This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
The contact owns a 2018 Toyota Highlander. The contact stated that while driving uphill and depressing the accelerator pedal, the vehicle decelerated and rolled backwards unexpectedly. An independent mechanic was contacted. The vehicle was inspected by a mechanic friend and diagnosed with transmission failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 92,000.
The transmission makes a whining noise, especially when pulling, as in driving up an incline. I took the 2018 Highlander to Rusty Drewing Toyota in Jefferson City, MO to be diagnosed. They said the transmission needs to be replaced. In researching the problem, I found a bulletin/recall: 7A61K20482. The bulletin says the serial number must be before 7A617E03416. I want to get on your list and hopefully, be able to get some kind of relief for this problem.
The contact owns a 2018 Toyota Highlander. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power in the middle of the roadway. The contact stated that the RPM continued to increase rapidly, but the vehicle failed to respond. No warning lights were illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the washer tab, designed to prevent the loosening of the nut inside the transmission, resulting in damage to the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to the Customer Support Program: ZJC. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 104,000.
Transmission, whine rough shifting issues. Yes can be looked at. Tough to hear over the noise, harder to know when its going to change gears and increase speed due to slow/intermittent gear shifts. Yes they have a TSB from Toyota that descript the issue and Toyota has extend some vins warranty's for this issue but not for all affect vehicles apparently. No, not by any of those. Yes DTC have come on for awd system issues. Frist appear at 90K.
- North Ogden, UT, USA
Search CarComplaints.com for these popular complaint phrases...
The transmission on my 2018 Highlander is failing prematurely at 80k miles in alignment with known/published customer support program ZJC. My car is not a VIN covered by the program today. Symptoms include a growing whining sound coming from the transmission and confirmed by two Toyota dealership service centers.
The vehicle started having a whining noise in the transmission around 60,000 mi we took it to the Toyota dealership they said they couldn't hear anything He called Toyota itself The customer support program several times they have neglected it and it's getting worse
August 14, 2025 while coming home from work, truck started to lose power. It slowed down on the main street and then coasted to a complete stop in the middle of the road. There were no signals or alerts until it went dead. The vehicle will start, but it will not advance when put in drive. I have had the vehicle towed to my dealership to expedite diagnosing the issue.
The transmission has failed after only 39,000 miles. As a result, the vehicle would not accelerate which lead to a dangerous situation while crossing an intersection. No engine light was shown and no sensors were triggered on the onboard computer so it was impossible to know there was an issue.
While driving my 2018 Toyota Highlander (UA80F transmission), I began noticing a faint high-pitched whining noise between 25-?"45 mph around 63,000 miles. Over time, it progressively worsened, eventually including intermittent jerking and hard low-speed shifts, particularly during acceleration or uphill climbs. In wet conditions, the drivetrain lurches slightly under throttle, increasing risk of loss of control. I had a transmission fluid drain and fill service performed by a Toyota dealership at ~58,000 miles, along with full 4WD maintenance (differentials and transfer case). Despite this, symptoms developed shortly afterward. Toyota was notified and a corporate case was opened. I provided clear sound recordings, videos, and a full inspection history, and cited their Customer Support Program ZJC (POL19-04) for known defects related to UA80F whine and washer tab failures. Although my build date falls within the general failure range, Toyota refused coverage and claimed it was -??operating to spec.-?? Tier 1 support initially confirmed ZJC eligibility, but Tier 2 reversed course with no follow-up. Dealership service also failed to elevate the case properly to my Zurich warranty provider, who required dealer confirmation to proceed. Multiple other owners have reported similar failures around 60K-?"100K miles, and I believe this is a dangerous latent defect that Toyota is attempting to narrowly contain. Whining precedes jerking, and jerking precedes full failure. Many complainants, like me, are met with stall tactics, deflection, or no follow-through. There were no warning lights or diagnostic codes, but the safety risk is growing. I believe this transmission issue deserves expanded CSP eligibility and potential recall investigation.
Whining noise coming out from the tranmission and dealer recommended for transaxle to be remanufatured. The issue was on going with Toyota Customer Support Program for Transmission UA80 but my VIN is not covered upon checking with them
The contact owns a 2018 Toyota Highlander. The contact stated that while driving at various speeds and attempting to accelerate, the transmission whined abnormally loud. No warning light was illuminated. The vehicle was taken to a local dealer to be diagnosed. The contact was informed that the transmission needed to be replaced due to internal failures. The vehicle was not repaired because the warranty had expired. The manufacturer was notified of the failure by the local dealer. The failure mileage was approximately 107,000.
Transmission developed whine at 64,000 miles similar to the whine/issues experienced for customers covered under Toyota's ZJC Customer Support Program. My VIN was not in the range of impacted units, but had the same issue/failure.
Vehicle started making a whining noise and diagnosed at Lancaster Toyota as needing a new transmission at a cost of $8500. Ended up having transmission replaced at a local transmission repair shop for $7000.
I brought my car to the dealership due to a small whining noise when accelerating over 30mph. Technician determined the noise is coming from internal transmission failure and recommended replacement. The small whining noise was the only indication something was wrong. No check engine or warning lights on my dashboard. The car is under 50,000 miles at the time.
The 2018 Toyota Highlander has less than 100K miles on it and has been diagnosed with an $11K repair for essentially a new engine! The dealership (Coughlin Toyota, Heath OH) has said it needs cylinder head assembly for $10,684.20. The error message we are getting is a "Check Engine" light "Take Vehicle to Dealership" and the AWD/ Traction Control shuts off. When searching online forums, there are MANY people experiencing the same problem, apparently a well know issue with Toyota (not just Highlanders). We have only owned this vehicle for a few years and believe this is a manufacturer error that desperately needs investigated. Please.
My 2018 Highlander Transmission (8 speed model UA80) began a whine noise characteristic of Customer Support Bulletin POL19-04 when the vehicle hit 101k miles. Toyota performed an inspection on 8/9/2024 and recommends full transmission + transfer case replacement. The dealer confirmed also confirmed the issue is characteristic of POL19-04, but because the vehicle was manufactured 6-months after vehicles bracketed in POL19-04 (based on the transmission serial number) it is not included in the support program therefore not covered. Toyota UA80 transmissions have continued to have this issue (example - T-SB-0008-21 for '21 UA80 transmission). While Toyota acknowledges replacement of transmission is necessary to maintain a safe drivetrain, no customer-facing error messages are evident. Also note - transmission fluid has been maintained only using Toyota's recommended Fluid (Toyota branded WS ATF) at Toyota's specified intervals.
The contact owns a 2018 Toyota Highlander. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle was towed to the dealer where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 130,000.
Whining noise from transmission on 2018 Toyota Highlander XLE model. Toyota has acknowledged this on large numbers of vehicles manufactured during the same year (TSB-0160-18). They have a voluntary recall for some of these vehicles during this year (2018), but not all of them. The transmission can fail which would cause the vehicle to stop running. On a highway or busy road, this presents a very large danger to both the vehicle occupants and also other people on the road. The vehicle has been inspected by both the dealership an an independent transmission shop and identified as the same transmission issue. Toyota will not correct this issue other than to say the transmission needs to be replaced as it will fail at some point in time. No other warning indicators other than the whining sound from the transmission. The symptoms appeared around 48700 miles on the vehicle.
A D V E R T I S E M E N T S
- Easton, PA, USA