- November 18: Jeep Grand Cherokee L and Wagoneer SUVs Recalled recalls | 17 days ago
- November 11: Jeep Wrangler 4xe Lawsuit Filed Over Check Engine Light news | 24 days ago
- October 22: Headlight Problems Cause Jeep Grand Cherokee L Recall recalls | 44 days ago
- September 26: Jeep Grand Cherokee L Recall: Rearview Camera Image Failures recalls | 70 days ago
- September 20: Jeep Wrangler 4xe Recall Needed, Alleges Class Action Lawsuit news | 76 days ago
Jeep Preliminary Evaluation PE11019: Airbag Clockspring Failure
2008 Jeep Wrangler
Airbag Clockspring Failure
Air Bags:Frontal:Driver Side:Inflator Module
Air Bags:Frontal:Sensor/Control Module-Inactive
Air Bags:Knee Bolster
Air Bags:On-Off Switch Assembly
- In its July 29, 2011 response to ODI's May 27, 2011 information request letter, Chrysler provided 153 MY 2007-2008 owner reports, additional to the 28 ODI Vehicle Owner Questionnaires (VOQs), which related to the illumination of the air bag light (ABL) due to a faulty clockspring (CS) wiring circuit.The right hand drive (RHD) vehicles, which were first produced in MY 2008 and account for only 1% of vehicle production, accounted for 82 of these 181 reports (45%).The MY2007 left hand drive (LHD) vehicle accounted for 61 of the remaining 92 LHD reports and exhibited a higher complaint rate than the MY 2008 LHD vehicles.ODI did not identify any incidents of crashes/injuries attributable to the CS circuit failure.Since May 27, 2011, ODI has received another 32 consumer complaints bringing the total to 213 reports at this closing.In addition, and for comparative purposes, Chrysler provided another 42 owner reports it received on the MY2006 and MY2009-2010 Wrangler vehicles; these populations showed a lower incident rate than the subject vehicles, especially in comparison to the RHD subject vehicles. Chrysler's investigation showed that the higher rate of RHD Wrangler CS failures were due to a more severe duty cycle for these vehicles which are primarily used by US Postal workers/mail carriers delivering mail in rural regions.Chrysler concluded the unique vehicle usage, much of which occurs with the driver's window open and under dusty environmental conditions, is the cause of premature CS failure.Chrysler's analysis also indicated that the somewhat elevated MY2007 LHD rate, which showed a declining failure trend, was the result of start-up production/assembly issues that occurred with the introduction of a new design CS.The new design CS incorporated both dual airbag inflator circuitry and a steering wheel angle sensor (for the electronic stability control system).On November 1, 2011, Chrysler submitted a defect notice indicating it will conduct a recall of all MY 2008-2012 RHD Wrangler vehicles (11V528).The estimated 5,334 RHD Wrangler vehicles include the 2,297 MY 2008 RHD Wrangler vehicles, which were the subject of this investigation, plus an additional 3,037 MY 2009-2012 RHD Wrangler vehicles that Chrysler determined potentially have a similar CS concern as the MY 2008 RHD vehicles.Chrysler intends to replace the existing CS with a yet-to-be-produced improved CS assembly, or an improved steering housing assembly that is less susceptible to dusty environments.Owner notice is scheduled to begin in November, 2011.Chrysler also informed ODI that it intends to initiate a consumer satisfaction campaign for MY2007 LHD Wrangler which will extend the CS warranty coverage for 10 years or 150,000 miles.Accordingly the investigation is closed.
- Documents (12)
- CHRYSLER 8-5-2011 LETTER TO ODI WITH ENCLOSURE 12 - PART SALES
- CLOSING RESUME APPROVED
- CHRYSLER 7-29-2011 LETTER TO ODI WITH ENCLOSURE 7 DIAGNOSTIC TROUBLE CODES
- OPENING RESUME APPROVED
- IR TO MFR TO INVESTIGATE ALLEGATIONS OF AIRBAG LIGHT ILLUMINATION. * 05/27/2011 * P
- MFR RESPONSE EXTENSION - MFR'S REQUEST FOR AN EXTENSION - (EXTENSION REQUESTED ON JULY 7, 2011 - TWO WEEK EXTENSION FOR QUESTIONS 1 THRU 6, NEW DUE DATE, JULY 29, 2011. EXTENSION GRANTED UNTIL AUGUST 5, 2011 FOR QUESTIONS 7 THRU 13 * 07/07/2011 * P
- X41 TECHNICAL SERVICE BULLETIN DATED DECEMBER 21, 2011.
- SAMPLE DEALER AND OWNER LETTER TEMPLATES DATED DECEMBER 21, 2011.
- CHRYSLER 7-29-2011, ENCLOSURE 4 - FIELD DATA, FIELD REPORTS & LEGAL
- MFR IR RESPONSE DATA
- MFR IR RESPONSE DATA
- CHRYSLER 7-29-2011, ENCLOSURE 1 - PRODUCTION DATA [ACCESS DATEBASE]
Click a tab for more information.