- September 22: Mazda Recalls Mazda6 Cars Because of 'Weld Spatter' recalls | 3 days ago
- September 11: Lane Departure and Blind Spot Warning Systems Really Work news | 14 days ago
- September 2: Mazda Recalls RX-8, Mazda6 and MazdaSpeed6 Cars Over Airbags recalls | 23 days ago
- August 15: Mazda Recalls CX-7, CX-9 and Mazda6 Over Takata Airbags recalls | 41 days ago
- July 30: Ford and Mazda Want Out of Takata Recall of 2.7 Million Airbags recalls | 57 days ago
2009 Mazda MAZDA6
6 Recalls & Safety Reports
Recall List for the 2009 Mazda MAZDA6
Official recalls have been issued for the 2009 Mazda MAZDA6 by the NHTSA. The complete details of all recalls are listed below, along with what they cover and the recommended solutions.
Recalls don't cost you anything to get fixed, but most are time-limited, so if your car is affected you should call your local Mazda service department immediately!
If you have questions about a recall, write down your VIN & then call Mazda customer service.
2009 Mazda MAZDA6 AIR BAGS, AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE NHTSA Campaign #16V594000
Summary: Mazda North American Operations (Mazda) is recalling certain model year 2009-2010 Mazda6 vehicles manufactured February 4, 2008, to December 3, 2009. The protective coating may not have been properly applied to the air bag control unit (ACU) and, as a result, moisture may damage the unit causing it to malfunction.
Consequence: Failure of the ACU would illuminate the air bag warning light and prevent the air bags from deploying in the event of a crash, increasing the risk of injury.
Actions: Mazda dealers will replace the ACU, free of charge, however parts are not currently available. The recall has begun but parts are not yet available. Mazda will mail a second notice when remedy parts are available. Owners may contact Mazda customer service at 1-800-222-5500. Mazda's number for this recall is 9816H. For detailed information & supporting documents, see the official NHTSA page concerning recall #16V594000 »
2009 Mazda MAZDA6 AIR BAGS:PASSENGER SIDE FRONTAL NHTSA Campaign #16V356000
Summary: Mazda North America Operations (Mazda) is recalling certain model year 2009-2011 Mazda6, 2007-2011 CX-7 and CX-9 vehicles, originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Mazda is recalling certain model year 2007-2008 CX-7 and CX-9 vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Actions: Mazda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began July 2016. Owners may contact Mazda customer service at 1-800-222-5500. Mazda's number for this recall is 9516E. For detailed information & supporting documents, see the official NHTSA page concerning recall #16V356000 »
2009 Mazda MAZDA6 LATCHES/LOCKS/LINKAGES:DOORS:LATCH NHTSA Campaign #13V425000
Summary: Mazda is recalling certain model year 2009-2013 Mazda6 vehicles manufactured February 4, 2008, through August 24, 2012. The door latch mounting screws may become loose.
Consequence: If all three door latch mounting screws become excessively loose the door latch mechanism would not engage and the door might open while the vehicle is in motion increasing the risk of accident or injury.
Actions: Mazda will notify owners, and dealers will apply a thread locking adhesive to the door screws and retorque them, free of charge. The recall began on October 29, 2013. Owners may contact Mazda at 1-800-222-5500. Mazda's recall number is 7013I. For detailed information & supporting documents, see the official NHTSA page concerning recall #13V425000 »
2009 Mazda MAZDA6 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY NHTSA Campaign #11V134000
Summary: Mazda is recalling certain model year 2009-2010 Mazda6 vehicles manufactured from April 8, 2008, through February 8, 2010. A certain type of spider may weave a web in the evaporative canister vent line and this may cause a restriction in the line. If this occurs, the fuel tank pressure may become excessively negative when the emission control system works to purge the vapors from the canister.
Consequence: As the canister is purged repeatedly during normal operation, the stress on the fuel tank may eventually result in a crack, potentially leading to fuel leakage ad an increased risk of fire.
Actions: Dealers will inspect and clean up the canister vent line, and install a spring to prevent this type of spider from entering the vent line. This service will be performed free of charge. The safety recall is expected to begin on or before March 25, 2011. Owners may contact Mazda customer assistance center at 1-800-222-5500. For detailed information & supporting documents, see the official NHTSA page concerning recall #11V134000 »
2009 Mazda MAZDA6 EQUIPMENT NHTSA Campaign #09E011000
Summary: Thule, Inc. Is recalling 2,323 owner-installed roof-mounted fit kits, models 3068 and 3069, manufactured between January 1, 2008 and February 28, 2009 that are used with thule podium foot packs, models 460 and 460R. These fit kits were sold as aftermarket equipment for use on the vehicles listed above. The bolt(s) used to secure the foot to the vehicle was manufactured to a hardness that may cause the bolt(s) to be brittle and potentially break under stress.
Consequence: This may result in the bolt(s) snapping off during use or without a load. The unsecured rack and load can then come loose while driving creating a potential road hazard, possibly resulting in a vehicle crash.
Actions: Thule will mail a retro fit kit along with repair instructions to owners free of charge. The safety recall is expected to begin on or before April 13, 2009. Owners may contact thule toll-free at 1-800-238-2388. For detailed information & supporting documents, see the official NHTSA page concerning recall #09E011000 »
2009 Mazda MAZDA6 STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS NHTSA Campaign #09V043000
Summary: Mazda is recalling 29,000 MY 2009 Mazda6. The outer door handles may stick which may prevent the door from latching. This situation may allow the door to open while the vehicle is in motion.
Consequence: Driving the vehicle with the door unlatched could lead to an unbelted occupant being ejected and could result in death or injury.
Actions: Dealers will inspect the door handles and if necessary repair or replace the handles free of charge. The recall began on February 13, 2009. Owners may contact Mazda at 1-800-222-5500. For detailed information & supporting documents, see the official NHTSA page concerning recall #09V043000 »