CarComplaints.com Notes: The 2002 Ford Explorer is hands-down our worst vehicle on record. "Avoid like the plague" is putting it lightly.

The 2002-2005 Explorer has a very well-established record of expensive transmission failure at under 100k miles. The Explorer has an enclosed transmission which is typically replaced with a rebuilt transmission at a cost of almost $3,000.

Another common problem for the 2002-2003 Explorer is wheel bearing failure at around 90k miles, with a typical repair bill of $500 to $1000 depending on how many wheel bearings failed.

Adding insult to injury, the 2002-2005 Explorer also has a massive problem with the rear panel cracking. While it's a minor annoyance compared to transmission failure, ironically the crack usually goes right through the Ford logo.

8.0

pretty bad
Typical Repair Cost:
No data
Average Mileage:
140,000 miles
Total Complaints:
1 complaints

Most Common Solutions:

  1. not sure (1 reports)
2002 Ford Explorer electrical problems

electrical problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2002 Ford Explorer:

Unsubscribe any time. We don't sell/share your email.

2002 Ford Explorer Owner Comments

problem #1

May 142014

Explorer Eddie Bauer

  • Automatic transmission
  • 140,000 miles

A D V E R T I S E M E N T S

The computer message will not clear. We have used an assessment device and followed the clearing procedure. The codes return.

- , Pace, FL, USA

[an error occurred while processing this directive]

Not what you are looking for?