  • Automatic transmission
  • 162,000 miles

This problem actually started a few months ago when the powerlocks just quit working. I thought it might be a fuse so I took it to Auto Zone, they pulled fuses trying to find one and none were burnt, but when they put them back, the locks started to work again. This lasted about 6 weeks and then they went out again, I pulled the same fuse and again they worked again for a few weeks. Finally they went out and pulling the fuse did nothing so I took it to a dealer. They replaced the motor. One week later they stopped working again and I called and took it back about one week later. They replaced the motor on the other side. 2 weeks later they stopped working again. I took it back there this past Wednesday, they reset the computer but said I needed to have my actuater replaced. Today, I put in a search for 2005 Dodge Grand Caravan power locks and found this site with 85 complaints. I then searched for Dodge customer service and found this number: 800-423-6343. I called and actually talked with a person and filed a complaint. He told me that there wasn't much info about this problem, so all of you out there with this problem need to call and file a complaint. I am hoping that they are really going to work through this with me as they took the name of the dealer that I have been going to and said they would be contacting them to find out what had been done thus far.

- Carletta W., Steubenville, OH, US

Read the next 20 complaints »

Not what you are looking for?