CarComplaints.com Notes: The 2002 Ford Explorer is hands-down our worst vehicle on record. "Avoid like the plague" is putting it lightly.

The 2002-2005 Explorer has a very well-established record of expensive transmission failure at under 100k miles. The Explorer has an enclosed transmission which is typically replaced with a rebuilt transmission at a cost of almost $3,000.

Another common problem for the 2002-2003 Explorer is wheel bearing failure at around 90k miles, with a typical repair bill of $500 to $1000 depending on how many wheel bearings failed.

Adding insult to injury, the 2002-2005 Explorer also has a massive problem with the rear panel cracking. While it's a minor annoyance compared to transmission failure, ironically the crack usually goes right through the Ford logo.

4.0

definitely annoying
Typical Repair Cost:
No data
Average Mileage:
138,000 miles
Total Complaints:
1 complaints

Most Common Solutions:

  1. not sure (1 reports)
2002 Ford Explorer windows / windshield problems

windows / windshield problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2002 Ford Explorer:

Unsubscribe any time. We don't sell/share your email.

2002 Ford Explorer Owner Comments

problem #1

Apr 192005

Explorer XLS 4.0L

  • Automatic transmission
  • 138,000 miles

A D V E R T I S E M E N T S

I have had this car from new and would like to keep it for a longer time. This problem is an eye sore and I am fed up as I had this part replaced twice. Dealers said there are no recalls concerning this problem and it is expensive to repair and time consuming.

- , West Palm Beach, FL, USA

Not what you are looking for?