Notes: Most people need a car where the coil springs don't puncture or shred tires while driving. The Taurus fails in that respect.

The 1999-2003 Ford Taurus has a huge problem with coil springs breaking, which can puncture or even shred tires while driving.

The US government spent THREE YEARS (2008-2011) investigating the 2002-2003 Taurus coil springs. Although Taurus/Sable from earlier years were recalled, ultimately the NHTSA did not force a recall. They determined that because there had been no deaths & very few bad crashes & injuries, the broken coil springs defect was no big deal & not a safety defect. Tell that to all the owners who had close calls...


definitely annoying
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
21,900 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2002 Ford Taurus fuel system problems

fuel system problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2002 Ford Taurus:

Unsubscribe any time. We don't sell/share your email.

2002 Ford Taurus Owner Comments

problem #1

Feb 012003

Taurus 6-cyl

  • Manual transmission
  • 21,900 miles


Car was driven for approx. 100 miles, gas was low, so stopped to refill. When car was restarted, the car hesitated then sounded choked like it was not getting gas. Revved car to try to 'clear' system. Problem continued, at worst when idling. After a few minutes, engine light came on, so I turned off the car and called Ford dealer. Wrecker driver came out, revved car a few more times (approx. 3000 RPM) small backfire out of muffler each time. Problem seemed to go away. Wrecker driver blamed 'baffles' in muffler? drove car another 200 miles home. Three days later, after driving a bit, parked for short time then restarted car, same problem reoccurred.

- Royal Oak, MI, USA

Not what you are looking for?